RoadVitals

1995 Western Star Conventional Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
5
Newest Aug 1, 1996
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0

Recall campaigns

5 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

96V124003

SUSPENSION

Aug 1, 1996
36 units potentially affected
The defect: THE EQUALIZING BEAM SHAFT OF THE TANDEM AXLE SUSPENSION WERE MANUFACTURED FROM AS-ROLLED SAE4140 STEEL RATHER THAN THE SPECIFIED ANNEALED SAE4140. THESE SHAFTS CAN FRACTURE INSIDE THE BEAM AT THE TOE OF THE WELD.
The risk: VEHICLES ARE SUBJECT TO VEHICLE TILT AND POSSIBLE ROLLOVER IN THE EVENT THAT BOTH EQUALIZING BEAMS, ON THE SAME SIDE OF THE VEHICLE, EXPERIENCE A SIMULTANEOUS SHAFT FAILURE. AFFECTED SUSPENSIONS CAN ALSO DROP AND CONTACT THE ROAD SURFACE GENERATING SPARKS WHICH COULD IGNITE FLAMMABLE MATERIAL.
The remedy: OWNER NOTIFICATION IS BEING CONDUCTED BY NEWAY ANCHORLOK. DEALERS WILL INSPECT AND REPLACE ALL SUSPENSION SUSPENSION BEAMS WITH SUSPENSION BEAMS CONTAINING APPROPRIATE SHAFTS.
WESTERN STAR TRUCKS, INC.View on NHTSA.gov
96V025000

VEHICLE SPEED CONTROL:SPRINGS

Feb 6, 1996
490 units potentially affected
The defect: THE THROTTLE RETURN SPRINGS CAN FAIL.
The risk: IF BOTH SPRINGS FAIL, THE ENGINE IS NOT LIKELY TO RETURN TO IDLE WHEN THE ACCELERATOR IS RELEASED, CAUSING LOSS OF VEHICLE SPEED CONTROL AND SUDDENLY INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
The remedy: REPLACEMENT THROTTLE RETURN SPRINGS WILL BE MAILED DIRECTLY TO OWNERS. IF THE OWNERS PREFER, THEIR DEALERS CAN INSTALL THE SPRINGS FOR THEM.
WESTERN STAR TRUCKS, INC.View on NHTSA.gov
96V022000

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE

Jan 5, 1996
21 units potentially affected
The defect: THESE HEAVY TRUCKS WERE EQUIPPED WITH EXHAUST MUFFLERS WITHOUT HEAT SHIELDING.
The risk: SOMEONE WORKING BEHIND THE CAB COULD CONTACT THE HOT MUFFLER CAUSING PERSONAL INJURY. ALSO SOME OF THESE VEHICLES WERE EQUIPPED WITH DECK PLATES WITH NO GRAB HANDLES FOR ACCESS.
The remedy: DEALERS WILL INSTALL MUFFLER SHIELDS AND, WHERE NECESSARY, GRAB HANDLES.
WESTERN STAR TRUCKS, INC.View on NHTSA.gov
95E003002

SERVICE BRAKES, AIR:SUPPLY:HOSES, LINES/PIPING, AND FITTINGS

Mar 13, 1995
283 units potentially affected
The defect: AIR SYSTEM BLOCKAGE IN THE AIR DRYER OCCURS DEGRADING THE MOISTURE REMOVING CAPABILITIES OF THE DRYER WHEN THE VEHICLE IS OPERATED IN A COLD ENVIRONMENT AND MOISTURE ACCUMULATES AND FREEZES IN THE AIR DRYER OR IN THE LINE BETWEEN THE DRYER AND THE AIR SYSTEM RESERVOIR. THE AIR DRYER CAN BECOME OVER PRESSURIZED CAUSING THE AIR DRYER CARTRIDGE TO SEPARATE FROM THE MOUNTING BASE.
The risk: IF THE AIR DRYER SEPARATES FROM THE BASE, THE CARTRIDGE CAN SEPARATE SUFFICIENTLY ENOUGH TO CAUSE PERSONAL INJURY OR PROPERTY DAMAGE.
The remedy: DEALERS WILL EQUIP AIR SYSTEMS WITH A PRESSURE RELIEF VALVE TO BE LOCATED BETWEEN THE COMPRESSOR AND THE AIR DRYER. THIS PRESSURE RELIEF VALVE IS INTENDED TO VENT IF EXCESSIVE PRESSURE DEVELOPS IN THE AIR DRYER.
WESTERN STAR TRUCKS, INC.View on NHTSA.gov
95V014000

EQUIPMENT:RECREATIONAL VEHICLE/TRAILER

Jan 1, 1995
122 units potentially affected
The defect: STRAPS HOLDING THE SLEEPER UPPER BUNK IN THE RAISED POSITION CAN RELEASE WITHOUT WARNING.
The risk: IF THE RESTRAINING STRAP RELEASES SUDDENLY, THEBUNK FALLS WITHOUT WARNING AND CAN STRIKE AN OCCUPANT SITTING IN THE LOWER BUNK CAUSING PERSONAL INJURY.
The remedy: DEALERS WILL REPLACE THE UPPER BUNK RETAINING STRAPS WITH AN IMPROVED AUTOMOTIVE SAFETY BELT STYLE DESIGN STRAP.
WESTERN STAR TRUCKS, INC.View on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Elsewhere on this vehicle

Data sources