RoadVitals

2019 Volvo V90

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
1
Latest Jun 25, 2025
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
3
Latest Jun 2, 2021
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

Overview

Our database contains 1 NHTSA owner-reported complaint for the 2019 Volvo V90, most frequently naming the exterior lighting category. 3 safety recalls have been issued covering this model year; and 292 manufacturer communications are on file.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

  • Exterior lighting1100.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

3 campaigns cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
21V414000

ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS; FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Jun 2, 2021
85,550 units potentially affected
The defect: Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2020 V90, XC60, S60, V60, V60CC, S90, V90CC, S90L, and XC90 vehicles. The low-pressure fuel pump can blow a fuse and fail.
The risk: Failure of the low-pressure fuel pump can cause a stall, increasing the risk of a crash.
The remedy: Dealers will replace the fuse, free of charge. Owner notification letters were mailed July 2, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10100.
Volvo Car USA, LLCManufacturer number R10100View on NHTSA.gov
20V144000

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING; FORWARD COLLISION AVOIDANCE:SOFTWARE:PEDESTRIAN/CYCLIST/OBJECT/OBSTACLE/ RECOGNITION

Mar 12, 2020
121,605 units potentially affected
The defect: Volvo Cars USA LLC (Volvo Cars) is recalling certain 2019-2020 S60, V60, V60 Cross Country, S90L, V90, V90 Cross Country, XC40, XC60, and XC90 vehicles. Due to a software/hardware incompatibility, the Automatic Emergency Brake (AEB) system may not detect obstacles and engage as intended.
The risk: If the automatic emergency braking system does not engage as intended, it can increase the risk of a crash.
The remedy: Volvo will notify owners, and dealers will update the Active Safety Domain Master (ASDM) software, free of charge. The recall began April 9, 2020. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R29998.
Volvo Car USA LLCManufacturer number R29998View on NHTSA.gov
18V800000

ELECTRICAL SYSTEM:SOFTWARE

Nov 13, 2018
17,548 units potentially affected
The defect: Volvo Car USA LLC (Volvo) is recalling certain 2017-2019 Volvo XC90, S90, V60, V60 Cross Country, V90, XC40, XC60, and V90 Cross Country vehicles. The software installed in the Vehicle Connectivity Module (VCM) may have an error causing the Telematics and Driver Support Systems to function improperly. As a result, the GPS will not provide location information to emergency personnel in the event of an emergency.
The risk: If the GPS location is not provided to emergency personnel it can inhibit emergency response in the event of a crash or injury.
The remedy: Volvo will notify owners, and dealers will correct the software, free of charge. The recall began December 26, 2018. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R39917.
Volvo Car USA LLCManufacturer number R39917View on NHTSA.gov

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

Exterior lighting
Filed Jun 25, 2025

Rear taillight failure due to moisture incursion. No message appeared, but light failure was observed less than a month ago. Car is in for regular service now and item is being replaced at great personal expense, since it will not pass required safety inspection until repaired. Reporting this here because it is a known problem for hundreds of owners of this vehicle, and should be subject to a safety recall, but Volvo has repeated refused to address this flaw. Please see the documentation here of many other instances of same: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID
11669217
Incident
Jun 1, 2025

Manufacturer communications

A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.

33031.6.0

This is a Technical Journal: Text plus 1 .jpg attachment - If remote control key is not detected by the car and shows message in DIM "Car key not found" or if functions such as lock/unlock are not working, please follow advice for detecting key

36496.10.0

POWER TRAIN

This is a Technical Journal: Intermittent knocking noise during acceleration. If the sound corresponds to attached sound file, change front drive shafts to the below part numbers.

34521.11.1

EXTERIOR LIGHTING

This is a Technical Journal: Headlamp condensation inside lens - information/leak test. If the result is not ok (air leak), it is ok to replace the headlamp

35526.1.8

ENGINE

This is a Technical Journal: Text plus 2 PDFs and 1 .PNG Oil Consumption test. Perform the test. Follow service procedure
 Description and Service sections updated to clarify that vehicle reports are not required.

37809.1.1

This is a TJ text only - The purpose of this TJ is to be a master reference list to easily identify any components that are on prior approval. This TJ will be regularily updated as items are added or removed from prior approval.
 Current items under prior approval are listed in the "Service" section

34521.10.0

EXTERIOR LIGHTING

This is a Technical Journal: Headlamp condensation inside lens - information/leak test. If the result is not ok (air leak), it is ok to replace the headlamp

Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Compare model years

Complaint and recall counts across every year of this model

Volvo V90 by model year
YearComplaintsRecallsInvestigationsIssue Index
2024000—
2023000—
2022030—
2021120—
2020120—
2019Viewing130—
2018210—
2017010—
1999002—
1998100139.1
1997100—
1996000—
1995000—
1994000—
1993100—
1992000—
1991000—
1990000—
1989000—
1988000—
1987000—
1986000—
1985000—

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.