RoadVitals

2004 Workhorse P32

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
2
Latest Jun 19, 2018
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
1
Latest Jun 20, 2006
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

Overview

Our database contains 2 NHTSA owner-reported complaints for the 2004 Workhorse P32, most frequently naming the brakes and fuel system categories. 1 safety recall has been issued covering this model year.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

  • Brakes150.0%
  • Fuel system150.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

1 campaign cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
06V225000

ENGINE AND ENGINE COOLING

Jun 20, 2006
30,335 units potentially affected
The defect: ON CERTAIN MOTOR HOME AND TRUCK CHASSIS EQUIPPED WITH GENERAL MOTORS 8.1L V8 ENGINES, IMPROPER HARDENING DURING THE HEAT TREATMENT PROCESS CAN CAUSE THE FUEL RAIL PULSE DAMPER RETAINER CLIP TO FRACTURE, RESULTING IN INADEQUATE RETENTION OF THE DAMPER. IF THE DAMPER BECOMES LOOSE, FUEL COULD BE PUMPED BY THE FUEL PUMP INTO THE UNDER HOOD AREA.
The risk: IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD RESULT.
The remedy: DEALERS WILL REPLACE THE FUEL RAIL PULSE DAMPER RETAINER CLIPS ON THESE ENGINES FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 1, 2006. OWNERS MAY CONTACT WORKHORSE AT 877-294-6773.
WORKHORSE CUSTOM CHASSISManufacturer number 60601-CView on NHTSA.gov

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

Fuel system
Filed Jun 19, 2018

PULSE DAMPER IN THE FUEL RAIL IS LEAKING GAS ON TO THE ENGINE. I UNDERSTAND THAT THIS IS A FACTORY DEFECT PER INTERNET REPORTS. INTERNET REPORTS STATE TO CONTACT MANUFACTURER PER PHONE NUMBERS PROVIDED BUT NON WORK.

NHTSA ID
11102682
Incident
Jun 13, 2018
Mileage
14,945 mi
Brakes
Filed Jan 14, 2013

TL* THE CONTACT OWNS A 2004 GEORGIE BOY LANDAU RV EQUIPPED WITH A WORKHORSE P32. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE BRAKES SEIZED. THE CONTACT ALSO STATED THAT THE BRAKES BECAME EXTREMELY HOT AND A STRANGE ODOR COULD BE SMELLED IN THE CABIN. THE VEHICLE WAS NOT INSPECTED BY A DEALER OR AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 59,000. THE CURRENT MILEAGE WAS APPROXIMATELY 60,000.

NHTSA ID
10492942
Incident
Jan 14, 2012
Mileage
59,000 mi

Compare model years

Complaint and recall counts across every year of this model

Workhorse P32 by model year
YearComplaintsRecallsInvestigationsIssue Index
2006010—
2005210—
2004Viewing210—

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.