RoadVitals

2005 Workhorse W24

Recalls, owner-reported complaints, investigations and safety data

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
0
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
2
Latest Jun 20, 2006
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
1
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

Overview

Our database contains no NHTSA owner-reported complaints for the 2005 Workhorse W24. 2 safety recalls have been issued covering this model year; and 1 NHTSA investigation names it.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Safety recalls

2 campaigns cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
06V225000

ENGINE AND ENGINE COOLING

Jun 20, 2006
30,335 units potentially affected
The defect: ON CERTAIN MOTOR HOME AND TRUCK CHASSIS EQUIPPED WITH GENERAL MOTORS 8.1L V8 ENGINES, IMPROPER HARDENING DURING THE HEAT TREATMENT PROCESS CAN CAUSE THE FUEL RAIL PULSE DAMPER RETAINER CLIP TO FRACTURE, RESULTING IN INADEQUATE RETENTION OF THE DAMPER. IF THE DAMPER BECOMES LOOSE, FUEL COULD BE PUMPED BY THE FUEL PUMP INTO THE UNDER HOOD AREA.
The risk: IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD RESULT.
The remedy: DEALERS WILL REPLACE THE FUEL RAIL PULSE DAMPER RETAINER CLIPS ON THESE ENGINES FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 1, 2006. OWNERS MAY CONTACT WORKHORSE AT 877-294-6773.
WORKHORSE CUSTOM CHASSISManufacturer number 60601-CView on NHTSA.gov
06V148000

STEERING

May 2, 2006
3,881 units potentially affected
The defect: CERTAIN CHASSIS MAY HAVE BEEN EQUIPPED WITH INCORRECT STEERING INTERMEDIATE SHAFTS. THE SPLINE CAN STRIP WHILE THE STEERING WHEEL IS BEING TURNED.
The risk: THIS STEERING CONDITION COULD INCREASE THE RISK OF A CRASH.
The remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE STEERING INTERMEDIATE SHAFTS. THE RECALL BEGAN ON MAY 22, 2006. OWNERS MAY CONTACT WORKHORSE AT 1-877-294-6773.
WORKHORSE CUSTOM CHASSISManufacturer number 20601-CView on NHTSA.gov

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect.

EA07016ClosedEngineering Analysis

OVERHEATING DISC BRAKE CALIPER

Opened Nov 16, 2007
Closed Aug 19, 2009

THE EA WAS OPENED TO GAIN A TECHNICAL UNDERSTANDING OF THE CAUSES FOR ONE OR MORE DISC BRAKE CALIPERS ON A SUBJECT VEHICLE TO SUFFER SEVERE OVERHEATING. THE OVERHEATING CAUSED BRAKE DRAG, MELTING ABS SENSORS, SMOKING, BRAKE LINING FIRES, AND IN SOME CASES BOILING BRAKE FLUID RESULTING IN DIMINISHED STOPPING CAPABILITY.BASED ON TESTING, WARRANTY AND COMPLAINT DATA ANALYSIS, FIELD TRIPS AND INTERVIEWS WITH OWNERS, MECHANICS AND SERVICE MANAGERS, ODI BELIEVES THE LIKELY CAUSE OF THE ALLEGED DEFECT IS WATER SWELL OF THE PHENOLIC CALIPER PISTON AND SUBSEQUENT FAILURE OF THE PISTON TO FULLY RETURN AFTER THE PEDAL IS RELEASED.A TECHNICAL REPORT IS ATTACHED WITH FULL DETAILS.

SERVICE BRAKES, HYDRAULICLed to recall 09V110000

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

No owner complaints recorded for this model year

Either none have been filed with NHTSA, or this vehicle is too new for reports to have accumulated.

Compare model years

Complaint and recall counts across every year of this model

Workhorse W24 by model year
YearComplaintsRecallsInvestigationsIssue Index
2006220—
2005Viewing021—
2004011—
2003100—
2000100—

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.