Owner-reported complaints naming the electrical system, filed with NHTSA
Data refreshed
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories. Every record below is an owner-reported complaint about the 1997 Chevrolet Malibu submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 86 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
The 25 most recent of 86, in the owner's own words
Theft light. Car won’t start it’s happened 20 times in the last 6 months. I was driving and theft light caused everything to shut down. This is a dangerous thing that needs to be fixed
MY THIEF LIGHT STARTS BLINKING AND MY CAR WILL NOT START. THIS HAS HAPPENED 3 TIMES THIS PAST MONTH. I WAS TOLD IT WAS THE PASSLOCK TO TURN CAR IN ON POSITION FOR 10 MINUTES OR UNTIL LIGHT STOPS BLINKING THEN IT WOULD START. THIS IS A SAFETY ISSUES THAT NEEDS TO BE FIXED BEFORE IT HAPPENS WHILE DRIVING
WAS DRIVING ON INTERSTATE WHEN CAR COMPLETELY SHUT OFF, LOST ALL POWER , NO POWER STEERING OR POWER BRAKES. SECOND TIME, CAME TO A STOP ON CITY STREET AND CAR SHUT OFF AGAIN , NO POWER , NO POWER STEERING OR POWER BRAKES AGAIN. CAR HAD TO BE TOWED. THIS HAPPENED AFTER I PAID MODERN CHEVROLET TO FIX THE ISSUE WHICH IGNITION SWITCH WAS FOUND TO BE AT FAULT. (NHTSA REFERENCE NUMBER-14V400000) AFFECTED NUMBER- 5,877,718
MY IGNITION SWITCH AND CYLINDER KEPT TURNING MY CAR OFF WHEN I STARTED IT. ALSO WHILE I WAS DRIVING THE CAR WOULD JUST CUT OFF..NOW IT GOT TO THE POINT WHERE I HAVE TO REPLACE THE PIECE. *TR
I HAVE HAD TO CHANGE THE PASSENGER CALIPER AND ROTORS TWICE BECAUSE THE BOLTS FOR THE CALIPER KEEPS POPPING OUT AND THE BOLTS FOR THE BRACKET KEEPS POPPING OUT.. MY WINDSHIELD WIPER ON THE PASSENGER SIDE WENT OUT LAST MONTH..LAST NIGHT THE CAR WOULDN'T START UP ANYMORE WHEN I DO TURN THE KEY THE LIGHTS COME ON BUT WHEN I TRY TO START THE CAR UP I GET A CLICKING NOISE, THE RADIO KEPT GOING IN AND OUT ALSO. NOW MY O2 SENSORS AND TRIPPING. I'VE HAD TO CHANGE THE EGR VALVE BECAUSE IT KEPT GETTING STUCK IN OPEN POSITION AND I ALSO CHANGED THE BELT
TL* THE CONTACT OWNS A 1997 CHEVROLET MALIBU. THE CONTACT HAD TROUBLE STARTING THE VEHICLE AND THE ANTI-THEFT SYSTEM WARNING INDICATOR ILLUMINATED. AFTER TEN MINUTES, THE VEHICLE WAS OPERABLE. THE CONTACT STATED THAT THE FAILURE OCCURRED TWICE A MONTH. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 80,000. *LN CONSUMER STATED HAD TO KEEP KEY IN IGNITION FOR 10 MINUTES IN A POSITION NOT GOOD NOT SAFE, CHANCE OF BATTERY DYING. I'M ALSO AFRAID THEFT SYSTEM LIGHT WILL COME ON AND LOCK CAR UP WHILE DRIVING. UPDATED 7/25/18*JB
TL* THE CONTACT OWNS A 1997 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 15 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO A DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 88,000.
TL* THE CONTACT OWNS A 1997 CHEVROLET MALIBU. THE CONTACT STATED THAT THE AUTO THEFT SYSTEM INDEPENDENTLY FUNCTIONED AND CAUSED THE VEHICLE TO STALL WITHOUT WARNING. AFTER 10 TO 15 MINUTES, THE VEHICLE WAS OPERABLE AGAIN. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE VEHICLE PASSKEY SENSOR AND IGNITION SWITCH WERE DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 92,000.
TL* THE CONTACT OWNS A 1997 CHEVROLET MALIBU. THE CONTACT STATED THAT THE ANTI-THEFT SYSTEM ENGAGED WITHOUT WARNING AND CAUSED THE VEHICLE TO STALL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 130,000.
1997 CHEVROLET MALIBU. CONSUMER WRITES IN REGARDS TO IGNITION CYLINDER LOCK AND SWITCH RECALL REPAIRS AND SEEKS REIMBURSEMENT. *SMD UPDATED 11/24/15*JB
1997 CHEVROLET MALIBU. THE CONSUMER STATES THAT THE AUTO WOULD NOT START OR WOULD CONTINUE TO RUN AFTER THE KEY WAS REMOVED FROM THE IGNITION. *TA THE CONSUMER STATED THE VEHICLE LEFT HER STRANDED DURING THE MONTHS OF MAY, JUNE, AND JULY. THE IGNITION LOCK CYLINDER WAS FINALLY REPLACED. *JB
1997 CHEVROLET MALIBU. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH CUT OFF ISSUES. *TGW THE IGNITION SWITCH WAS REPLACED AT A COST OF $400.00 AND IS SEEKING REIMBURSEMENT. ALSO, THE OUTER AND INNER TIE RODS WERE REPLACED. *JB
TL* THE CONTACT OWNS A 1997 CHEVROLET MALIBU. THE CONTACT STATED THAT IT TOOK NUMEROUS ATTEMPTS TO START THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE IGNITION SWITCH AND SENSOR WERE BOTH REPLACED. IN ADDITION, THE ENGINE PISTON SLAP MADE A LOUD KNOCKING NOISE WHENEVER THE VEHICLE WAS IN OPERATION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 68,000.
I ONCE OWNED THE CHEVY MALIBU. INCIDENTS HAPPENED IN THE PAST. THREE TIMES WHEN I HIT A BUMP MY CAR SHUT DOWN. I BROUGHT IT TO DAVIDSON CHEVROLET IN MALDEN MASS. THEY COULD NOT FIND THE CAUSE OF THE PROBLEM. SOMEONE DID SUGGEST THAT I REMOVE EXTRA STUFF OFF MY KEYRING. I NOLONGER OWN THIS CAR. I AM WRITING TO YOU BECAUSE IT SOUNDS SIMILAR TO WHAT IS HAPPENING WITH THE CHEVY COBALT IGNITIONS. FROM MY EXPERIENCE, I FEEL THAT YOUR CURRENT RECALL MAY NOT BE REACHING AS FAR AS IT SHOULD. *JS
CAR GOES INTO LOCKDOWN FREQUENTLY BECAUSE OF THE THEFT ALERT SYSTEM AND YOU HAVE TO WAIT 10 MINUTES BEFORE THE CAR WILL START. I BELIEVE THIS IS A SAFETY CONCERN AND POTENTIAL HAZARD TO ANYONE IS OPERATING THIS VEHICLE. I CALLED DEALERSHIP TO DISCUSS THIS PROBLEM AND THERE REPLY IS "WELL THE CAR IS OLD AND YOU NEED TO SEE ABOUT PURCHASING ANOTHER ONE". I GOT THIS REPLY IN 2007. I HAVE ALSO RESEARCHED IT ON THE INTERNET AND FOUND THAT THIS IS A COMMON PROBLEM IN CHEVY MALIBU'S, WHICH TO ME CONSTITUTES A MANUFACTURING DEFECT AS WELL AS A SAFETY CONCERN. *TR
TL* THE CONTACT OWNS A 1997 CHEVROLET MALIBU. THE CONTACT WAS HAVING THE VEHICLE SERVICED AND WHEN THE BATTERY WAS DISCONNECTED, THE FUEL GAUGE NEEDLE BECAME STUCK. THE FAILURE OCCURRED TWICE. A PRIVATE MECHANIC WAS ABLE TO REPAIR THE VEHICLE AFTER THE FIRST FAILURE. THE DEALER WAS CONTACTED ABOUT THE FAILURE AND ADVISED THE CONTACT THAT THE FAILURE COULD HAVE HAPPENED DUE TO A SPIKE IN VOLTAGE WHEN THE BATTERY WAS RECONNECTED WITH THE KEY LEFT IN THE RUN POSITION. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 126,930.
ANTI THEFT SYSTEM ARMS AND DISARMS RANDOMLY, CAUSING THE CAR TO NOT START OR STALL OUT. *TR
TL*THE CONTACT OWNS A 1997 CHEVROLET MALIBU. THE CONTACT WAS DRIVING APPROXIMATELY BETWEEN 5 TO 10 MPH AND ENCOUNTERED SEVERAL SPEED BUMPS IN THE ROADWAY. IMMEDIATELY AFTER DRIVING OVER THE SPEED BUMPS THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WOULD NOT RESTART AND WAS TOWED TO HIS RESIDENCE. THE CONTACT STATED THAT THE FAILURE WAS CONTRIBUTED TO THE ANTI-THEFT PATH LOCK. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED WHEN THE COMPLAINT WAS FILED. THE FAILURE MILEAGE WAS 150,000.
I HAVE A 1997 CHEVY MALIBU. RECENTLY, THE ANTI-THEFT LIGHT HAS BEEN COMING ON AND DISABLING THE ENGINE. THERE IS NO FIX FOR THIS PROBLEM PER THE DEALERSHIP AND THE ONLY OPTION I HAVE IS TO DISCONNECT THE BATTERY AND RECONNECT IT. THIS ISN'T EVER CONVENIENT AND IS A MAJOR SAFETY ISSUE. *TR
THEFT SYSTEM CONTINUES TO COME ON INTERMITTENTLY AFTER MULTIPLE REPAIRS. I OWN A 1997 CHEVROLET MALIBU 3.1L. *TR
TL*THE CONTACT OWNS A 1997 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 45 MPH, THE ENGINE WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE LIGHT REMAINED ILLUMINATED UNTIL THE ENGINE WAS TURNED OFF. THE VEHICLE HAS NOT YET BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 100,000.
THE CAR HAS A THEFT SYSTEM IN IT WHICH ON NUMEROUS OCCASIONS DOESN'T LET ME START THE CAR . IT IS A 1997 CHEVY MALIBU. *TR
I WOULD LIKE TO GET A REPLACEMENT,DISCOUNT OR FREE SERVICE ON MY 1997 MALIBU. I'VE HAD MY CAR SINCE 2004 AND HAD TO GET ANOTHER MOTOR IN 2005 WHICH IS NEEDED NOW .THIS CAR HAS PUT ME DOWN A LOT NOT ONLY PROBLEMS WITH THE MOTOR BUT THE IGNITION LOCKED UP AND I HAD TO REPLACE THAT AS WELL AS THE BRAKES AND ROTORS THAT LAST ABOUT 2 OR 3 MONTHS. I ALSO HAVE A PROBLEM WITH THE LIGHTS NOT WORKING PROPERLY THEY ONLY WORK ON HIGH BEAM. I CAN'T FIND A MORE REASONABLE MECHANIC THAT'S WILLING TO REPAIR THE MOTOR THAT I CURRENTLY HAVE DUE TO THE TYPE WHICH IS A 2.4 AND A USED MOTOR COST ABOUT HALF THE PRICE OF A NEW ONE. PLEASE HELP! *TR
I WAS DRIVING MY CAR ON THE BYWAY AND TOOK THE INTERSTATE MERGE LANE WHILE INCREASING MY SPEED TO MERGE INTO TRAFFIC I FELT A SNAP IN MY STEERING WHEEL AND GAS PEDAL, I THEN LOST THE DASH AND THE CAR IMMEDIATELY OVERHEATED, I HAD NO REAL POWER TO TURN THE WHEEL AND THE GAS PEDAL WAS A LOOSE PUSH. BEING THAT I HAD MERGED ONTO THE INTERSTATE WHEN THIS OCCURRED I HAD TO DRIVE AN ADDITIONAL 5 MILES TO THE NEXT EXIT. NOT EVERYONE HAS A CELL PHONE. WHEN I GOT TO THE NEXT EXIT I WAS ALMOST UNABLE TO TURN THE WHEEL ENOUGH TO GET IT INTO THE NEAREST PARKING LOT, IT WAS HARDER TO TURN THAN MY FIRST TRUCK A 1959 FORD TWIN I BEAM PICKUP. I FORTUNATELY DIDN'T HIT ANY ONE OR ANYTHING. UPON RAISING MY HOOD AFTER PARKING THE CAR I AM APPALLED TO SEE THAT THE TENSIONER PULLEY AND ONE OF THE IDLER PULLEYS ARE GONE AND MY SERPENTINE BELT IS SHREDDED. I HAVE REPLACED THE PARTS BUT SINCE THEN I ALSO FOUND THAT WITHIN 5 MILES THE "DREADED" GASKETS THAT SO MANY PEOPLE HAVE COMPLAINED ABOUT, AND MINE WE ALREADY EATING FLUIDS IN SIPPS BEFORE THIS, WERE GONE. I HAVE REPLACED THE BROKEN PULLEYS SERPENTINE BELT ALTERNATOR WATERPUMP AND GASKETS NOT A MONTH LATER THE OTHER IDLER PULLEY THAT WAS UNAFFECTED IN THE FIRST INCIDENT WENT. WHEN THE FIRST TWO WERE REPLACED THAT DREADED SQUEAKING STOPPED FOR ABOUT 3 DAYS AND STARTED BACK UP AGAIN. SOMETHING MUST NOT BE STRAIGHT FOR ME TO HAVE TO KEEP REPLACING THE MOVING PARTS THAT RUN ON THE SERPENTINE BELT AND EVERYTIME ONE OF THEM GOES YOU LOOSE YOUR POWER STEERING AND THE CAR IS HARD TO TURN. NOT ONLY THAT BUT THE TAIL LIGHTS WOULD BE A BETTER PLACE FOR A GOLD FISH THAN A LIGHT BULB. EVERYTIME IT RAINS, OR SNOWS I HAVE TO REPLACE TAIL LIGHTS. THIS CAR IS THE BANE OF MY EXISTENCE. I HAVE THE FIRST IDLER PULLEY PART STILL THE REST OF THEM WERE LOST TO THE HIGHWAY THE THING IS MELTED. *TR
MY FIANCE AND I HAVE HAD A 1997 CHEVY MALIBU FOR A YEAR AND A HALF. ABOUT A MONTH AFTER PURCHASING IT, THE VEHICLE STARTED HAVING PROBLEMS WITH THE PASSLOCK THEFT SYSTEM THAT WOULD LEAVE US STRANDED FOR 10 MINUTES BECAUSE THE CAR WOULDN'T CRANK. GRADUALLY IT STARTED DOING IT MORE AND MORE. WE'VE HAD INCIDENTS WHERE THE THEFT SYSTEM LIGHT WOULD GO OFF AFTER 10 MINUTES BUT WHEN TRYING TO START IT AGAIN; IT WOULD DO THE SAME THING. I'VE ACTUALLY HAD TIMES OF BEING STRANDED FOR 2 HOURS BECAUSE IT WOULD KEEP DOING IT! RIGHT NOW OUR CAR IS AT MY FIANCE'S WORK BECAUSE IT WON'T CRANK AND WE GOT TIRED OF TRYING AFTER 3 HOURS. THIS IS SO ANNOYING! CHEVROLET SHOULD BE ASHAMED OF THEMSELVES! I KNOW A LOT OF PEOPLE THAT HAVE HAD THIS SAME PROBLEM(NOT COUNTING ALL THE OTHER PROBLEMS LIKE THE BRAKES AND WINDSHIELD WIPERS). WITH SO MANY PEOPLE HAVING THE SAME PROBLEM..THAT MEANS THEY SHOULD RECALL IT AND FIX IT. WE DON'T HAVE MONEY LIKE THEY DO AND CAN'T AFFORD TO KEEP PUTTING IT IN THE SHOP TO BE WORKED ON. I'M CURRENTLY A COLLEGE PELL GRANT RECIPIENT THAT IS GOING TO LOSE MY GRANTS BECAUSE OF THIS LEMON CAR! I WAS ADOPTED BY MY GRANDPARENTS THAT ARE ON SSI AND DISABILITY AND THEY CAN'T AFFORD TO SEND ME TO SCHOOL. I HOPE THE PEOPLE AT CHEVROLET ARE HAPPY WITH RUINING MY FUTURE! PLEASE HELP ME!!!I NEED MY CAR FIXED BEFORE IT'S TOO LATE!*JB
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .