RoadVitals

2001 Workhorse W22 Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Data refreshed

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
3
Newest Apr 3, 2009
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
2 investigations on file

Recall campaigns

3 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

09V110000

SERVICE BRAKES, HYDRAULIC

Apr 3, 2009
48,876 units potentially affected
The defect: NAVISTAR IS RECALLING CERTAIN MODEL YEAR MY 2001-2008 WORKHORSE W20, W21 AND W22 CHASSIS AND CERTAIN MODEL YEAR 2009 THROUGH 2011 MONACO RV ADMIRAL, ARISTA, MONARCH, AND RIPTIDE RECREATIONAL VEHICLES EQUIPPED WITH AXLES THAT INCLUDE BOSCH ZOPS OR ZOHT PIN SLIDE HYDRAULIC DISC BRAKES. WHEN COMBINED WITH OCCASIONAL OR SEASONAL VEHICLE OPERATION MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION. THIS CAN RESULT IN ABNORMAL HEAT GENERATION AT THE WHEEL END CAUSING BRAKE DRAG. THE DRIVER WOULD NORMALLY HAVE WARNING OF THE BRAKE DRAG IF UNDETECTED BY THE DRIVER.
The risk: THE TEMPERATURE INCREASE AT THE WHEEL END CAN EVENTUALLY LEAD TO SOFT PEDAL CONDITIONS DUE TO BRAKE FLUID BOIL, AND POSSIBLE EXTENDED STOPPING DISTANCE INCREASING THE RISK OF A CRASH.
The remedy: WORKHORSE DEALERS WILL REPLACE ALL FOUR BOSCH BRAKE CALIPER ASSEMBLIES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2010. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731.
NAVISTAR, INCManufacturer number 50901-C & 51101-CView on NHTSA.gov
04V084000

SERVICE BRAKES, HYDRAULIC

Feb 18, 2004
10,235 units potentially affected
The defect: ON CERTAIN MOTORHOME CHASSIS EQUIPPED WITH BOSCH ZOPS, THE PADS CAN DRAG ON THE ROTOR SURFACE DUE TO THE PIN SLIDE.
The risk: A HANG UP OR LOCK UP MAY CAUSE THE CALIPERS TO OVER HEAT AND NOT ALLOW THE DRIVER TO STOP SAFELY. THIS COULD CAUSE OVERHEATING OF THE BRAKE CALIPERS WHICH COULD RESULT IN A VEHICLE FIRE.
The remedy: DEALERS WILL INSPECT, REPAIR AND REPLACE ACCORDING TO THE PROCEDURE DEVELOPED BY BOSCH (SEE CAMPAIGN 03E064000). THE RECALL BEGAN ON AUGUST 1, 2004. OWNERS SHOULD CONTACT WORKHORSE AT 1-877-294-6773.
WORKHORSE CUSTOM CHASSISManufacturer number 50401-CView on NHTSA.gov
01V317000

SUSPENSION:REAR:SPRINGS:LEAF SPRING ASSEMBLY:U-BOLT, LEAF SPRING TO AXLE

Oct 4, 2001
5,011 units potentially affected
The defect: VEHICLE DESCRIPTION: MOTOR HOME AND COMMERCIAL CHASSIS. THE REAR AXLE U-BOLTS MAY NOT BE TIGHTENED CORRECTLY DUE TO RANDOM FAILURE OF PRODUCTION TOOLING IN THE SPECIFIED TIME SPAN.
The risk: LOW U-BOLT TORQUE CAN RESULT IN U-BOLTS COMING LOOSE AND NOT PROPERLY RETAINING THE REAR AXLE TO THE VEHICLE, RESULTING IN A LOSS OF VEHICLE CONTROL.
The remedy: DEALERS WILL TIGHTEN THE REAR AXLE U-BOLTS. OWNER NOTIFICATION IS EXPECTED TO BEGIN OCTOBER 10, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT WORKHORSE AT 1-877-946-7731.
WORKHORSE CUSTOM CHASSISView on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect, and it is not a recall.

EA07016ClosedEngineering Analysis

OVERHEATING DISC BRAKE CALIPER

Opened Nov 16, 2007
Closed Aug 19, 2009

THE EA WAS OPENED TO GAIN A TECHNICAL UNDERSTANDING OF THE CAUSES FOR ONE OR MORE DISC BRAKE CALIPERS ON A SUBJECT VEHICLE TO SUFFER SEVERE OVERHEATING. THE OVERHEATING CAUSED BRAKE DRAG, MELTING ABS SENSORS, SMOKING, BRAKE LINING FIRES, AND IN SOME CASES BOILING BRAKE FLUID RESULTING IN DIMINISHED STOPPING CAPABILITY.BASED ON TESTING, WARRANTY AND COMPLAINT DATA ANALYSIS, FIELD TRIPS AND INTERVIEWS WITH OWNERS, MECHANICS AND SERVICE MANAGERS, ODI BELIEVES THE LIKELY CAUSE OF THE ALLEGED DEFECT IS WATER SWELL OF THE PHENOLIC CALIPER PISTON AND SUBSEQUENT FAILURE OF THE PISTON TO FULLY RETURN AFTER THE PEDAL IS RELEASED.A TECHNICAL REPORT IS ATTACHED WITH FULL DETAILS.

SERVICE BRAKES, HYDRAULICLed to recall 09V110000
EA03003ClosedEngineering Analysis

OVERHEATING FRONT AND REAR BRAKES

Opened Apr 9, 2003
Closed Mar 3, 2004

THIS INVESTIGATION WAS DERIVED FROM INFORMATION GATHERED DURING PE02-046, BOSCH DISC BRAKE CALIPERS.THIS INVESTIGATION FOCUSED ON THE VEHICLE MANUFACTURER, NEWMAR.SUBJECT VEHICLES WERE THOSE BUILT WITH A HYDRAULIC BRAKE SYSTEM INCORPORATING THE BOSCH ZERO OFFSET PIN SLIDE (ZOPS) CALIPERS.ODI'SCONCERN WASEXCESSIVE WHEEL END HEAT, POSSIBLY RESULTING IN A WHEEL END FIRE.DURING THE INVESTIGATION, ODI DISCOVERED TWO SPECIFIC NEWMAR VEHICLE MODELS, THOSE BUILT ON NEWMAR CHASSIS AND THOSE BUILT ON A WORKHORSE CHASSIS. AS A RESULT OF THE AGENY'S INVESTIGATION INTO THIS MATTER, ALL NEWMAROWNERS WILL BE NOTIFIED (04V-019) AND THE REMEDY WILL BE APPLIED TO THEIR VEHICLES. SOME NEWMAR VEHICLES (1,795) BUILT ON THE WORKHORSE CHASSIS ARE BEING RECALLED BY WORKHORSE (04V-084).THIS INVESTIGATION IS CLOSED.FURTHER DETAILS ARE PROVIDED ON PAGES 2, 3, AND 4.COPIES OF BOTH SAFETY RECALLS ARE ATTACHED.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTSLed to recall 04V019000

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .