2000 Volvo V70

ON NOVEMBER 14, 2006 VOLVO SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING ETM FAILURES IN MODEL YEAR (MY) 1999 THROUGH 2001 VOLVO MODELS (NOT INCLUDING THE S40 AND V40), MY 2002 S60 AND V70 WITH NATURALLY ASPIRATED ENGINES AND MY 2002 V70S.ACCORDING TO VOLVO, ?A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.VOLVO FURTHER STATED THAT,THIS RESULTED IN A HIGH NUMBER OF THESE VEHICLES GOING INTO LIMP HOME MODE WITHOUT NEED.?VOLVO INDICATED THAT THIS WAS THE MOST SEVERE CONSEQUENCE OF AN ETM FAULT IN THE SUBJECT VEHICLES.THE RECALL REMEDY IS A SOFTWARE UPGRADE INTRODUCED BY VOLVO ON MARCH 16, 2006 IN A CUSTOMER SATISFACTION PROGRAM.AT THE TIME OF THE NOTIFICATION 161,202 VEHICLES OF THE POPULATION OF 331,301 HAD ALREADY HAD THE SOFTWARE UPLOADED AND WERE THEREFORE NOT INCLUDED IN THE POPULATION COUNT OF THE RECALL. ODI?S ANALYSIS OF COMPLAINTS TO ODI AND VOLVO, VOLVO FIELD REPORTS AND WARRANTY DATA FOUND THAT ETM FAILURE COULD RESULT IN (1) ENGINE STALL; (2) MECHANICAL LIMP MODE; (3) LUNGING FORWARD DURING LOW-SPEED DRIVING MANEUVERS; AND (4) FALTERING DURING HIGH SPEED MERGES OR WHEN CROSSING TRAFFIC.ODI IDENTIFIED 12 CRASHES RELATED TO ETM FAILURE, WITH 6 CAUSED BY LUNGING INCIDENTS, 3 CAUSED BY STALLING INCIDENTS, 2 CAUSED BY MECHANICAL LIMP MODE AND 1 FROM THE FALTERING CONDITION.ODI'S ANALYSIS OF COMPLAINT DATA AND INFORMATION OBTAINED FROM CONSUMER INTERVIEWS IDENTIFIED 1,289 INCIDENTS WITH SAFETY RELATED CONSEQUENCES (389.1 PER 100,000 VEHICLES), INCLUDING 479 INVOLVING ENGINE STALL (144.6 PER 100,000 VEHICLES) AND 729 INVOLVING MECHANICAL LIMP MODE (220.0 PER 100,000 VEHICLES).ODI'S ANALYSIS OF WARRANTY CLAIM NARRATIVE TEXT SHOWS AT LEAST 14,965 WARRANTY CLAIMS WITH CODES INDICATING AN ETM FAULT RESULTING IN VEHICLE OPERATION IN MECHANICAL LIMP MODE (4.5% OF THE SUBJECT VEHICLES). VOLVO?S RECALL ADDRESSES ODI?S SAFETY CONCERNS WITH ETM FAILURES.ODI WILL CONTINUE TO MONITOR THE SUBJECT VEHICLES TO DETERMINE IF ADDITIONAL ACTION IS REQUIRED.THIS ENGINEERING ANALYSIS IS CLOSED.

PE05-041 WAS OPENED ON JULY, 26, 2005, BASED ON 136 CONSUMER COMPLAINTS TO ODI ALLEGING THROTTLE CONTROL MALFUNCTIONS IN THE SUBJECT VEHICLES.ODI HAS NOW RECEIVED 591 COMPLAINTS OF ETM FAILURES WHICH ALLEGE SYMPTOMS WITH POTENTIAL SAFETY RELATED CONSEQUENCES.THESE INCLUDE ALLEGATIONS OF ENGINE STALL, VEHICLE SURGING FORWARD WITHOUT ACCELERATOR INPUT, VEHICLE HESITATION UPON ACCELERATION AND SUDDEN AND UNEXPECTED TRANSITION INTO REDUCED PERFORMANCE OPERATION (LIMP MODE).VOLVO SUBMITTED OVER 2,900 COMPLAINTS CONCERNING THE ETM IN THE SUBJECT VEHICLES DURING PE05-041.ODI'S PRELIMINARY ANALYSIS OF A SAMPLE THE VOLVO COMPLAINTS IDENTIFIED APPROXIMATELY 55 PERCENT WITH ONE OR MORE OF THE SYMPTOMS DESCRIBED ABOVE.ODI IS CONTINUING ITS ASSESSMENT OF THE INFORMATION CONTAINED IN THE VOLVO COMPLAINTS. IN NOVEMBER 2005, TO RESOLVE AN INVESTIGATION BY THE CALIFORNIA AIR RESOURCES BOARD, VOLVO ANNOUNCED THAT IT WOULD EXTEND THE WARRANTY COVERAGE TO 10 YEARS / 200,000 MILES FOR THE ETM IN APPROXIMATELY 356,000 MODEL YEAR 1999 THROUGH 2002 PASSENGER CARS SOLD IN THE UNITED STATES AND CANADA.UNDER VOLVO'S POLICY, VEHICLES THAT EXPERIENCE ETM FAILURES WILL RECEIVE A VARIETY OF REPAIRS INCLUDING ETM CLEANING, REPROGRAMMING THE ENGINE CONTROL MODULE AND/OR REPLACEMENT OF THE ETM. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA05-021) TO CONTINUE TO ASSESS THE SAFETY CONSEQUENCES OF ETM FAILURES IN THE SUBJECT VEHICLES.

ON AUGUST 23, 1999, VOLVO NOTIFIED NHTSA THAT IT WOULD CONDUCT A SAFETY RECALL (99V235) ON CERTAIN 1997 MODEL YEAR (MY) 850 VEHICLES AND CERTAIN 1998 S/V/C 70 SERIES VEHICLES FOR FAILURE OF THE HEADLIGHT SWITCH.THE DEFECT REPORT STATED IN PART: OPERATION OF THE HEADLIGHT SWITCH, OVER AN EXTENDED PERIOD OF TIME, CAN RESULT IN INCONSISTENT OPERATION OF THE SWITCH.VOLVO'S REMEDY FOR THIS RECALL WAS TO REPLACE THE HEADLIGHT SWITCH.THIS RECALL QUERY INVESTIGATION WAS OPENED ON JUNE 8, 2004, BASED ON 13 REPORTS OF HEADLIGHT FAILURE ON 1998 AND 1999 S/V/C 70 SERIES VEHICLES THAT WERE NOT INCLUDED IN THE EARLIER RECALL.BY LETTER OF OCTOBER 18, 2004, VOLVO HAS NOTIFIED THE AGENCY THAT IT WILL NOW CONDUCT A SAFETY RECALL OF AN ADDITIONAL 97,000 MY 1998 THROUGH 2000 S70/V70/V70XC AND C70 VEHICLES BUILT FROM JUNE 5, 1997 THROUGH JANUARY 11, 2000. VOLVO DEALERS WILL REPLACE THE ORIGINAL EQUIPMENT MASTER LIGHT SWITCH WITH ONE OF AN IMPROVED DESIGN. SEE SAFETY RECALL 04V504 FOR DETAILS.

I TOOK MY CAR TO THE DEALER BECAUSE IT WAS NOT PASSING SMOG AND HAD TROUBLE FOR SEVERAL YEARS. SO THE SMOG DEALER TOLD ME TO TAKE IT TO THE DEALER. I TOLD THE DEALER THAT I WAS TRYING TO PASS SMOG, BUT THE CAR HAD BEEN DRIVING VERY GOOD IN SPITE OF THE SMOG PROBLEM. THEY REPLACED EVERYTHING THAT YOU CAN IMAGINE AT A COST OF OVER 10,000 DOLLARS WHICH BOTH OF US SPENT IN A TWO MONTH PERIOD. BUT AFTER THEY GOT IT TO PASS SMOG I NOTICED ANOTHER MORE SERIOUS PROBLEM, IT WOULD STOP RUNNING IN THE MIDDLE OF TRAFFIC. I TOLD THEM ABOUT THIS NEW PROBLEM AND THEY REPLACED THE KEY AND IT STILL STOPPED ON ME 3 X ON THE FREEWAY AND STREETS. I RETURNED THE CAR GOING DOWN THE MAIN STREETS FOR 2 HOURS AND LIFT IT WITH THE COMPANY. MCKEVITT VOLVO IN SAN LEANDRO CA. THEY WANTED TO CHARGE ME BUT I TOLD THEM MY ARE DID NOT HAVE THIS PROBLEM UNTIL THEY WORKED ON IT! I NEED A WORKING CAR AND I AM IN DEPT AS A RESULT OF THEIR WORK. I AM A 65 YEAR OLD RETIRED TEACHER BUT I CAN'T AFFORD THIS DEPT. 11

NHTSA ID

11165020

Incident

Nov 15, 2018

TL* THE CONTACT OWNS A 2000 VOLVO V70. WHILE DRIVING 65 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED, BUT THE VEHICLE FAILED TO MOVE FORWARD AS THE RPMS INCREASED. THE CHECK ENGINE AND ETS WARNING LIGHTS ILLUMINATED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 146,000.

NHTSA ID

10785051

Incident

Oct 1, 2015

Mileage

146,000 mi

TL* THE CONTACT OWNS A 2000 VOLVO V70. WHILE DRIVING 65 MPH, THE RPMS EXCESSIVELY INCREASED AND THE ETS WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS AWARE OF NHTSA CAMPAIGN NUMBER: 06V441000 (VEHICLE SPEED CONTROL); HOWEVER, THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS 115,000.

NHTSA ID

10727037

Incident

Jan 1, 2015

Mileage

115,000 mi

TL* THE CONTACT OWNS A 2000 VOLVO V70. THE CONTACT STATED THAT HE WAS REAR ENDED AT 45 MPH AND A VOLVO ADVERTISEMENT INDICATED THAT THE VEHICLE WAS EQUIPPED WITH SPECIAL SEATS TO AVOID SERIOUS INJURIES WHEN A CRASH OCCURRED. WHEN THE CRASH OCCURRED THE CONTACTS HEAD STRUCK THE STEERING WHEEL, BROKE THE STEERING WHEEL, THE HEAD REST AND THE SEAT. THE IMPACT FROM THE REAR END COLLISION CAUSED THE REAR SEATS TO BE PUSHED CLOSER TOWARDS THE FRONT AND REAR PASSENGER SEATS. THE IMPACT ALSO CAUSED DAMAGE TO THE EXTERIOR OF THE VEHICLE INCLUDING A CREASE IN THE ROOF OF THE VEHICLE IN A V-SHAPE. NONE OF THE AIR BAGS DEPLOYED; HOWEVER, THE CONTACT WAS TOLD THAT DURING A REAR END CRASH THE AIR BAGS DO NOT DEPLOY. THE VEHICLE WAS DESTROYED. THE CONTACT WAS UNCONSCIOUS AND ANOTHER DRIVER PASSING BY CALLED THE AMBULANCE ON HIS BEHALF. THE FIREMAN ADVISED THE CONTACT THAT ALTHOUGH HE WAS DRIVING THE VEHICLE THEY FOUND HIM UNCONSCIOUS IN THE BACK SEAT. THE CONTACT SUSTAINED A BROKEN NOSE, A DEVIATED SEPTUM, A SEVERE CASE OF ASTHMA, HEART DISEASE, AND WAS COMPLETELY INCAPACITATED AFTER THE CRASH OCCURRED. THE T7 AND T9 THORACIC VERTEBRAE WERE FRACTURED. THE CRASH HAD CAUSED THE CONTACT TO LIVE WITH A TRAUMATIC BRAIN INJURY. THE MANUFACTURER DISPATCHED A TECHNICIAN TO INSPECT THE VEHICLE AND ADVISED THE CONTACT THAT THERE WAS NOTHING WRONG THE VEHICLE; HOWEVER, HE WOULD NOT PROVIDE THE CONTACT, THE INSURANCE COMPANY OR HIS ATTORNEY WITH COPIES OF THE REPORT OR PHOTOS TAKEN DURING THE INVESTIGATION. A POLICE REPORT WAS FILED. THE VIN WAS NOT PROVIDED. THE CURRENT AND FAILURE MILEAGE WERE 100,000.

NHTSA ID

10593692

Incident

Oct 28, 2012

Mileage

100,000 mi

TL* THE CONTACT OWNS A 2000 VOLVO V70. THE CONTACT STATED WHILE THE VEHICLE WAS AT A STOP, THE FRONT SEAT FAILED TO HOLD THE CONTACT IN POSITION CAUSING HIM TO BE REAR ENDED. THE CONTACT WAS INJURED AND RECEIVED IMMEDIATE MEDICAL ATTENTION. THE VEHICLE WAS DESTROYED. A POLICE REPORT WAS FILED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND OFFERED NO REMEDY. THE FAILURE WAS NOT DIAGNOSED BY A DEALER OR LOCAL MECHANIC. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WERE 100,000.

NHTSA ID

10593680

Incident

Oct 28, 2012

Mileage

100,000 mi

TL* THE CONTACT OWNS A 2000 VOLVO V70 STATION WAGON. THE CONTACT STATED WHILE SITTING IN TRAFFIC, THE VEHICLE WAS CRASHED INTO FROM THE REAR. THE PASSENGER AND DRIVERS SIDE AIR BAGS DID NOT DEPLOY. THE VEHICLE WAS DESTROYED. A POLICE REPORT WAS FILED. THE CONTACT WAS INJURED AND RECEIVED IMMEDIATE MEDICAL ATTENTION. THE MANUFACTURER WAS NOTIFIED AND DID NOT OFFER A REMEDY. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WERE 200,070.

NHTSA ID

10593671

Incident

Oct 28, 2012

Mileage

200,070 mi

MY VOLVO V70 HAS BEEN DYING IMMEDIATELY AFTER STARTING THE ENGINE AND HAS PROGRESSIVELY GOTTEN WORSE OVER THE LAST 6 MONTHS. HAVE HAD TWO TRIPS TO A MECHANIC WHO REPAIRED A FEW PARTS, BUT IT DIDN'T FIX IT. PROBLEM CONTINUES. RECENTLY, WE WERE DRIVING ON THE HIGHWAY AT ABOUT 65 MPH AND THE CAR SPEED DROPPED TO ABOUT 20 MPH AND COULDN'T GO ANY FASTER AND WE HAD TO PULL OVER. THIS IS A MAJOR SAFETY RISK. NOW THE CAR STARTS AND IMMEDIATELY DIES FOR ABOUT 4-5 TIMES BEFORE IT WILL START AND CONTINUE RUNNING. THERE IS A WHIRRING NOISE COMING FROM THE ELECTRONIC THROTTLE WHEN IT DIES IMMEDIATELY. I TOOK IT TO A VOLVO DEALER AND THEY SAID A RECALL FOR A SOFTWARE UPDATE WAS PERFORMED ON MY CAR IN 2006 TO LOWER THE WEAR INSIDE THE THROTTLE. THEN VOLVO ISSUED A SERVICE CAMPAIGN FOR THE ETM WHEN IT FAILS, BUT THE CAMPAIGN LASTED UNTIL 200,000 MILES OR 10 YEARS. SO EVEN THOUGH THE CAR HAS ONLY 94K MILES AND THE RECALL SOFTWARE WAS INSTALLED ONLY 25K MILES AGO, VOLVO WON'T REPLACE A CRITICAL PART TO THE SAFE OPERATION OF THE VEHICLE BECAUSE THE 10 YEARS HAVE PASSED. SO THE DEALER AND VOLVO REFUSED TO REPLACE THIS PART EVEN THOUGH THE ETM ALREADY HAD A RECALL AND SERVICE CAMPAIGN IN THE PAST. 2 ACTIONS TO ADDRESS A DEFECTIVE PART, BUT VOLVO DIDN'T FIX THE PROBLEM AND I HAVE A BAD PART IN MY VOLVO THAT IS UNSAFE. *JS

NHTSA ID

10585360

Incident

Oct 1, 2013

Mileage

93,000 mi

TL* THE CONTACT OWNS A 2000 VOLVO V70. THE CONTACT WAS STOPPED IN TRAFFIC WHEN ANOTHER VEHICLE CRASHED INTO THE REAR OF THE CONTACT'S VEHICLE WHILE DRIVING APPROXIMATELY 45 MPH. UPON IMPACT, THE DRIVER'S SEAT SPLIT IN HALF AND THE CONTACT WAS THROWN TO THE REAR DRIVER'S SIDE SEAT. HE HAD TO BE CUT OUT OF THE VEHICLE. THE VEHICLE WAS DESTROYED. THE FAILURE AND CURRENT MILEAGE WAS 100,000.

NHTSA ID

10482907

Incident

Oct 28, 2012

Mileage

100,000 mi

This is a Technical Journal: Text plus 2 PDFs and 1 .PNG Oil Consumption test. Perform the test. Follow service procedure
 Description and Service sections updated to clarify that vehicle reports are not required.

This is a TJ text only - The purpose of this TJ is to be a master reference list to easily identify any components that are on prior approval. This TJ will be regularily updated as items are added or removed from prior approval.
 Current items under prior approval are listed in the "Service" section

This is a Technical Journal. Vehicle type and platform identification.

This is a Technical Journal: Remote connection, BOMGAR application. Before joining a remote session:
 •Connect a suitable battery maintainer/charger and verify that the battery voltage indicated in VIDA is between 12.5V and 14.9V.
 •Connect to the vehicle over a wired connection using a VOE (Volvo OBD to Ethernet) adapter and perform a NEW vehicle readout.

Volvo Cars USA LLC and Volvo Car Canada LTD on behalf of the Volvo Car Corporation has decided to launch Service Action S10303 on certain model year 2025 EX90 vehicles.
 Volvo Car Investigations have identified that there is a pairing issue with the key fob.
 As a result, there is a possibility that the customer’s key fob is not paired to the vehicle.
 The corrective action is to download SP Software.
 S10303 affects 151 vehicles in the U.S and 5 in Canada.

Volvo Cars USA LLC and Volvo Car Canada LTD on behalf of the Volvo Car Corporation has decided to launch Service Action S10303 on certain model year 2025 EX90 vehicles.
 Volvo Car Investigations have identified that there is a pairing issue with the key fob.
 As a result, there is a possibility that the customer’s key fob is not paired to the vehicle.
 The corrective action is to download SP Software.
 S10303 affects 151 vehicles in the U.S and 5 in Canada.