2005 Chevrolet Venture Owner Complaints

The contact owns a 2005 Chevrolet Venture. The contact stated that while his father was driving at an undisclosed speed on the highway, the vehicle suddenly lost automotive power. No warning lights illuminated. In addition, the contact stated that his father managed to pull over to the shoulder of the road, and upon further inspection, white/blue smoke was seen coming from under the vehicle, and the vehicle later caught on fire from the fuel pump/tank. The fire had leaked onto the floor; however, it had extinguished on its own. A police report was not filed; however, Law Enforcement arrived on scene to direct traffic. The local fire department did not arrive on scene. No injuries were sustained, nor medical attention was sought. The vehicle failed to restart. The vehicle was towed to a local tow yard, where it was deemed a total loss by the insurance provider. The local dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 116,000.

NHTSA ID

11722553

Incident

Dec 15, 2025

Mileage

116,000 mi

The contact owns a 2005 Chevrolet Venture. The contact stated that while driving at various speeds, the vehicle was making a rattling sound coming from the front passenger’s side of the vehicle. There were no warning lights illuminated. The contact took the vehicle to a certified mechanic who replaced the wheel bearing hub assembly, brakes, rotors, struts, and tires. The failure persisted. The contact took the vehicle to another certified mechanic who performed a front-end alignment however, the failure persisted. The vehicle was taken to a third mechanic who identified that the noise seemed to be coming from the steering wheel; however, the mechanic could not verify the cause of the failure. The vehicle had not been repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 236,000.

NHTSA ID

11490992

Incident

Oct 26, 2021

Mileage

236,000 mi

TL* THE CONTACT OWNED A 2005 CHEVROLET VENTURE. WHILE DRIVING APPROXIMATELY 35 MPH IN THE RAIN, THE VEHICLE HYDROPLANED TO THE LEFT AND THEN BACK TO ITS LANE. THE REAR TIRES ROLLED OFF THE ROAD AND CAUSED THE VEHICLE TO CRASH INTO A DITCH. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED INJURIES THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS TOWED TO A BODY SHOP AND DEEMED DESTROYED BY THE INSURANCE COMPANY. THE FAILURE MILEAGE WAS 130,000.

NHTSA ID

10991158

Incident

May 10, 2017

Mileage

130,000 mi

MY WIFE HIT A OLD STYLE VAN THAT HAD STOPPED FOR A DOG CROSSING A THE ROAD. THE WHOLE FRONT END HAD TO BE REPLACED. HOOD, GRILL, LIGHTS, BOTH FENDER HAD TO BE REPAIRED, ALSO THE STEAL TUBE UNDER THE RADIATOR FRAME HAD TO BE CUT OUT AND REPLACED. ON 11/5/2010 I HIT A DEER GOING 30 MPH, AGAIN FRONT END DAMAGE. BOTH TIMES THE AIR BAGS DIDN'T DEPLOY, AND ON STAR DIDN'T RESPOND. I ASKED TWO DIFFERENT CHEVROLET DEALERS IF THE AIR BAG SENSOR COULD BE TESTED, ANSWER WAS NO.

NHTSA ID

10747955

Incident

Jan 25, 2010

Mileage

49,357 mi

WE HAVE BEEN SMELLING GASOLINE FUMES IN AND OUTSIDE OUR VAN. SOMETIMES IT IS VERY POTENT AND OTHER TIMES FAINT. WHEN WE WALK INTO OUR GARAGE, WE CAN SMELL IT ALSO. IT OCCURS OFTEN WHEN MAKING A LEFT-HAND TURN. WHEN WE INSPECT IT, WE CAN'T FIND ANY LEAK. WE SMELL THIS FROM A HALF TANK TO EMPTY. *TR

NHTSA ID

10683516

Incident

Jan 1, 2015

Mileage

225,000 mi

2005 CHEVROLET VENTURA. CONSUMER WRITES IN REGARDS TO NON-DEPLOYMENT OF AIR BAGS. *SMD THE CONSUMER STATED HIS FATHER AND STEP-MOTHER WERE INVOLVED IN AN ACCIDENT. HIS FATHER DIED FROM HIS INJURIES AND HIS STEP-MOTHER WAS INJURED. THE CONSUMER STATED HIS FATHER HIT A DIRT BANK HEAD-ON AND THE AIR BAGS FAILED TO DEPLOY. AS A RESULT, HIS FATHER HIT THE STEERING WHEEL WITH HIS CHEST CAUSING DAMAGE TO HIS LUNGS, SPLEEN, KIDNEYS AND RIBS. HIS STEP-MOTHER HIT THE DASH AND CENTER CONSOLE WITH HER HEAD, CUTTING HER ACROSS THE FOREHEAD. *JB

NHTSA ID

10651206

Incident

Oct 15, 2012

TL * THE CONTACT OWNS A 2005 CHEVROLET VENTURE. THE CONTACT STATED THAT THE FRONT PASSENGER SIDE SEAT BELT BUCKLE RELEASE MECHANISM FRACTURED. THE DEALER ORDERED A SEAT BELT MOUNTING KIT TO PERFORM THE REPAIR. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 90,000. UPDATED 10/24/2014*LJ UPDATED 7/14/2015*JS

NHTSA ID

10619552

Incident

Jul 9, 2014

Mileage

90,000 mi

TL* THE CONTACT OWNS A 2005 CHEVROLET VENTURE. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT SMELLED FUEL WITHIN THE CABIN OF THE VEHICLE. THE DEALER WAS UNABLE TO DIAGNOSE THE CAUSE OF THE FUEL ODOR. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 85,000.

NHTSA ID

10608071

Incident

Dec 16, 2013

Mileage

85,000 mi

THE VAN FILLS WITH FUEL FUMES. THE FUMES CAN BE SMELLED INSIDE AND OUTSIDE THE VEHICLE. GM HAS RECALLED CHEVY VENTURE 2001-2004 FOR SPECIFIC VIN#'S BUT NO 2005'S AND MY SPECIFIC VIN# IS NOT INCLUDED. I HAVE TALKED WITH GM BUT THEIR RESPONSE IS JUST YOUR VIN# IS NOT INCLUDED. YOU CAN GO TO THE DEALERSHIP AND PAY FOR IT TO GET FIXED. THIS IS A SPECIFIC FIRE HAZARD ACCORDING TO THEIR REPORTS. I HAVE HAD TO PARK MY VEHICLE FOR SAFETY REASONS. I CAN NOT ALLOW MY CHILDREN TO BE SUBJECTED TO THE FUEL FUMES OR THE POTENTIAL OF A FIRE. I AM NOT IN A POSITION AT THIS TIME TO PAY FOR THE WORK OR TRADE DUE TO THE ECONOMY. IF GM KNOWS THAT HAVE THIS PROBLEM THEN WHY WOULD THEY LET A POTENTIAL HAZARD TO LOYAL CUSTOMERS CONTINUE. REGARDLESS OF THE VIN# IF THE PROBLEM IS PRESENT THEN GM SHOULD BE RESPONSIBLE. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID

10607740

Incident

Oct 25, 2013

Mileage

85,000 mi

THE DRIVER WAS SLOWING OR STOPPED WHEN SHE WAS REAR ENDED. THE FRONT DRIVER SEAT AIRBAG DEPLOYED. IT IS UNCLEAR WHETHER THE AIRBAG DEPLOYED PREMATURELY OR WHETHER IT DEPLOYED AFTER THE VEHICLE WAS REAR ENDED. *TR

NHTSA ID

10596950

Incident

Feb 21, 2012

ROUGH SHIFTING FROM BEGINNING NOW 2ND GEAR OUT AFTER LIGHTS WERE LEFT ON BY ACCIDENT AND DRAINED BATTERY. *TR

NHTSA ID

10577545

Incident

Feb 3, 2014

TL* THE CONTACT OWNS A 2005 CHEVROLET VENTURE. THE CONTACT STATED THAT WHILE REFUELING, FUEL SPRAYED FROM THE FILLER NECK VALVE. THE VEHICLE WAS TOWED TO A PRIVATE MECHANIC, WHO STATED THAT THE FUEL TANK HAD FAILED. THE CONTACT WAS ALSO INFORMED BY THE DEALER THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 07E021000 (FUEL SYSTEM, OTHER). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 70,000. UPDATED 10/17/13*CN

NHTSA ID

10543866

Incident

Sep 11, 2013

Mileage

70,000 mi

THE ABS LIGHT CAME ON AS WE WERE BRAKING. THE BRAKES THEN STARTED FEELING LIKE THEY WERE WORKING INTERMITTENTLY. THIS CAUSED THE CAR TO FEEL LIKE IT WAS NOT GOING TO STOP. WE WERE NOT EVEN GOING THAT FAST. WE OWNED A PREVIOUS 2005 CHEVROLET VENTURE AND IT HAD THE SAME PROBLEM. *TR

NHTSA ID

10513507

Incident

May 15, 2013

Mileage

130,000 mi

TL* THE CONTACT OWNS A 2005 CHEVROLET VENTURE. THE CONTACT STATED THAT THE PASSENGER SIDE POWER DOOR WOULD NOT LOCK. THE VEHICLE WAS TAKEN TO THE DEALER, WHO STATED THAT THE SLIDING DOOR LOCK NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 145,000.

NHTSA ID

10504451

Incident

Feb 25, 2013

Mileage

145,000 mi

TL* THE CONTACT OWNS A 2005 CHEVROLET VENTURE. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, HE ATTEMPTED TO SLOW DOWN AND THE VEHICLE BEGAN TO PULL TOWARD THE RIGHT. THE BEARING ON THE BRAKING SYSTEM ALSO BEGAN TO GRIND. THE CONTACT STATED THAT THE BEARINGS NEEDED TO BE REPLACED AND HE REPAIRED THE VEHICLE HIMSELF. THE FAILURE RECURRED ONCE MORE AND THE CONTACT TOOK THE VEHICLE TO A REPAIR SHOP FOR REPAIR. THE FAILURE CONTINUED TO RECUR. THE CONTACT HAD NOT NOTIFIED THE MANUFACTURER. THE FAILURE MILEAGE WAS 50,000.

NHTSA ID

10462953

Incident

Jun 25, 2009

Mileage

50,000 mi

I HAVE A 2005 CHEVROLET VENTURE MINI VAN THAT HAS DEVELOPED A FUEL LEAK AROUND THE AREA WHERE THE FILLER TUBE CONNECTS TO THE FUEL TANK. HAVING RESEARCHED THIS, IT IS APPARENT THAT THIS HAS BEEN A PROBLEM FOR THESE VEHICLES AS EARLY AS 2003. THIS THE THIRD TIME THIS HAS HAPPENED ON MY VAN. I HAVE ATTEMPTED TO REPAIR IT TWICE, USING AN EPOXY SEALER,BUT THE LEAK REDEVELOPS AFTER A FEW DAYS. I MIGHT HAVE TO REPLACE THE FUEL TANK AND FILLER TUBE, IF I CAN FIND ONE THAT I CAN AFFORD. GM SAYS THAT THIS IS NOT DEFECT AND WILL NOT ISSUE A RECALL, BUT IT SEEMS THAT JUST THE IDEA OF FIRE HAZARD WOULD BE ENOUGH REASON FOR GM TO FIX THE PROBLEM. I DO NOT SEE HOW GM CAN NOT SAY THAT THIS IS NOT A DEFECT IN THE DESIGN, SINCE THIS HAS OCCURRED A NUMBER OF TIME. IT'S A PLASTIC SIDE MOUNTED TANK WITH NO PROTECTION SURROUNDING IT AND A FILLER TUBE THAT JOINS IT IN A VERY VULNERABLE AREA. *TR

NHTSA ID

10372038

Incident

Oct 1, 2010

Mileage

145,000 mi

SPEEDOMETER NEVER DROPS BELOW 55 MPH WHEN VEHICLE IS STANDING STILL AND HAS INCREASED TO 95 MPH AT TIMES. *TR

NHTSA ID

10308407

Incident

Feb 9, 2010

Mileage

98,600 mi

TEMP GAUGE READING HOT, DECIDED 95 S IN NEW YORK CITY WASN'T AN IDEAL PLACE TO STOP AND TRAFFIC WAS VERY BAD HAD TO DRIVE IN BREAKDOWN LANE TO GET TO NEAREST EXIT (APPROX 1.5 MILES) PULLED OVER IN A WATER WORKS LOT WITH MY 4 YR OLDS AND WIFE AT 11:30 PM, ON WAY TO OHIO FROM RHODE ISLAND. CALLED AAA TOOK TO GARAGE, SEVERAL HOURS LATER, US TO A HOTEL THAT WASN'T BOOKED. NEXT GARAGE REPLACED THE TEMP SWITCH AND THERMOSTAT. SEEMED OK. CONTINUED TO OHIO. WHILE IN OHIO TEMP GAUGE WAS READING HOT AGAIN. TOOK TO DEALER AND SAID THAT THE GAUGE CLUSTER WAS FAULTY BUT DID NOT HAVE THE PART TO REPLACE. CAME HOME , TEMP GAUGE HAS BEEN READING FINE IF I TURN THE KEY ON AND OFF TO "RESET" THE GAUGE BACK TO "ZERO" STILL NOT SURE THAT IT IS READING CORRECTLY AT THAT POINT. $500.00 TO HAVE REPLACED. MOST CAR FORUMS PEOPLE HAVE BEEN COMPLAINING OF THIS ISSUE AND SOME OTHER COOLING ISSUES THAT VERY WELL MAY BE RELATED TO THIS PROBLEM. SAFETY OF MY FAMILY IS VERY IMPORTANT AND HAVING A VAN THAT "OVERHEATS"IS A PROBLEM DUE THE FACT THAT IF WE IGNORE THE GAUGE IT VERY WELL MAY OVERHEAT AND MY FAMILY MAY BE ON THE SIDE OF THE ROAD NOT BEING ABLE TO GET TO A SAFE PLACE. WE WERE FORTUNATE THAT AAA WAS ABLE TO HELP US ALOT AND THAT I WAS ABLE TO GET TO A SAFE PLACE THAT WASN'T THE BRONX (WHICH WAS THE NEXT EXIT) OR WORSE. THIS PROBLEM INCLUDING THE STAY WAS $1300.00 AND NOT TO MENTION BEING IN A STRANGE DARK PLACE FOR NEARLY 3 HRS. I STILL HAVE NO CONFIDENCE THE NEW CLUSTER IS WORKING THE WAY IT IS SUPPOSED TO. *TR

NHTSA ID

10293751

Incident

Aug 1, 2009

Mileage

34,000 mi

TEMP GAUGE READING HOT, DECIDED 95 S IN NEW YORK CITY WASN'T AN IDEAL PLACE TO STOP AND TRAFFIC WAS VERY BAD HAD TO DRIVE IN BREAKDOWN LANE TO GET TO NEAREST EXIT (APPROX 1.5 MILES) PULLED OVER IN A WATER WORKS LOT WITH MY 4 YR OLDS AND WIFE AT 11:30 PM, ON WAY TO OHIO FROM RHODE ISLAND. CALLED AAA TOOK TO GARAGE, SEVERAL HOURS LATER, US TO A HOTEL THAT WASN'T BOOKED. NEXT GARAGE REPLACED THE TEMP SWITCH AND THERMOSTAT. SEEMED OK. CONTINUED TO OHIO. WHILE IN OHIO TEMP GAUGE WAS READING HOT AGAIN. TOOK TO DEALER AND SAID THAT THE GAUGE CLUSTER WAS FAULTY BUT DID NOT HAVE THE PART TO REPLACE. CAME HOME , TEMP GAUGE HAS BEEN READING FINE IF I TURN THE KEY ON AND OFF TO "RESET" THE GAUGE BACK TO "ZERO" STILL NOT SURE THAT IT IS READING CORRECTLY AT THAT POINT. $500.00 TO HAVE REPLACED. MOST CAR FORUMS PEOPLE HAVE BEEN COMPLAINING OF THIS ISSUE AND SOME OTHER COOLING ISSUES THAT VERY WELL MAY BE RELATED TO THIS PROBLEM. SAFETY OF MY FAMILY IS VERY IMPORTANT AND HAVING A VAN THAT "OVERHEATS"IS A PROBLEM DUE THE FACT THAT IF WE IGNORE THE GAUGE IT VERY WELL MAY OVERHEAT AND MY FAMILY MAY BE ON THE SIDE OF THE ROAD NOT BEING ABLE TO GET TO A SAFE PLACE. WE WERE FORTUNATE THAT AAA WAS ABLE TO HELP US ALOT AND THAT I WAS ABLE TO GET TO A SAFE PLACE THAT WASN'T THE BRONX (WHICH WAS THE NEXT EXIT) OR WORSE. THIS PROBLEM INCLUDING THE STAY WAS $1300.00 AND NOT TO MENTION BEING IN A STRANGE DARK PLACE FOR NEARLY 3 HRS. I STILL HAVE NO CONFIDENCE THE NEW CLUSTER IS WORKING THE WAY IT IS SUPPOSED TO. *TR

NHTSA ID

10293749

Incident

Aug 1, 2009

Mileage

34,000 mi

WHILE THE CONTACT WAS DRIVING 30MPH THE DRIVER SIDE REAR DOOR HAD SUDDENLY SLID OPEN. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALERSHIP AND THE CONTACT NOTICED BEFOREHAND THAT THE DOOR WOULD NOT OPEN ELECTRONICALLY. THE CURRENT AND FAILURE MILEAGE IS 69250. BML

NHTSA ID

10280846

Incident

Jun 2, 2009

Mileage

69,250 mi

THE SLIDING DOORS WANT OPEN AND WHEN IT DOES, IT IS HARD TO CLOSE. THE LOCKS GET STUCK OFTEN ON BOTH DOORS; THE AUTOMATIC DOOR & WINDOW CONTROL DOES NOT WORK. THE OVER ALL QUALITY IS POOR. HAVE AIR POCKETS AND THE DRIVER SEAT IS BROKEN. *TR

NHTSA ID

10263646

Incident

Jan 1, 2009

Mileage

90,000 mi

JUST BOUGHT 2005 CHEVROLET VENTURE MINI VAN FROM DEALER WE HAVE VERY DIM HEAD LIGHTS, DANGEROUS AT NIGHT TO DRIVE!, NOTICE DEFECTIVE EXTERIOR LIGHTING: HEADLIGHTS DEFECT DESCRIPTION: EAGLE EYES IS RECALLING HEADLAMP ASSEMBLIES : FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108,LAMPS REFLECTIVE DEVICES. THESES HEAD LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS. I CONTACTED THEM ON 1-26-09 LEFT MESSAGE, HAVE NOT RECEIVED REPLY. ALSO CONTACTED DELPHI ABOUT THE FUEL PRESSURE REGULATOR THAT WERE PRODUCED WITH OUT AN O' RING AND RETAINER FOR THIS SAME YEAR CHEVY VENTURE. HAVEN'T RECEIVED ANY REPLY . *TR

NHTSA ID

10256971

Incident

Jan 14, 2009

Mileage

71,340 mi

TL*THE CONTACT WAS TRANSPORTING A 2005 CHEVROLET VENTURE TO A DEALER. WHILE DRIVING APPROXIMATELY 40 MPH, THE CONTACT FELT A GUST OF WIND AND THE HOOD DETACHED FROM THE VEHICLE AND SHATTERED THE WINDSHIELD AND THE GRILL. THE VEHICLE WAS TOWED BACK TO HIS ESTABLISHMENT. THE DRIVER WAS UNINJURED. THE DEALER AND THE MANUFACTURER HAVE NOT BEEN NOTIFIED. UPDATED 1/6/09 *CN UPDATED 01/14/09. *JB

NHTSA ID

10251934

Incident

Dec 15, 2008

TL*THE CONTACT OWNS A 2005 CHEVROLET VENTURE. THE VEHICLE DOES NOT STEER PROPERLY AND THE BRAKES FAIL IN COLD WEATHER. THE FAILURES CAUSED THE CONTACT TO CRASH INTO AN ELECTRICAL POST. THE POLICE ARRIVED AT THE SCENE AND FILED A REPORT. THE VEHICLE WAS DESTROYED. THE DEALER AND MANUFACTURER HAVE NOT YET BEEN NOTIFIED. THE SPEED WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 40,000.

NHTSA ID

10214036

Incident

Jan 6, 2008

Mileage

40,000 mi

CHEVY VENTURE: POWER SLIDING DOOR (DRIVER SIDE) DOES NOT CLOSE AND LATCH CORRECTLY. *TR

NHTSA ID

10205721

Incident

Oct 5, 2007