1997 Chevrolet Venture

MR. DENNIS FIKE OF ELKRIDGE, MD, SUBMITTED A PETITION TO NHTSA BY LETTER DATED JANUARY 13, 2004, ALLEGING THAT A GM DEALER INFORMED HIM THAT HIS VAN WAS NOT INCLUDED IN SAFETY RECALL 02V286 AND CHARGED HIM FOR THE REPLACEMENT OF THE STEERING RACK AND PINION UNIT.MR. FIKE BELIEVES THAT HIS VAN SHOULD HAVE BEEN INCLUDED AND THAT THE REPAIR SHOULD HAVE BEEN PERFORMED WITHOUT CHARGE TO HIM.THE RECALL IN QUESTION ADDRESSED STEERING RACK AND PINION UNIT LOWER PINION BEARING FAILURES ON CERTAIN MY 1996 THROUGH 1998 GM VEHICLES.THE RECALL REMEDY WAS TO INSPECT AND REPLACE THE STEERING GEAR PINION BEARING.IF THE INSPECTION INDICATED THAT THE BEARING FAILURE DAMAGED THE STEERING GEAR, THEN THE STEERING GEAR ASSEMBLY WAS BE REPLACED.GM INFORMED ODI THAT MR. FIKE?S VEHICLE WAS COVERED AND THAT THE RECALL REMEDY WAS PERFORMED ON FEBRUARY 25, 2003.THE ENTIRE RACK AND PINION UNIT WAS REPLACED.BECAUSE MR. FIKE HAD A SUBSEQUENT FAILURE WITH THIS UNIT, ON JANUARY 20, 2004, ODISUGGESTED THAT HE CONTACT THE DEALER FOR REIMBURSEMENT OF THE CHARGE FOR REPLACING THE FAILED RACK AND PINION UNIT IN HIS VEHICLE BECAUSE GM WARRANTS ITS REPLACEMENT PARTS FOR 12 MONTHS OR 12,000 MILES, WHICH EVER COMES FIRST.MR. FIKE INFORMED ODI ON MARCH 3, 2004, THAT HE HAD RECEIVED AN REIMBURSEMENT CHECK FROM GM.

ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE. THE TRAILING ARM DESIGN IN THESE VEHICLES HAS BEEN USED IN THE U-VAN FROM MY 1997 THROUGH THE PRESENT.THE GM ANALYSIS CONCLUDED THAT THE SUBJECT TRAILING ARMS COULD CRACK OR BUCKLE IF THEY WERE DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR SUBJECTED TO CERTAIN SERVICE RELATED ABUSE CONDITIONS SUCH AS IMPROPER TOWING OR JACKING.ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 19 INCIDENTS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES.THERE HAVE BEEN NO NEW REPORTS TO ODI OR GM IN THE LAST 12 MONTHS AND ONLY ONE NEW COMPLAINT IN THE LAST 21 MONTHS. DUE TO THE LOW COMPLAINT RATE AND THE ABSENCE OF A CONTINUING TREND IN REPORTED FAILURES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.

ODI IDENTIFIED 59 REPORTS WITH THE ALLEGED DEFECT.ODI WAS ABLE TO CONTACT 44 OF THE 59 CONSUMERS IN ORDER TO DETERMINE THE SPECIFIC CAUSE OF THE LATCH PROBLEMS.OF THE 44 OWNERS CONTACTED, ODI DETERMINED THAT FOUR FAILURES WERE DUE TO AN OUT-OF-TOLERANCE LATCH PLATE, AND THAT 23 FAILURES WERE DUE TO A DISPLACED BUCKLE HOUSING COVER.THE REMAINING 17 FAILURES HAD INDETERMINABLE CAUSES.OF THE 59 REPORTS, THERE WERE THREE ALLEGED MINOR INJURIES.NO LEGAL CLAIMS OR LAWSUITS HAVE BEEN FILED WITH REGARD TO THIS ALLEGED DEFECT.BASED ON THE LIMITED NUMBER OF REPORTS, AND A DECLINING REPORT TREND, THIS INVESTIGATION IS CLOSED.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEARED TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ADDITIONAL SUMMARY REPORT.

THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.

STEERING LOCKED UP ON '97 VENTURE VAN WHILE BEING OPERATED AT 70 MPH ON A STRAIGHT HIGHWAY. VEHICLE HAD TO BE TOWED, RACK AND PINION AND STEERING PUMP REPLACED.

NHTSA ID

11013139

Incident

Apr 11, 2017

Mileage

58,000 mi

TL* THE CONTACT OWNS A 1997 CHEVROLET VENTURE. WITHIN LESS THAN 30 DAYS OF OWNING THE VEHICLE, THE SERVICE ENGINE LIGHT AND THE COOLANT LIGHT RANDOMLY KEPT ILLUMINATING. THE CONTACT STATED THAT THE VEHICLE OVERHEATED. THE MECHANIC WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS AWAITING THE DIAGNOSTIC RESULTS. THE CONTACT RECEIVED NO SOLUTION FROM THE MECHANIC AND WAS UNCERTAIN OF WHAT NEEDED TO BE REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS NOT AVAILABLE.

NHTSA ID

10892584

Incident

Jul 18, 2016

REAR BRAKE LAMPS KEEP FAILING, LIGHT BAR ON TOP WORKS FINE BUT BOTH SIDE REAR BRAKE LAMPS FAIL CONTINUOUSLY. UPON DISASSEMBLY OF BRAKE LIGHT ONE CAN SEE THE SOCKETS AND BULB CONTACTS ARE MELTING. THIS VAN HAS ALREADY HAD THE ENTIRE REAR LIGHT ASSEMBLY ON EACH SIDE REPLACED BUT PROBLEM IS RECURRING. CLEANING/SANDING SOCKETS WORKS TEMPORARILY BUT PROBLEM RETURNS WITHIN A COUPLE OF WEEKS. BULB REPLACEMENT ALONE DOES NOT WORK. FILAMENTS IN BULBS ARE NOT BURNT OUT BUT CONTACTS ON BULBS AND SOCKETS ARE BURNT. THIS ONLY AFFECTS THE CIRCUIT THE BRAKE LIGHT FILAMENT IS ON, THE TAILLIGHTS (WHICH SHARE THE SAME MULTIFILAMENT BULB) ARE NOT AFFECTED. UPON FURTHER RESEARCH IT'S QUITE APPARENT THIS IS A PROBLEM VERY COMMON ACROSS MOST OR ALL MODEL YEARS OF THIS VAN. THIS IS A SAFETY ISSUE FOR THE OCCUPANTS - THE LIGHTS CAN (AND WILL) FAIL WITHOUT NOTICE LEAVING DRIVER VULNERABLE TO COLLISIONS FROM BEHIND DUE TO INADEQUATE SIGNALING. *TR

NHTSA ID

10503490

Incident

Apr 11, 2012

Mileage

156,000 mi

I BOUGHT 4 PEP BOYS DEFINITY TIRES W ROAD HASARD TOTAL WAS 424.58 ON 9/10/201. MILEAGE WAS152156..YESTERDAY 9/1/2011 IHAD A BLOW OUT ON L REAR TIRE. THE MILEAGE WAS158180. THEY TOLD ME IT WOULD BE PRO RATED,ONLY 6,000 MILES AND IT COST ME 41.52 FOR ANOTHER TIRE. IT COULDNT BE FIXED. WHAT WAS THE ROAD HAZZARD FOR? PS THEY OFFERED ME A OIL CHANGE AS A SETTELMENT. I TOLD THEM NO THANKS! *TR

NHTSA ID

10423034

Incident

Sep 1, 2011

Mileage

158,180 mi

1997 CHEVROLET VENTURE, UNIT 1 WAS EASTBOUND IN THE FAR RIGHT LANE. THE HOOD APPARENTLY WAS NOT LATCHED PROPERLY, FLEW UP AND BACK, SHATTERING THE WINDSHIELD. UPDATED 04/04/2011 *BF (OHIO TRAFFIC CRASH REPORT #10-0175-90)*JB UPDATED 04/22/11 *BF

NHTSA ID

10394927

Incident

Feb 26, 2011

1997 CHEVROLET VENTURE, CAUGHT FIRE AND BECAME FULLY ENGULFED CAUSING TOTAL DAMAGE. *BF ACCORDING TO THE POLICE REPORT, THE VEHICLE HAD ENGINE TROUBLE. (OHIO TRAFFIC CRASH REPORT # 10-0318-89)*JB UPDATED 09/13/10*BF

NHTSA ID

10354249

Incident

Jul 31, 2010

I HAVE OWNED 3 CHEVY VENTURE MINIVANS OVER THE PAST 10 YEARS. ALL OF THEM HAD THE SAME PROBLEMS, THE SIGNAL AND HEAD LIGHTS GO OUT, THE WINDOW SWITCH GOES OUT AND FINALLY THE HEAD GASKET GOES. THEY RUN GREAT UNTIL THE DAY IT STARTS OVERHEATING, THEN YOUR OUT A VEHICLE. EVERYONE I KNOW WHO HAS A VENTURE HAS HAD AT LEAST ONE OF THESE PROBLEMS WITH THEIR VEHICLE. *TR

NHTSA ID

10329161

Incident

Dec 18, 2009

Mileage

99,998 mi

TL*THE CONTACT OWNS A 1997 CHEVROLET VENTURE. THE CONTACT STATED THAT THE ANTIFREEZE IN HER VEHICLE HAS CORRODED THE RADIATOR, WATER PUMP, THERMOSTAT, AND INTAKE VALVE. THIS IS THE COOLANT THAT WAS LISTED IN THE OWNER'S MANUAL AND IS ALWAYS USED IN HER VEHICLE. A RECALL WAS SENT TO CHEVROLET CONSUMERS, BUT IT WAS NOT ISSUED BY NHTSA. THE MANUFACTURER STATED THAT THEY COULD NOT ASSIST WITH THE REPAIRS. THE FAILURE MILEAGE WAS 122,000.

NHTSA ID

10265521

Incident

Dec 28, 2008

Mileage

122,000 mi

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.  The PI update to version D is to advise the unlock procedure is temporarily unavailable.  E version update is to add administrative details.

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.  The PI update to version D is to advise the unlock procedure is temporarily unavailable.