1997 Chevrolet Malibu

IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.

GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.

THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.

ODI HAS RECEIVED 200 COMPLAINTS FROMT CONSUMERS AND 1,238 FROM GM ALLEGING FAILURE OR LOCKUP OF THE STEERING RACK AND PINION UNIT (R&P).THIS ALLEGED CONDITION CAN RESULT IN THE LOSS OF STEERING CONTROL OF THE VEHICLE AND A CRASH CAN RESULT.GM HAS REPORTED SIX CRASHES IN WHICH EIGHT PEOPLE HAVE SUSTAINED INJURIES RANGING FROM BRUISES, AIRBAG BURN, SEAT BELT ABRASION, FACIAL INJURY, NECK AND BACK PAIN.ALL CRASHES WERE SINGLE VEHICLE CRASHES.GM STATES THAT ONE POSSIBLE FAILURE MODE IS FAILURE OF THE LOWER PINION BEARING IN THE R&P.AN ENGINEERING ANALYSIS HAS BEEN OPENED TO DETERMINE IF A SAFETY DEFECT TREND EXISTS.

Theft light. Car won’t start it’s happened 20 times in the last 6 months. I was driving and theft light caused everything to shut down. This is a dangerous thing that needs to be fixed

NHTSA ID

11433505

Incident

Aug 2, 2021

Theft light keeps coming on, my car will stop when it happens. This has happened while driving. And will not start. I’ve had the recall fixed years ago that was said to be the reason. It didn’t fix the problem

NHTSA ID

11422206

Incident

May 1, 2020

MY THIEF LIGHT STARTS BLINKING AND MY CAR WILL NOT START. THIS HAS HAPPENED 3 TIMES THIS PAST MONTH. I WAS TOLD IT WAS THE PASSLOCK TO TURN CAR IN ON POSITION FOR 10 MINUTES OR UNTIL LIGHT STOPS BLINKING THEN IT WOULD START. THIS IS A SAFETY ISSUES THAT NEEDS TO BE FIXED BEFORE IT HAPPENS WHILE DRIVING

NHTSA ID

11386109

Incident

Jan 2, 2021

WAS DRIVING ON INTERSTATE WHEN CAR COMPLETELY SHUT OFF, LOST ALL POWER , NO POWER STEERING OR POWER BRAKES. SECOND TIME, CAME TO A STOP ON CITY STREET AND CAR SHUT OFF AGAIN , NO POWER , NO POWER STEERING OR POWER BRAKES AGAIN. CAR HAD TO BE TOWED. THIS HAPPENED AFTER I PAID MODERN CHEVROLET TO FIX THE ISSUE WHICH IGNITION SWITCH WAS FOUND TO BE AT FAULT. (NHTSA REFERENCE NUMBER-14V400000) AFFECTED NUMBER- 5,877,718

NHTSA ID

11364879

Incident

Oct 13, 2020

Mileage

130,000 mi

MY IGNITION SWITCH AND CYLINDER KEPT TURNING MY CAR OFF WHEN I STARTED IT. ALSO WHILE I WAS DRIVING THE CAR WOULD JUST CUT OFF..NOW IT GOT TO THE POINT WHERE I HAVE TO REPLACE THE PIECE. *TR

NHTSA ID

11323867

Incident

Apr 6, 2020

I HAVE HAD TO CHANGE THE PASSENGER CALIPER AND ROTORS TWICE BECAUSE THE BOLTS FOR THE CALIPER KEEPS POPPING OUT AND THE BOLTS FOR THE BRACKET KEEPS POPPING OUT.. MY WINDSHIELD WIPER ON THE PASSENGER SIDE WENT OUT LAST MONTH..LAST NIGHT THE CAR WOULDN'T START UP ANYMORE WHEN I DO TURN THE KEY THE LIGHTS COME ON BUT WHEN I TRY TO START THE CAR UP I GET A CLICKING NOISE, THE RADIO KEPT GOING IN AND OUT ALSO. NOW MY O2 SENSORS AND TRIPPING. I'VE HAD TO CHANGE THE EGR VALVE BECAUSE IT KEPT GETTING STUCK IN OPEN POSITION AND I ALSO CHANGED THE BELT

NHTSA ID

11322384

Incident

Apr 26, 2020

I WAS DRIVING ON A RESIDENTIAL STREET AND REALIZED I WAS GOING THE WRONG WAY. I TURNED LEFT TO MAKE A U-TURN AND DROVE ONTO THE EASEMENT (DIRT). WHEN I TURNED THE STEERING WHEEL TO THE LEFT ALL THE WAY, BOTH AIRBAGS DEPLOYED. I WAS BURNED BY THE CHEMICALS OVER THE LEFT SIDE OF MY NECK AND CHEST, LEFT EAR AND INSIDE LEFT WRIST. I WAS TRAVELING LESS THAN 5 MPH WHILE MAKING THIS TURN. THE PASSENGER AIRBAG KNOCKED MY WINDOW CAMERA OFF AND BROKE IT AND SENT PART OF A HANDHELD FAN CLIPPED TO THE PASSENGERS VISOR, INTO MY HEAD AND ENDED UP IN THE BACKSEAT. I DID NOT HIT ANYTHING AS IT WAS JUST DIRT.

NHTSA ID

11289715

Incident

Dec 17, 2019

Mileage

83,501 mi

TL* THE CONTACT OWNS A 1997 CHEVROLET MALIBU. THE CONTACT HAD TROUBLE STARTING THE VEHICLE AND THE ANTI-THEFT SYSTEM WARNING INDICATOR ILLUMINATED. AFTER TEN MINUTES, THE VEHICLE WAS OPERABLE. THE CONTACT STATED THAT THE FAILURE OCCURRED TWICE A MONTH. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 80,000. *LN CONSUMER STATED HAD TO KEEP KEY IN IGNITION FOR 10 MINUTES IN A POSITION NOT GOOD NOT SAFE, CHANCE OF BATTERY DYING. I'M ALSO AFRAID THEFT SYSTEM LIGHT WILL COME ON AND LOCK CAR UP WHILE DRIVING. UPDATED 7/25/18*JB

NHTSA ID

11032630

Incident

Oct 9, 2017

Mileage

80,000 mi

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.  The PI update to version D is to advise the unlock procedure is temporarily unavailable.  E version update is to add administrative details.

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.  The PI update to version D is to advise the unlock procedure is temporarily unavailable.