2000 Chevrolet Venture

SUBJECT VEHICLES ARE AVAILABLE WITH AN OPTIONAL POWER SLIDING DOOR.THE INTERIOR HANDLE IS ORIENTED IN THE VERTICAL POSITION IN THE DOOR PANEL AND LINES UP AT THE ELBOW LEVEL WHEN THE OCCUPANT IS SEATED IN THE 2ND-ROW OUTBOARD POSITION.IF THE OCCUPANT HOLDS THE INTERIOR HANDLE IN THE THUMB UP POSITION DURING POWER-ASSISTED OPENING, THE ARM/WRIST CAN BE PUSH BACK WITH FORCE AGAINST THE 2ND-ROW BUCKET SEAT OR CAPTAIN'S CHAIR SEAT BACK CREATING A RISK OF INJURY (OTHER SEATING CONFIGURATIONS HAVE AMPLE SEAT TO DOOR CLEARANCE TO AVOID ENTRAPMENT OF THE LOWER ARM).AMONG THE 103 TOTAL REPORTS, THERE WERE 102 ALLEGED INJURIES INCLUDING ARM/WRIST, THUMB AND SHOULDER INJURIES.A COUNT OF INJURIES REVEALS THAT 76 INJURIES WERE A FRACTURED OR A BROKEN ARM/WRIST REQUIRING AN IMMOBILIZING CAST FOR FOUR-TO-SIX WEEKS.ALL INJURIES INVOLVE THE RIGHT SIDE POWER SLIDING DOOR.THE LEFT SIDE POWER SLIDING DOOR IS ON FAR FEWER VEHICLES, BUT MORE IMPORTANTLY, IT PRODUCES LESS FORCE.GM NOTIFIED THE AGENCY BY LETTER DATED DECEMBER 21, 2004, THAT IT WILL RECALL MODEL YEAR 1997 THOUGH EARLY 2005 GM U-VAN VEHICLES EQUIPPED WITH A RIGHT SIDE POWER SLIDING DOOR AND WITH 2ND-ROW BUCKET SEATS OR CAPTAIN CHAIRS (NHTSA RECALL #04V597).AS PART OF THE RECALL REMEDY, GM WILL REPLACE THE DOOR HANDLE WITH A FLUSH MOUNTED HANDLE THAT WILL PREVENT AN OCCUPANT FROM GRASPING THE HANDLE WITH THE PALM BETWEEN THE HANDLE AND DOOR PANEL (THUMB UP ORIENTATION) AND THUS ELIMINATE THE POTENTIAL FOR ARM/WRIST ENTRAPMENT.THIS INVESTIGATION IS CLOSED.

There is no summary currently available

In January 2022, I noticed white smoke coming from the engine and a mechanic said it was the water pump that needed to be replaced, so I have it replaced. Recently, I noticed the same white smoke coming from the engine and took it back to the same mechanic who installed the water pump. The mechanic said it was the intake manifold that caused the white smoke. I decided to take it to another mechanic to see if the first diagnosis was correct and that mechanic confirmed the first mechanic's diagnosis and my previous experience with another GM vehicle (1997 Vhevy Lumina) that had the exact same problem: water pump went out and intake manifold also started to fail until the Lumina's engine was fried.

NHTSA ID

11488379

Incident

Sep 26, 2022

Car is losing coolant quickly, even though I have replaced the water pump about a month ago. Due to GM Manufactuing, they only allow Dex Cool coolant for their vehicles but not everyone carries Dex Cool. Also, the oxygen sensor code need to be read oxygen sensor only and not with 4 or 5 other codes.

NHTSA ID

11450671

Incident

Feb 6, 2022

AIR BAG LIGHT WILL NOT TURN OFF, THERE IS NO WAY TO FIX IT AS THEY DON'T MAKE THE PARTS ANYMORE, NOT SURE IF AIRBAG WILL DEPLOY IF EVER NEEDED.

NHTSA ID

11349149

Incident

Aug 9, 2020

Mileage

105,000 mi

WAS DRIVING FORWARD COMING UP TO AN INTERSECTION AND APPROACHING A RED LIGHT WHEN THE BRAKES WENT OUT .WHEN TRYING TO STOP AND PUSH THE BRAKE DOWN IT STARTED SHAKING AND THE BRAKE CAME UP AND THEN WHEN PUSHED IT BACK DOWN IT WENT TO THE FLOOR AND THE BRAKES WERE COMPLETELY OUT. THEM GOING OUT CAUSED US TO ROLL THROUGH THE INTERSECTION CAUSING US TO GET HIT BY A VEHICLE COMING THROUGH THE LIGHT, SPINNING US AROUND AND GOT HIT MORE THAN ONCE. HIT US ON BOTH SIDES OF VEHICLE AND WINDOWS WERE SHATTERED OUT BUT NOT ONE AIR BAG WENT OFF/DEPLOYED AT ALL AND THE VEHICLE WAS TOTALLED.THERE WERE 3 BABIES IN THE VEHICLE WHEN THE AIR BAGS DID NOT DEPLOY.

NHTSA ID

11310811

Incident

Feb 20, 2020

Mileage

137,000 mi

BOUGHT 4 NEW GOODYEAR VIVA 2 TIRES AT WALMART IN APPROXIMATELY 2014 SOMETIME. ACCORDING TO LOCAL TIRE SHOP THEY HAVE 2014 DATE CODES. VAN STARTED DEVELOPING A LOW SPEED WOBBLE WHEN DRIVING. FRONT L TIRE WAS LOW ON PRESSURE SO TOOK TO A LOCA SHOP TO HAVE IT CHECKED THINKING I JUST NEEDED A PATCH. WRONG! THE SHOP DISCOVERED A TREAD SEPARATION ON THE INSIDE SIDEWALL! LUCKILY I WAS NOT DRIVING ON THE HIGHWAY. AFTER COMING HERE AND READING ALL THE OTHER ALMOST IDENTICAL COMPLAINTS TO ME IT LOOKS LIKE THERE IS A TREND OF BULGING/POOR RIDE QUALITY/BLOWOUTS AND TREAD SEPARATION FROM THESE WALMART GOODYEARS. LUCKILY I ONLY MADE A 2 MILE ROUND TRIP FROM HOME TO A FRIENDS AND I WAS ABLE TO CATCH THIS BEFORE I HAD A BLOWOUT.

NHTSA ID

10898412

Incident

Aug 23, 2016

Mileage

150,000 mi

TL* THE CONTACT OWNED A 2000 CHEVROLET VENTURE. AFTER BEING PARKED FOR TWO DAYS, THE VEHICLE SUDDENLY CAUGHT FIRE. THE CONTACT MENTIONED THAT THE FIRE ORIGINATED IN THE ENGINE COMPARTMENT AND CAUSED A GARAGE LOCATED NEXT TO THE VEHICLE TO CATCH FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THERE WERE NO INJURIES. THE VEHICLE WAS DESTROYED. THE FAILURE MILEAGE WAS 115,000.

NHTSA ID

10705572

Incident

May 6, 2014

Mileage

115,000 mi

PLEASE INVESTIGATE INCIDENTS OF FAILURE OF THE GM PASSKEY/PASSLOCK/VATS SECURITY SYSTEM. SECURITY LIGHT WOULD FLASH AND VEHICLE EXPERIENCED A TOTAL LOSS OF POWER. PROBLEM OCCURRED INTERMITTENTLY FOR THE NEXT SEVERAL MONTHS, AT VARIOUS SPEEDS. NO ACCIDENTS INVOLVED, BUT SEVERAL NEAR MISSES. PROBLEM OCCURRED VERY FREQUENTLY IN THE PAST WEEK, AND NOW VEHICLE WILL NOT START DUE TO SECURITY FEATURE. I AM USING FACTORY ORIGINAL KEYS, NOT REPLACEMENTS. PROBLEM AFFECTS THIS PARTICULAR MAKE AND MODEL, BUT IT IS SO SYSTEMIC TO GM, AN ENTIRE AFTERMARKET INDUSTRY HAS ARISEN TO BYPASS THIS SECURITY "FEATURE." *TR

NHTSA ID

10637152

Incident

May 26, 2014

Mileage

130,000 mi

TL* THE CONTACT OWNS A 2000 CHEVROLET VENTURE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE SEAT BELT WARNING LIGHT ILLUMINATED CONTINUOUSLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN RECALL NHTSA CAMPAIGN ID NUMBER: 00V228003 (SEAT BELT). THE APPROXIMATE FAILURE MILEAGE WAS 186,000.

NHTSA ID

10633147

Incident

Sep 3, 2014

Mileage

186,000 mi

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.

This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.

Vehicle Wide Programming (VWP) is a new process to update software on GM Vehicles. It provides the ability via a single selection within Techline Connect to first identify which modules need updating and then proceed to updating affected modules (with some exceptions). The updating of modules is completed in parallel instead of the technician needing to update one module at a time. This allows a more streamlined approach for dealers and customers.

GM is receiving damaged (cracked or broken) transmission cores returned to the reman facilities. The damage is being caused either in the removal process by the technician, or inadequate packaging or shipping. This bulletin advises the dealers to be more careful not to damage the transmissions during removal and to package the core properly for return.

This service bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels should be used to reduce carbon build-up.