1998 Chevrolet Malibu

IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.

GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.

ON FEBRUARY 22, 2000, THE OFFICE OF DEFECTS INVESTIGATION (ODI) INITIATED PE00-009 BASED ON SEVEN REPORTS OF WINDSHIELD WIPER FAILURE IN CERTAIN MODEL YEAR (MY) 1997 & 1998 CHEVROLET MALIBU & OLDSMOBILE CUTLASS VEHICLES.THE INVESTIGATION WAS UPGRADED TO EA00-019 ON JULY 12, 2000.DURING THE COURSE OF THE INVESTIGATION, IT WAS FOUND THAT THE FAILURES WERE THE RESULT OF FRACTURE OF THE PASSENGER-SIDE WINDSHIELD WIPER PIVOT HOUSING (SUBJECT COMPONENT).SUCH A FRACTURE LED TO AN IMMEDIATE AND IRRECOVERABLE LOSS OF WINDSHIELD WIPER FUNCTION.GMREPORTED THAT THE MATERIAL COMPOSITION (50% GLASS-REINFORCED ACETAL) OF THE SUBJECT COMPONENT WAS INSUFFICIENT TO WITHSTAND STRESSES IMPOSED BY CERTAIN FROZEN PRECIPITIATION ACCUMULATIONS.THE SUBJECT COMPONENT MATERIAL WAS CHANGED TO THE STRONGER 50% GLASS-REINFORCEDNYLON-6, EFFECTIVE JANUARY 98.OBSOLETE SERVICE PART WERE DISCARDED.GM WILL REPLACE THE SUBJECT COMPONENTS IN 129,427 SUBJECT VEHICLES FOUND IN 28 STATES (AK, CO, CT, DE, ID, IL, IN, IA ME, MD, MA, MI, MN, MT, NE, NH, NJ, NY, ND, OH, PA, RI, SD, UT, VT, WV, WI, WY), THE DISTRICT OF COLUMBIA, AND ALL CANADIAN PROVINCES.THESE STATES ACCOUNTED FOR 91% OF THE CONSUMER COMPLAINTS IDENTIFIED ABOVE.ODI WILL MONITOR THIS COMPAIGN FOR ADEQUATE EFFCTIVENESS AND, IF NECESSARY, TAKE FURTHER ACTION IN THE FUTURE.FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS MATTER IS UNJUSTIFIED AT THIS TIME.THE ENGINEERING ANALYSIS IS CLOSED.

There is no summary currently available

Front seat belts come unbuckled while driving. My wife commuted to work in this car for about 12 months (37 miles one way) and mentioned that sometimes the seatbelt would come unbuckled. I suspected that she was not getting it latched in properly and did not think much of it as when I looked at the seatbelt it functioned properly. However our daughter started driving this car to and from school and also mentioned issues with the seatbelt occasionally coming unbuckled, unfortunately she was involved in a collision. When we learned that she did not have her seatbelt on it surprised us. When my aunt and uncle who owned the car visited in the hospital, my aunt mentioned that she also has had the seatbelt randomly come unbuckled multiple times in that car. I purchased seatbelts from cars of the same age and platform (1997-2004 GM N body) and have inspected them. I believe there is a design flaw that allows the seatbelt to latch in and feel secure when it is actually not locked in. In my pictures note the scratches on the release button. It is my feeling that normal debris (hair, lint, ect) may be causing the release button to partially stick down (1/8" or so). When the release button is stuck partially down the belt side can be inserted into the buckle and it will latch with a click sound, however the white plastic lock tab will not drop under the lock rod. In this latched but not locked situation the belt can be pulled on with a fair amount of force and still stay latched. When compared to other seat belt styles from other models of cars, I notice that the release button or cover have a smaller "slide surface area". Also on the other seat belt styles if the release button is stuck partially down the belt will not latch into the buckle.

NHTSA ID

11525299

Incident

Oct 10, 2022

I WAS A AUTOMOTIVE MANUFACTURERS REP AND UNDERSTAND THE IMPORTANCE OF GETTING THESE RECALLS COMPLETED. I HAVE HAD MY 2 KEYS RETROFITTED WITH THE INSERTS BY MY LOCAL CHEV DEALER YEARS AGO AND TRIED 6 TIMES UNSUCCESSFULLY TO HAVE THIS RECALL SHOWN AS COMPLETED. I WAS ASSURED THAT THEY MADE A MISTAKE AND USED A VIN WITH 1 # WRONG AND THAT IT HAD BEEN CORRECTED. THIS IS MY LAST REQUEST. I GIVE UP. I AM NOT WILLING TO RETURN TO THE DEALER AGAIN. PLEASE SEE THAT THIS IS RESOLVED.

NHTSA ID

11306454

Incident

Oct 10, 1997

TL* THE CONTACT OWNS A 1998 CHEVROLET MALIBU. WHILE DRIVING 70 MPH, THE ANTI-THEFT SYSTEM ENGAGED AND THE ENGINE SEIZED. THE CONTACT WAS NOT ABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TOWED TO HIS HOME. THE MANUFACTURER WAS NOTIFIED, BUT WAS UNABLE TO ASSIST. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 130,000. THE VIN WAS UNKNOWN.

NHTSA ID

11171731

Incident

Jan 18, 2019

Mileage

130,000 mi

TAKATA RECALL HAVE A CHEVROLET MALIBU 1998 THAT I JUST BOUGHT AND FOUND OUT IT HAD A RECALL THAT WAS NOT TAKEN CARE OF AND HOW WOULD I GO TO GET IT DONE

NHTSA ID

10950178

Incident

Feb 1, 2017

IGNITION SWITCH NOT SHUTTING OFF AND AT TIMES NOT TURNING TO START CAR. SHIFT LEVER HAS TO BE WIGGLED TO ALLOW KEY TO TURN TO OFF POSITION. KEY CYLINDER SHUTTING OFF IN START POSITION.

NHTSA ID

10945175

Incident

Aug 2, 2016

Mileage

170,000 mi

TAKATA RECALL - WHILE DRIVING HOME FROM WORK AT NIGHT MY DAUGHTER (SOLE OCCUPANT) HEARD A LOUD EXPLOSION AND WINDSHIELD SHATTERED. SHE LOOKED TO RIGHT AND SAW THAT THE PASSENGER AIRBAG HAD DEPLOYED. SHE HAD NOT HIT ANYTHING INCLUDING BUMPS OR POT-HOLE. NOT SURE IF IT'S A TAKATA BUT DEPLOYMENT COULD OF COST HER LIFE. *TR

NHTSA ID

10944959

Incident

Jan 12, 2017

Mileage

313,000 mi

TL* THE CONTACT OWNS A 1998 CHEVROLET MALIBU. THE CONTACT STATED THAT AFTER THE IGNITION KEY WAS INSERTED INTO THE VEHICLE, THE VEHICLE FAILED TO START AS THE ANTI THEFT WARNING LIGHT ILLUMINATED. THE CONTACT STATED THAT VEHICLE WAS ABLE TO START AFTER TEN MINUTES. THE CONTACT ALSO MENTIONED THAT THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 150,000.

NHTSA ID

10822938

Incident

Jan 28, 2016

Mileage

150,000 mi

WHILE BACKING OUT OF MY DRIVE WAY TO THE RIGHT I HEARD LOUD CLUNKING AND THEN FINALLY A POP AS I TURNED THE STEERING TO THE LEFT. IMMEDIATELY FOLLOWING, WHILE DRIVING IN RESIDENTIAL AREA LEFT TURNS BECAME EXTREMELY DIFFICULT TO MAKE, AND I NOTICED THE STEERING WHEEL SEEMED TO BE OFF CENTER. I DECIDED TO MAKE A 3-POINT TURN TO RETURN HOME, AND WHILE BACKING TO THE LEFT THERE SEEMED TO BE LITTLE ACTUAL MOVEMENT BEFORE I FELT AS IF THE FRONT END OF THE CAR RAISED A BIT FOLLOWED BY ANOTHER LOUT POP. RETURNING THE WHEELS RIGHT SAW LITTLE MOVEMENT AT FIRST BEFORE TURNING AS NORMAL. LEFT TURNS THE REST OF THE WAY HOME DIFFICULT, WHILE RIGHT TURNS ARE MADE WITH EASE. UPON INSPECTION WHEN GETTING TO MY GARAGE RACK AND PINION MOUNT ON PASSENGER SIDE THAT APPEARS TO BE WELDED HAD BROKEN. PERHAPS RUSTED? I LIVE IN CA, SO I DIDN'T EXPECT RUSTED PARTS TO BE AN ISSUE.I HAVE RESEARCHED OTHER MALIBUS THAT HAVE EXPERIENCED INCREDIBLY SIMILAR BEHAVIOR, AND THERE IS EVEN A RECALL REGARDING THE RACK AND PINION IN MY MY MALIBU, HOWEVER MINE IS NOT INCLUDED DUE TO VIN. I FIND THIS TO BE ABSOLUTELY APPALLING THAT GM CAN RECEIVE SO MANY COMPLAINTS FOR THIS ISSUE, AND REQUEST FOR A FIX, AND SO BOLDLY TELL THESE CUSTOMERS THAT THEY WILL NOT SERVICE THEIR VEHICLES WHEN THIS IS CLEARLY A MANUFACTURER DEFECT.

NHTSA ID

10818472

Incident

Jan 4, 2016

Mileage

200,116 mi

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.  The PI update to version D is to advise the unlock procedure is temporarily unavailable.  E version update is to add administrative details.

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.  The PI update to version D is to advise the unlock procedure is temporarily unavailable.