RoadVitals

2004 Volvo V70XC Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
5
Latest May 20, 2017
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
3
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
1

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 2004 Volvo V70XC, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Fuel system360.0%
  • Interior & seats120.0%
  • Suspension120.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Fuel system

Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.

3
reports

From owner reports, verbatim

ENTERING MY VEHICLE I SMELLED A STRONG ODOR OF GASOLINE. UPON INVESTIGATION, I FOUND THIS WAS DUE TO A CRACKED FUEL PUMP. BECAUSE OF THIS VERY PROBLEM, THIS MAKE AND MODEL OF VEHICLE WAS OFFICIALLY RECALLED BY VOLVO IN 2009 AS PART OF NHTSA ACTION NUMBER : PE09039 NHTSA RECALL CAMPAIGN NUMBER : 09V483000 . HOWEVER THE RECALL ONLY APPLIES TO VEHICLES SOLD IN AL, AZ, AR, CA, FL, GA, HI, KY, LA, MS, NV, NM, NC, OK, SC, TN, TX, UT, VA AND THE US TERRITORIES. THE PROBLEM CAN HAPPEN TO ANY OF THESE CARS REGARDLESS OF WHERE THEY WERE SOLD. THE TEMPERATURE FLUCTUATIONS THAT MAY BE RESPONSIBLE FOR THE SAFETY HAZARD OCCUR IN NEW ENGLAND AS WELL AS THE SOUTH AND WEST. THE DEFECTIVE PART AND SAFETY ISSUE EXISTS FOR ALL OWNERS OF THESE CARS AND EVERY ONE OF THEM SHOULD BE RECALLED.

NHTSA ID 10767267 · filed Sep 21, 2015

FUEL SMELL COMING FROM TRUNK. POSSIBLE COMBUSTION. PREVIOUS RECALL WAS NOT EXTENDED TO COLORADO, BUT AS THE FRONT RANGE SUMMER TEMPERATURES AND DRYNESS ARE AN INDICATOR OF FAILURE, I WORRY THAT THIS RECALL SHOULD BE EXTENDED TO COLORADO OWNERS. *TR

NHTSA ID 10488917 · filed Dec 16, 2012

Too few reports in this category for a page of its own — they appear in the full complaint list.

Interior & seats

Reports naming seats, latches, locks, linkages and interior fittings.

1
report

From owner reports, verbatim

THE DRIVER SIDE SEAT WARMER CAUGHT FIRE. IT BURNED A HOLE THROUGH THE SIDE OF THE SEAT COVER AND ALSO CAUSED A MILD BURN TO MY LEG. I STOPPED THE CAR, SHUT OF THE SEAT WARMER, AND WAS ABLE TO EXTINGUISH THE FIRE WHILE IT WAS STILL SMALL. A SEARCH ON THE INTERNET REVEALED THAT OTHER OWNERS HAVE EXPERIENCED THIS PROBLEM. *TR

NHTSA ID 10695258 · filed Mar 19, 2015

Too few reports in this category for a page of its own — they appear in the full complaint list.

Suspension

Reports naming suspension components — springs, struts, shocks, control arms and related hardware.

1
report

From owner reports, verbatim

I WAS DEPARTING MY HOME VILLAGE ABOUT A BLOCK FROM MY HOME AND I HEARD A LOUD BANG IN THE FRONT DRIVER SIDE AT ABOUT 15 MPH!! NO BUMP.. NOTHING! I LOOKED UNDER THE CAR AND THERE WAS NO OBVIOUS ISSUE AT THE INITIAL LOOK AND I DROVE ANOTHER QUARTER MILE AND HEARD A SLIGHT GRIND OR NOISE ON SMALL BUMPS... THEN A CLANK. I BACKED UP AND THERE WAS A PIECE OF THE COIL SPRING ON THE ROAD!!!! THE FRONT LEFT - DRIVERS SIDE - COIL SPRING SNAPPED IN TWO. AT 101,000 MILES. THE CLEAN BREAK AND NO RUST OR UNUSUAL CORROSION INDICATES A FAULTY METAL. HOW CAN I TRUST THE VOLVO XC AGAIN!! SAFETY AND VOLVO ARE NO LONGER WORDS THAT SHOULD BE USED TOGETHER. MY COMPLAINTS TO VOLVO AMERICA WERE RESPONDED TO WITH NO CONSIDERATION TO THE MAGNITUDE OF THE ISSUE. VOLVO DID NOT STAND BEHIND THE OBVIOUS FLAW IN THE CONSTRUCTION OF THE VEHICLE. MANY OTHER COMPLAINTS ON NHTSA AND ONLINE FORUMS INDICATE A COMMON ISSUE WITH VOLVO XC SUSPENSION COIL SPRINGS. SO DANGEROUS!

NHTSA ID 10990697 · filed May 20, 2017

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .