2005 Yamaha FZ6 Owner Complaints

Hello, i ride this Yamaha FZ-6 motorcycle and I experience poor idling and engine stalls during riding, and last time this nearly led to accident, because the motorcycle slowed down in front of an overpassing automobile. I have bought this bike imported from USA. I am situated in Bulgaria, Europe. I saw there is a recall action about faulty TPS sensor. Kindly requesting any help for replacing this sensor by recall action. Thank you in advance for your kind support. [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA ID

11453978

Incident

Feb 23, 2022

ENGINE OIL PAN CRACKED AFTER TORQUING DRAIN PLUG TO MANUFACTURERS SPEC. HAVE READ MANY OTHER COMPLAINTS OF THIS SAME OCCURRENCE. CONTACTED LOCAL DEALER AND YAMAHA AMERICA. BOTH DECLINED KNOWLEDGE OF DEFECT. YAMAHA AMERICA WAS QUITE SHORT, DID NOT WANT TO HEAR ANY DETAILS OF THE FAILURE, JUST STATED THAT THERE WERE NO RECALLS, ANY DEFECTS WERE NO LONGER UNDER WARRANTY. *TR

NHTSA ID

10260324

Incident

Feb 7, 2009

Mileage

5,225 mi

MY 2005 FZ6 RAN FLAWLESSLY TILL 4000 MILE THEN THE IDLE WAS DROPPING TO 600-800 AND THEN WOULD JUST DIE. I WOULD TURN KEY OFF AND TURN KEY ON AGAIN AND RESTART AND IT WOULD RUN FINE. IT HAPPENS TWICE A WEEK. ONCE ON WET PAVEMENT IT WAS FEELING BOGGISH I PULLED CLUTCH TO SEE AND IT WAS 600-800 AND DIED. I LET OUT CLUTCH AND ALMOST LOST IT. I READ ABOUT SEVERAL OTHER OWNERS EXPERIENCING SAME PROBLEM AND SOME RUMOR IT TO THE TPS SENSOR. *JB

NHTSA ID

10168366

Incident

May 1, 2006

Mileage

4,000 mi

MOTORCYCLE HAS BEEN IDLING POORLY AND STALLING WHEN COMING OFF INTERSTATE RIDING. GAS MILEAGE HAS ALSO BEEN DROPPING. ONLY RECENTLY, MOTORCYCLE STALLED IN CENTER LANE OF HIGHWAY AT TRAFFIC SIGNAL AT NIGHT, WOULD NOT RESTART. RECEIVED FAULT CODE 15 CORRESPONDING TO THROTTLE POSITION SENSOR. REPLACED PART. LEARNED OF SEVERAL OTHER 2005 FZ6'S WITH SIMILAR PROBLEM. *NM

NHTSA ID

10161041

Incident

Jun 20, 2006

Mileage

17,648 mi

I WAS RIDING HOME ON MY 2005 YAMAHA FZ6 MOTORCYCLE, WHEN THE ENGINE BEGAN IDLING VERY ROUGH. I HAD TO ROLL ON THE THROTTLE TO KEEP THE ENGINE FROM STALLING. THEN A FEW SECONDS LATER I PULLED IN THE CLUTCH AND THE ENGINE STALLED COMPLETELY. I WAS NOT ABLE TO RESTART THE ENGINE AFTER 4 ATTEMPTS. THEN I TURNED THE IGNITION OFF, AND TURNED IT BACK ON, AND THE ENGINE STARTED AS IF THERE WAS NO PROBLEM. OBVIOUSLY, TURNING THE IGNITION OFF AND BACK ON IS MERELY A BAND AID FOR THIS ISSUE, AND NOT A PERMANENT SOLUTION. PLEASE REFER TO THIS WEBSITE TO LEARN OF OTHER FZ6 OWNERS THAT HAVE EXPERIENCED THIS ISSUE. HTTP://FORUMS.SPORTBIKES.NET/FORUMS/SHOWTHREAD.PHP?T=7320 *JB

NHTSA ID

10158254

Incident

May 24, 2006

Mileage

3,690 mi

I AM AWARE OF SEVERAL DOZEN PEOPLE WHO HAVE HAD THE SAME PROBLEM I AM NOW HAVING WITH FAILURE OF THE THROTTLE POSITION SENSOR (TPS) ON A 2004-2005 YAMAHA FZ6. THIS CAUSES A NEW VEHICLE TO RUN POORLY AND STALL FREQUENTLY UNTIL THE PART IS REPLACED. *JB

NHTSA ID

10157605

Incident

May 15, 2006

Mileage

4,800 mi

METZLER Z4 MOTORCYCLE TIRE (FRONT) INTERNAL BELT BREAKING LOOSE AT 65 MPH IN MORNING RUSH HOUR TRAFFIC. THE TIRE IMMEDIATELY BECAME SO OUT OF ROUND THAT THE MOTORCYCLE COULD NOT BE RIDDEN MORE THAN 5 MPH. *NM

NHTSA ID

10144155

Incident

Sep 15, 2005

Mileage

9,500 mi

ROUGH RUNNING AT SMALL THROTTLE OPENINGS, STALLING. NOT CORRECTED YET. *JB

NHTSA ID

10139422

Incident

Oct 9, 2005

Mileage

7,600 mi

DT: THE CALLER SAID THAT WHILE HE RIDING THE ENGINE ON MOTORCYCLE BROKE OPEN AND ALL THE FLUID SPRAYED OUT. THE CALLER WAS GOING ABOUT 60 MPH. HE ALMOST LOST CONTROL ,BUT WAS ABLE TO STOP AND GET OFF THE MOTORCYCLE. HE HAD TO HAVE IT TOWED. DEALER , WHOSAID THEY WILL LOOK AT IT. THE CALLER CONTACTED THE MANUFACTURER AND LEFT A VOICE MAIL. MOTORCYCLE IS A YAMAHA R-1. *AK

NHTSA ID

10138672

Incident

Oct 2, 2005

Mileage

1,200 mi

THE MOTORCYCLE LOSES IGNITION, AS THOUGH THE "KILL SWITCH" WAS PRESSED. THE RPMS DROP TO ZERO AND THERE IS NO THROTTLE RESPONSE, ALTHOUGH LIGHTS AND GAUGES CONTINUE TO WORK. *JB

NHTSA ID

10137531

Incident

Sep 24, 2005

Mileage

7,500 mi

1) 2005 YAMAHA YZF R1. NORMAL EVERYDAY RIDING FOR 10,000 MILES. AFTER WORK I WARMED UP MY MOTORCYCLE TO 170 DEG F. 2) WHEN I SLOWED DOWN THE RPM'S DROPPED UNDER 1,000 AND THE MOTORCYCLE STALLS/DIES. IT DIED 3 MORE TIMES BEFORE I COULD GET TO A PLACE TO PULL OVER. AFTER I PULLED OVER I GOT OFF MY MOTORCYCLE AND THEN LET IT IDLE. THE IDLE WAS LOW BUT DID NOT DIE. I THEN RIDE MORE AND IT HAPPENED 1 MORE TIME. I HAD TO REV THE ENGINE TO KEEP IT FROM DYING. I STOPPED AND LET THE BIKE SIT FOR OVER 1 HOUR. AFTER I STARTED IT BACK UP EVERYTHING WAS RUNNING PERFECT AGAIN. I RODE ~80 MILES HOME WITH NO PROBLEMS. THE NEXT MORNING I STARTED THE MOTORCYCLE AND LET IT WARM UP TO 170 DEG F AGAIN. I TOOK OFF AND WHEN I WAS SLOWING DOWN THE BIKE JERKED MY FORWARD AND DIED. THE BIKE ALMOST FELL OVER. IT CONTINUED TO DO THEN WHEN I TEST RODE IT AROUND THE BLOCK. I THEN PARKED IT AND DROVE MY CAR TO WORK. I BEGAN DOING RESEARCH ON THE INTERNET AND FOUND THAT OTHER RIDERS ALSO HAD MY PROBLEM. AFTER I GOT HOME I TEST RODE MY BIKE AND EVERYTHING IS WORKING FINE. I ALSO RODE TO WORK TODAY WITH OUT ANY PROBLEMS. THIS IS COMMON WITH A PROBLEM THAT I READ ABOUT THE 2004 YZF R1 ALSO. IT LOOKS LIKE THE MOST COMMON FIX WAS REPLACING THE UPPER AND LOWER TPS SENSOR. I CALLED MY DEALER AND HE TOLD ME IT WAS MY THROTTLE BODY NOT IN SYNC. ALSO FROM WHAT I READ WAS A MISSED DIAGNOSED PROBLEM FROM YAMAHA. 3) I AM GOING TO MY DEALER TOMORROW TO FIX THE "THROTTLE BODY SYNC ISSUE" PLEASE REFER TO THIS WEBSITE AND THE ROUGHLY 100 OTHER RIDERS WITH THE 2004/2005 MODEL YAMAHA R1 HTTP://WWW.R1-FORUM.COM/FORUMS/SHOWTHREAD.PHP?S=&THREADID=98831&PERPAGE=20&PAGENUMBER=1. *JB

NHTSA ID

10136746

Incident

Sep 14, 2005

Mileage

100 mi

1) EXHAUST PIPE TURNS RED AFTER NORMAL USE, GAS TANK VENT LINE IS ABOVE EXHAUST PIPE, BACK FIRES 2) FIRE HAZARD 3) TAKEN TO SHOP AND YAMAHA COULD NOT RECREATE PROBLEM AND I WAS CHARGED FOR DIAGNOSIS - THE PROBLEM STILL EXISTS YAMAHA DOES NOT ACKNOWLEDGE THAT THEIR IS A PROBLEM WITH THIS ATV - THEY COULD NOT RECREATE THE PROBLEM AND THEREFORE ASSUME IT DOES NOT EXIST, THIS ATV HAS DONE THIS SINCE I BROUGHT IT HOME NEW FROM THE DEALER. THE RISK OF FIRE OR EXPLODING IS HIGH SINCE THE EXHAUST PIPE IS VERY NEAR THE FUEL VENT. *NM

NHTSA ID

10132944

Incident

Jul 1, 2005

Mileage

2 mi

DT: OWNER BOUGHT A SCOOTER AND THERE WAS A SUBSTANCE COATING ON THE PANEL, AND THERE WAS A CRACK . THE PANEL WAS LOCATED ON THE RIGHT HAND SIDE OF THE VEHICLE. THE OWNER CONTACTED THE SALES REPRESENTATIVE FROM BARGAIN GEMS, HE SENT A REPLACEMENT PANEL. THEN WHEN ATTEMPTING TO TURN ON THE HEADLIGHT HIGH BEAMS ABOUT A MONTH LATER, THE HEADLIGHTS HA D A BLOWN BULB. THEN, THE OWNER CALLED THE SALES REPRESENTATIVE WHO SENT OWNER A REPLACEMENT HEADLIGHT AND BULBS. THE VEHICLE STARTED LEAKING OIL A MONTH AGO. THE OWNER COULD NOT FIND ANYONE TO WORK ON THE PRODUCT. THE OWNER COULD NOT REPAIR THE OIL LEAK. HE GOT THE LEAK TO SLOW DOWN, BUT NOT STOP. THERE WAS A BREEDER HOSE FOR THE CRANK CASE, THE HOSE WAS PINCHED. THIS CAUSED THE ENGINE NOT TO GET AIR. THEN, WHEN OWNER WENT TO CHECK OIL IT LEAKED OIL. THEN THE HOSE SUCKED PRESSURE IN. CURRENTLY, THE ENGINE STILL LEAKS, AND THE OWNER THOUGHT THE SEAL WAS DAMAGED. THEN, WHILE DRIVING THE OWNER NOTICED THE VEHICLE REVVED UP AND THE SCOOTER STOPPED. THERE WAS A CRACKING NOISE, AND SOMETHING CAME LOOSE. THEN THE OWNER PUSHED AND COASTED DOWN A HILL TO A FRIEND'S DRIVEWAY. THE FRIEND GAVE THE OWNER A RIDE HOME. THE OWNER RETRIEVED THE SCOOTER FROM FRIEND. THE OWNER DID NOT KNOW WHAT CAUSED THE ENGINE TO FAIL. OWNER HAS THE PARTS TO FIX THE ENGINE BUT IT IS GOING TO BE A PROBLEM TO FIX IT. THE GAS GAUGE DIDN'T WORK. THEN THE OWNER CHECKED THE BATTERY. THERE WAS AN IMMENSE AMOUNT OF BATTERY ACID ON THE GROUND WIRE. OWNER TOOK OUT THE BATTERY AND CLEANED IT.*AK

NHTSA ID

10130769

Incident

Mar 1, 2005

DT: LOOSE BOLTS ALL OVER THE MOTORCYCLE NOT FROM THE DEALERSHIP, BUT FROM FACTORY. ALSO, FRONT DISC BRAKE JUNCTION BOX FELL OFF/ CASING MOTOR BOLTS WERE LOOSE, AND TAIL LIGHT WAS ABOUT TO FALL OFF. THIS MOTORCYCLE IS A COUPLE OF MONTHS OLD AND HAS ABOUT 1,000 MILES ON IT. CONSUMER OWNED THREE ROADSTARS, HOWEVER, THIS ONE HAS QUALITY CONTROL PROBLEMS. THE DAY AFTER THE MOTORCYCLE WAS PURCHASED DRIVER HEARD CLANKING NOISES. ROUTING OF CLUTCH CABLE WAS RUBBING AGAINST WINDSHIELD AND CHEWING UP THE CABLE. IN ADDITION, LOWER ROUTING, THE RETAINING CLIPS, WERE PUT ON UPSIDE DOWN AND WERE FALLING OFF. INDICATORS LIGHTS FILLED UP FULL OF WATER IN THE RAIN AND AFTER WASHING. SIDE CASING WERE NOT MOUNTED CORRECTLY. HOWEVER, 2001-2002 MOTORCYCLES WERE FINE, AND THE 2005 MODELS WERE CROOKED AND DID MATCH UP. THE ROAD STAR 1700CC IS THE MODEL.*AK

NHTSA ID

10125688

Incident

Jun 17, 2005

Mileage

100 mi