RoadVitals

2005 Workhorse P32

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
2
Latest Jun 23, 2020
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
1
Latest Jun 20, 2006
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
1

Overview

Our database contains 2 NHTSA owner-reported complaints for the 2005 Workhorse P32, most frequently naming the brakes category. 1 safety recall has been issued covering this model year.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

  • Brakes2100.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

1 campaign cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
06V225000

ENGINE AND ENGINE COOLING

Jun 20, 2006
30,335 units potentially affected
The defect: ON CERTAIN MOTOR HOME AND TRUCK CHASSIS EQUIPPED WITH GENERAL MOTORS 8.1L V8 ENGINES, IMPROPER HARDENING DURING THE HEAT TREATMENT PROCESS CAN CAUSE THE FUEL RAIL PULSE DAMPER RETAINER CLIP TO FRACTURE, RESULTING IN INADEQUATE RETENTION OF THE DAMPER. IF THE DAMPER BECOMES LOOSE, FUEL COULD BE PUMPED BY THE FUEL PUMP INTO THE UNDER HOOD AREA.
The risk: IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD RESULT.
The remedy: DEALERS WILL REPLACE THE FUEL RAIL PULSE DAMPER RETAINER CLIPS ON THESE ENGINES FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 1, 2006. OWNERS MAY CONTACT WORKHORSE AT 877-294-6773.
WORKHORSE CUSTOM CHASSISManufacturer number 60601-CView on NHTSA.gov

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

Brakes
Filed Jun 23, 2020
Fire reported

I HAVE HAD NOTHING BUT ISSUES WITH THE BRAKES. I HAVE REPLACED THE ABS SENSOR TWICE. THE BRAKES SUDDENLY JUST GO TO THE FLOOR SOMETIMES. TODAY I WAS DRIVING MOSTLY ON HIGHWAYS THEN I GOT OFF AND THE ABS LIGHT CAME ON. THEN I SAW SMOKE SO I STOPPED AND LOOKED AND THERE WAS A FIRE IN THE BRAKES AREA ON MY DRIVER SIDE FRONT TIRE. THERE WAS FLAMES SHOOTING UP 12 INCHES. AFTER DISTINGUISHING THE FIRE AND LETTING THE WHEEL COOL OFF I TOOK THE TIRE OFF TO INSPECT IT AND DISCOVERED THAT THE ABS SENSOR CAUGHT ON FIRE. *TR

NHTSA ID
11330434
Incident
Jun 23, 2020
Mileage
23,000 mi
Brakes
Filed Feb 12, 2019

IN MOTION THE BRAKES ARE STICKING, PRESS DOWN STICKS HAVE TO MANUALL PULL UP THE BRAKE PEDAL

NHTSA ID
11176546
Incident
Feb 7, 2019
Mileage
40,000 mi

Compare model years

Complaint and recall counts across every year of this model

Workhorse P32 by model year
YearComplaintsRecallsInvestigationsIssue Index
2006010—
2005Viewing210—
2004210—

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.