2024 Volvo XC90 Problems

My 2024 Volvo XC90 has experienced complete battery and electrical failure three times in approximately ten months. The failure pattern is identical each time. The battery discharges fully with no prior warning. A jump start restores power briefly, but the vehicle does not hold a charge and shuts down again, so it must be towed. The battery has been replaced three separate times by authorized Volvo retailers and the failure keeps recurring, which indicates the underlying cause has not been identified. Component: Electrical system, specifically a suspected parasitic current draw causing complete discharge of the 12V battery. The vehicle is available for inspection on request. Safety risk: The vehicle becomes completely inoperable without warning and has stranded me three times, requiring towing on each occasion. There is no advance indication that the battery is failing. Because the failure is sudden and unpredictable, the vehicle cannot be relied on to start in an emergency or to remain operable, and I have no confidence that a failure will not occur at a time or place that puts occupants at risk. Confirmed by dealer: Yes. Each failure was confirmed by an authorized Volvo dealer, which replaced the battery each time. Repairing dealers include Independence Volvo and University Volvo. The failures occurred in approximately October 2025, approximately March or April 2026, and [date of current failure]. The vehicle is currently at [dealer] for the third occurrence. Inspection by manufacturer or others: Volvo Car USA corporate has not inspected the vehicle. No police or insurance inspection. To my knowledge no dealer has performed or documented a parasitic draw test to locate the source of the discharge. Warning lamps or symptoms: None. There were no warning lamps, dashboard messages, or symptoms of any kind before any of the three failures. The vehicle operated normally and then would not start. Total days out of service: at least 15 days across the three times

The Infotainment Head Unit (IHU) on my 2024 Volvo XC90 has experienced repeated total system blackouts, spontaneous power-cycles, and critical thermal failures while operating at highway speeds (46–77 MPH). The IHU displays a "Cooling Infotainment System" critical warning and fails completely, resulting in total loss of the federally mandated rearview/backup camera (FMVSS 111 violation), GPS navigation, and all safety interfaces while in motion. The dealer confirmed the defect and attempted repair twice but only performed software resets rather than hardware replacement. The dealer documented "FIXED FAILED." Failures have continued and worsened after both repair attempts. Video documentation exists for all incidents (Exhibits A–H, dated May 2–7, 2026, odometer 41,900–42,151 miles). The vehicle's own diagnostic system issued a Critical Thermal Warning on the driver cluster while navigating traffic, confirming a hardware cooling defect. Two failures occurred during active driving maneuvers including a reverse maneuver and highway operation on I-20, creating immediate safety risk to the driver and public. The component is available for inspection. The defect has been confirmed by the Volvo dealer. A Texas Lemon Law complaint has been filed.

The contact owns a 2024 Volvo XC90. The contact stated that while the vehicle was parked with the contact about to exit the vehicle, the vehicle rolled forward unexpectedly and crashed into the vehicle in front. The contact stated that after striking that vehicle, the vehicle independently started reversing and struck a mailbox and some trees. The brake pedal was depressed; however, the vehicle failed to stop until the rear of the vehicle struck the second tree. The contact stated that none of the air bags deployed. The rear of the vehicle was damaged, and the driver’s side rear wheel was tilted outwards at a 45-degree angle. The contact was taken to the ER and was treated for bruises and pain to the head. A Police report was filed. The vehicle was towed to a Collision Repair center by the police, but was not yet inspected. The dealer was not contacted. The manufacturer was not made aware of the failure. The failure mileage was approximately 37,000.

The Infotainment Head Unit (IHU) on my 2024 Volvo XC90 has experienced repeated total system blackouts, spontaneous power-cycles, and critical thermal failures while operating at highway speeds (46–77 MPH). The IHU displays a "Cooling Infotainment System" critical warning and fails completely, resulting in total loss of the federally mandated rearview/backup camera (FMVSS 111 violation), GPS navigation, and all safety interfaces while in motion. The dealer confirmed the defect and attempted repair twice but only performed software resets rather than hardware replacement. The dealer documented "FIXED FAILED." Failures have continued and worsened after both repair attempts. Video documentation exists for all incidents (Exhibits A–H, dated May 2–7, 2026, odometer 41,900–42,151 miles). The vehicle's own diagnostic system issued a Critical Thermal Warning on the driver cluster while navigating traffic, confirming a hardware cooling defect. Two failures occurred during active driving maneuvers including a reverse maneuver and highway operation on I-20, creating immediate safety risk to the driver and public. The component is available for inspection. The defect has been confirmed by the Volvo dealer. A Texas Lemon Law complaint has been filed.

Some critical functions on the center display console instrument panel are freezing up while driving - we are unable to change the drive mode while the car is in motion. This has not happened before, and it is glitching a lot lately. The display has been extremely slow and unresponsive, and the problem is multiplied as all critical functions of the car are controlled through the display panel. There were no warnings issued when we tried to change the drive mode. We had to pull over to the roadside, turn off the car for 30 seconds, then restart the car to fix the issue. We have [XXX] and [XXX] ) in the car, so this is becoming increasingly risky to drive this "safe" car by Volvo. We have reported such issues with the display to our Volvo service unit multiple times, and the car has been returned to us with such issues still lingering (despite the service reloading/updating the software multiple times) for the last 6 months since March of this year. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The park button does not always engage the park setting. Instead it takes 2-3 presses for park to engage. It happens several times a week when I am driving the vehicle multiple times per day. I come to a complete stop, press the park button, wait for my dash to show I’m in park, if it doesn’t, I press it until it does. This has resulted in the vehicle rolling forward several times while passengers were trying to exit the vehicle, because I had not first checked to be sure the park button worked. Huge safety concern. I have owned this vehicle since August 2023 and it has happened at about this frequency since I’ve owned the vehicle. For the first time, my vehicle actually trolled enough to hit an appliance in my garage. I have a maybe related issue with the infotainment system freezing since I’ve owned the vehicle as well. The screen will freeze and we have to reset it by holding down the clean screen button for like 20 seconds.

I am reporting a serious and ongoing safety defect involving my 2024 Volvo XC90. The vehicle has experienced intermittent unintended acceleration, intermittent loss of safety and alert systems, and false obstacle detection that triggers unexpected braking or steering input. These events occur randomly and without warning, and are not tied to a specific driver, key, driving condition, or user behavior. At times, the vehicle accelerates on its own without driver input. At other times, the vehicle detects objects that are not present, causing the car to suddenly stop while reversing or swerve to avoid perceived obstacles that are not actually in the roadway. These events occur unpredictably and create a risk of collision with surrounding vehicles, pedestrians, or objects. During these occurrences, safety systems and alerts may become unavailable or inoperable, leaving the driver without audible or visual warnings. Audio alerts and system feedback have also stopped functioning during these events, further increasing the safety risk. The vehicle has been brought in for service approximately 8–9 times for various concerns, including these safety issues. Despite repeated service visits, the problems remain unresolved. Restarting the vehicle sometimes restores functionality, but the defects continue to recur unpredictably. This vehicle is used to transport young children, and these failures present a significant risk of serious injury or death. The unpredictability of the unintended acceleration, false braking/steering, and loss of safety systems makes the vehicle unsafe to operate. I am submitting this complaint due to concern for my family’s safety and the safety of others on the road, and because the manufacturer has not resolved the defect after repeated attempts. These issues have occurred since we received the car in September 2024

1. When the air condition is turned on there is knocking/banging/thumping noise. It starts with a whinning noise and then gets thumping noise and then starts again with a whinning noise followed my a thumping noise. It can go over 15 to 20 mins and then stops and restarts again. Yes, it can easily be reproduced. 2. The whinning and thumping noise while the car is driving can cause a safety issue where something could explode (the way it sounds) or air condition can simply not working as we approach summer. 3. Yes, its been reproduced, I've sent them the videos, i was at the dealership to reproduce and they acknowledge there is an issue. Weaver brother volvo had created an internal case to Volvo Technical Assistance, case number: RTS-US831535. The reply was they are aware about this issue and they are investigating it. The issues seems to be on the expansion valve and they are still investigating it. This was dated August 6th, 2024. 4. No warning lamps or messages or other symptoms. June 26th, 2024. The issue was reported to dealer around July, 25th 2024.

The contact owns a 2024 Volvo XC90. The contact stated that while the vehicle was parked with the contact about to exit the vehicle, the vehicle rolled forward unexpectedly and crashed into the vehicle in front. The contact stated that after striking that vehicle, the vehicle independently started reversing and struck a mailbox and some trees. The brake pedal was depressed; however, the vehicle failed to stop until the rear of the vehicle struck the second tree. The contact stated that none of the air bags deployed. The rear of the vehicle was damaged, and the driver’s side rear wheel was tilted outwards at a 45-degree angle. The contact was taken to the ER and was treated for bruises and pain to the head. A Police report was filed. The vehicle was towed to a Collision Repair center by the police, but was not yet inspected. The dealer was not contacted. The manufacturer was not made aware of the failure. The failure mileage was approximately 37,000.

Pressing P button does not engage the parking brake 100% of the time. Multiple times I have pressed the P button when concluding a drive and pulling into a spot with the normal friction brakes engaged, and nevertheless the car keeps rolling once the brake pedal is released, until the P button is pressed again in a much more deliberate fashion. This is a big safety issue. Pressing the P button with normal force should cause the parking brake to engage. At this point I now bypass the P button and switch the car off, which I know works 100% of the time to auto-engage the parking brake. Volvo needs to address the failure of the P button to perform its function.

At certain times during the day and evening the rear windows are hazy and sometimes hard to see out of.

On February 17, 2026 I was driving from Sacramento, CA to Oakland, CA (approximately 100 miles). At the start of the trip, I discovered that the vehicle’s heating and climate control system was not functioning. Specifically, the heater would not turn on, and as a result, the windshield defrost system would not activate. I attempted multiple times to turn the vehicle off and restart it to see if the system would reset, but the problem persisted. I also tried manually activating the front defrost using the dashboard controls; however, the defrost function would not engage. Weather conditions were approximately 40°F with heavy rain. Because the defrost system was inoperable, the windshield and windows became fogged over during the drive. This significantly impaired my visibility. I was unable to adequately clear the windshield, creating a dangerous driving condition for the duration of the trip. This malfunction directly impacted my ability to safely operate the vehicle in cold and rainy conditions. The inability to use the defrost system created a serious safety hazard due to reduced visibility.

Instrument cluster failure and turn signal malfunction while highway driving. No interior sounds, including no lane change warning or near collision warning signals, and no audible confirmation of signal; no exterior blinker activated despite use by driver. Instrument cluster went blank. Safety at risk and accident occurred: approaching car from rear passenger side hit front right side of our car because there was no exterior signal and no audio or visual alerts in our vehicle about lane change or blind spot. Signal and instrument cluster failure: the car is at the manufacturer/dealer for the third time for similar issues with our vehicle (2 prior times they stated the issue was fixed). Manufacturer reports that they're sending a team to investigate given that this most recent episode lead to an accident.

Since purchasing this vehicle in October 2023 I have had multiple issues with the fuel door not opening, the turn indicator light not working, the backup cmera and sensors continue to engage the rear brake intervention system when there's nothing behind the vehicle.

Safety Complaint – Volvo XC90 Electrical and Airbag Malfunction Issues I am reporting ongoing safety concerns with my Volvo XC90 related to electrical malfunctions and unexpected engine shutdowns while driving. The vehicle has suddenly turned off multiple times, including: •Once before merging onto a highway, •Once while entering a roundabout, and •Once while driving in traffic. Each incident occurred without warning and created a hazardous situation with the potential for a collision. Additionally, the vehicle displayed an airbag malfunction warning once, raising concern about the reliability of the vehicle’s safety systems. The vehicle has been serviced multiple times, but the issues persist. I am requesting a formal investigation into these failures, as they pose a significant safety risk to the driver, passengers, and others on the road.

Safety Complaint – Volvo XC90 Electrical and Airbag Malfunction Issues I am reporting ongoing safety concerns with my Volvo XC90 related to electrical malfunctions and unexpected engine shutdowns while driving. The vehicle has suddenly turned off multiple times, including: •Once before merging onto a highway, •Once while entering a roundabout, and •Once while driving in traffic. Each incident occurred without warning and created a hazardous situation with the potential for a collision. Additionally, the vehicle displayed an airbag malfunction warning once, raising concern about the reliability of the vehicle’s safety systems. The vehicle has been serviced multiple times, but the issues persist. I am requesting a formal investigation into these failures, as they pose a significant safety risk to the driver, passengers, and others on the road.

To Whom It May Concern, I am submitting this complaint to report a repeated and unresolved safety defect in my leased Volvo vehicle involving rear passenger door lock failure, which has resulted in minor children being trapped inside the vehicle on multiple occasions Vehicle Safety Issue: The left rear passenger door fails to open from both inside and outside, despite the child lock not being engaged. This creates a serious safety risk, particularly during emergencies when occupants must exit the vehicle quickly. Incident History: [XXX]: Rear door would not open from inside or outside, trapping my two children (ages [XXX] and [XXX] ). At the same time, the infotainment system froze and the backup camera was not functioning. I reported this to Volvo service. [XXX]: The same issue occurred again, resulting in my children being locked in the rear seat. One child was experiencing leg pain, and it was extremely difficult and unsafe to remove him through the front door. The dealer stated the rear lock assembly was replaced. [XXX]: Despite prior repair and assurances, the rear door failed again, trapping my child inside the vehicle. I have video evidence showing the door cannot be opened from outside. In addition, on a separate occasion, the vehicle completely froze and could not be unlocked using either key. AAA was required to jump-start the vehicle, and I was informed that a required software installation had not occurred. Safety Concern: A rear passenger door that cannot be opened from inside or outside presents an immediate safety hazard, especially involving children, medical emergencies, accidents, or fire. A non-functional backup camera further increases the risk of injury while reversing. This issue has occurred three times, including after a component replacement, indicating a recurring defect rather than an isolated incident. I am reporting this issue so it can be reviewed for potential safety investigation and corrective action. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOI