2005 Chevrolet Venture

ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]

ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.

The contact owns a 2005 Chevrolet Venture. The contact stated that while his father was driving at an undisclosed speed on the highway, the vehicle suddenly lost automotive power. No warning lights illuminated. In addition, the contact stated that his father managed to pull over to the shoulder of the road, and upon further inspection, white/blue smoke was seen coming from under the vehicle, and the vehicle later caught on fire from the fuel pump/tank. The fire had leaked onto the floor; however, it had extinguished on its own. A police report was not filed; however, Law Enforcement arrived on scene to direct traffic. The local fire department did not arrive on scene. No injuries were sustained, nor medical attention was sought. The vehicle failed to restart. The vehicle was towed to a local tow yard, where it was deemed a total loss by the insurance provider. The local dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 116,000.

NHTSA ID

11722553

Incident

Dec 15, 2025

Mileage

116,000 mi

The contact owns a 2005 Chevrolet Venture. The contact stated that while driving at various speeds, the vehicle was making a rattling sound coming from the front passenger’s side of the vehicle. There were no warning lights illuminated. The contact took the vehicle to a certified mechanic who replaced the wheel bearing hub assembly, brakes, rotors, struts, and tires. The failure persisted. The contact took the vehicle to another certified mechanic who performed a front-end alignment however, the failure persisted. The vehicle was taken to a third mechanic who identified that the noise seemed to be coming from the steering wheel; however, the mechanic could not verify the cause of the failure. The vehicle had not been repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 236,000.

NHTSA ID

11490992

Incident

Oct 26, 2021

Mileage

236,000 mi

TL* THE CONTACT OWNED A 2005 CHEVROLET VENTURE. WHILE DRIVING APPROXIMATELY 35 MPH IN THE RAIN, THE VEHICLE HYDROPLANED TO THE LEFT AND THEN BACK TO ITS LANE. THE REAR TIRES ROLLED OFF THE ROAD AND CAUSED THE VEHICLE TO CRASH INTO A DITCH. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED INJURIES THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS TOWED TO A BODY SHOP AND DEEMED DESTROYED BY THE INSURANCE COMPANY. THE FAILURE MILEAGE WAS 130,000.

NHTSA ID

10991158

Incident

May 10, 2017

Mileage

130,000 mi

MY WIFE HIT A OLD STYLE VAN THAT HAD STOPPED FOR A DOG CROSSING A THE ROAD. THE WHOLE FRONT END HAD TO BE REPLACED. HOOD, GRILL, LIGHTS, BOTH FENDER HAD TO BE REPAIRED, ALSO THE STEAL TUBE UNDER THE RADIATOR FRAME HAD TO BE CUT OUT AND REPLACED. ON 11/5/2010 I HIT A DEER GOING 30 MPH, AGAIN FRONT END DAMAGE. BOTH TIMES THE AIR BAGS DIDN'T DEPLOY, AND ON STAR DIDN'T RESPOND. I ASKED TWO DIFFERENT CHEVROLET DEALERS IF THE AIR BAG SENSOR COULD BE TESTED, ANSWER WAS NO.

NHTSA ID

10747955

Incident

Jan 25, 2010

Mileage

49,357 mi

WE HAVE BEEN SMELLING GASOLINE FUMES IN AND OUTSIDE OUR VAN. SOMETIMES IT IS VERY POTENT AND OTHER TIMES FAINT. WHEN WE WALK INTO OUR GARAGE, WE CAN SMELL IT ALSO. IT OCCURS OFTEN WHEN MAKING A LEFT-HAND TURN. WHEN WE INSPECT IT, WE CAN'T FIND ANY LEAK. WE SMELL THIS FROM A HALF TANK TO EMPTY. *TR

NHTSA ID

10683516

Incident

Jan 1, 2015

Mileage

225,000 mi

2005 CHEVROLET VENTURA. CONSUMER WRITES IN REGARDS TO NON-DEPLOYMENT OF AIR BAGS. *SMD THE CONSUMER STATED HIS FATHER AND STEP-MOTHER WERE INVOLVED IN AN ACCIDENT. HIS FATHER DIED FROM HIS INJURIES AND HIS STEP-MOTHER WAS INJURED. THE CONSUMER STATED HIS FATHER HIT A DIRT BANK HEAD-ON AND THE AIR BAGS FAILED TO DEPLOY. AS A RESULT, HIS FATHER HIT THE STEERING WHEEL WITH HIS CHEST CAUSING DAMAGE TO HIS LUNGS, SPLEEN, KIDNEYS AND RIBS. HIS STEP-MOTHER HIT THE DASH AND CENTER CONSOLE WITH HER HEAD, CUTTING HER ACROSS THE FOREHEAD. *JB

NHTSA ID

10651206

Incident

Oct 15, 2012

TL * THE CONTACT OWNS A 2005 CHEVROLET VENTURE. THE CONTACT STATED THAT THE FRONT PASSENGER SIDE SEAT BELT BUCKLE RELEASE MECHANISM FRACTURED. THE DEALER ORDERED A SEAT BELT MOUNTING KIT TO PERFORM THE REPAIR. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 90,000. UPDATED 10/24/2014*LJ UPDATED 7/14/2015*JS

NHTSA ID

10619552

Incident

Jul 9, 2014

Mileage

90,000 mi

TL* THE CONTACT OWNS A 2005 CHEVROLET VENTURE. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT SMELLED FUEL WITHIN THE CABIN OF THE VEHICLE. THE DEALER WAS UNABLE TO DIAGNOSE THE CAUSE OF THE FUEL ODOR. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 85,000.

NHTSA ID

10608071

Incident

Dec 16, 2013

Mileage

85,000 mi

This PI communicates the requirement to provide a pico file to receive diagnostic assistance from TAC.

This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.

This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.

This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.

This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the noise for assessment by engineering. Technician will need to call General Motors Technical Assistance Center for further assistance.

This Preliminary Information communication provides information to the technician about the use of J-35616-64B terminal test probe, replacement terminals, and terminated leads. The J-35616-64B is the latest test probe released for checking tension or probing the .64 series terminals. The test probe terminal has been released in the terminal repair kit (J-38125-620H) located in Lear Tray 7 part number 963716-2. There are 5 terminated leads in a package part number is 13505346, which can be ordered through your normal General Motors Customer Care and Aftersales parts channel.