2014 Western Star 4900 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2014 Western Star 4900, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Body & structure233.3%
- Other / unspecified233.3%
- Exterior lighting116.7%
- Tires & wheels116.7%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
2014 WESTERN STAR 4900 CAR HAULER, JUST REPLACED 2 STEER TIRES TO 2014 MICHELIN XZA 275/70/R22.5 18 PLY. TIRE HAD LESS THEN 30,000 MILES AND PASSENGER SIDE BLOW OUT. FRONT DESTROYED. TRUCK WAS FULLY LOADED WITH ABOUT 75000 POUNDS. DRIVER LOST CONTROL AND TRAVELED FROM LEFT LANE TO SHOULDER. CAME TO STOP ON THE SHOULDER. INSURANCE PAID ALMOST $30,000. *TR
FRONT TIRE PASSENGER SIDE BLOW OUT. MICHELIN XZA 2 275/0.22.5. WHOLE FRONT OF THE TRUCK DAMAGED. HOOD BROKEN IN 2 PARTS. FENDER FLEW OFF. LIGHT FLEW OFF. RIM DESTROYED. REPAIR COST $16,000 TIRE WAS CHANGED AT ABOUT 90,000 MILES. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
Hi I had a trailer hitch failure yesterday causing the trailer to disconnect from the tow vehicle. The failure occurred at a faulty weld on the receiver hitch. The receiver hitch is a Angcosy one position hook mount 20,000 lb. 9" length model. Where the receiver tube is welded to the hitch mounting plate the weld failed causing the trailer to seperate from the tow vehicle. Upon examining the failed weld you could see there was no weld penetrating the hitch plate itself. Luckily I was moving the trailer on my property at a speed of 3 MPH, so no real damage done. I use this hitch for towing woodchippers and other car type trailers down the highway. If this would have occurred at highway speeds with the trailer becoming disconnected from the tow vehicle the results could have been life threatening. The hitch in question was in like new condition and only used 4-5 times. I bought the hitch thru Amazon and have notified them of the problem the faulty receiver hitch posses.
FRONT TIRE PASSENGER SIDE BLOW OUT. MICHELIN XZA 2 275/0.22.5. WHOLE FRONT OF THE TRUCK DAMAGED. HOOD BROKEN IN 2 PARTS. FENDER FLEW OFF. LIGHT FLEW OFF. RIM DESTROYED. REPAIR COST $16,000 TIRE WAS CHANGED AT ABOUT 90,000 MILES. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Exterior lighting
Reports naming headlights, tail lights, turn signals and other exterior lighting.
From owner reports, verbatim
FRONT TIRE PASSENGER SIDE BLOW OUT. MICHELIN XZA 2 275/0.22.5. WHOLE FRONT OF THE TRUCK DAMAGED. HOOD BROKEN IN 2 PARTS. FENDER FLEW OFF. LIGHT FLEW OFF. RIM DESTROYED. REPAIR COST $16,000 TIRE WAS CHANGED AT ABOUT 90,000 MILES. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
2014 WESTERN STAR 4900 CAR HAULER, JUST REPLACED 2 STEER TIRES TO 2014 MICHELIN XZA 275/70/R22.5 18 PLY. TIRE HAD LESS THEN 30,000 MILES AND PASSENGER SIDE BLOW OUT. FRONT DESTROYED. TRUCK WAS FULLY LOADED WITH ABOUT 75000 POUNDS. DRIVER LOST CONTROL AND TRAVELED FROM LEFT LANE TO SHOULDER. CAME TO STOP ON THE SHOULDER. INSURANCE PAID ALMOST $30,000. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .