Recalls, owner-reported complaints, investigations and safety data
Data refreshed
Our database contains 18 NHTSA owner-reported complaints for the 2005 Yamaha XV1700, most frequently naming the fuel system, engine and powertrain (other) categories. 2 safety recalls have been issued covering this model year; and 1 manufacturer communication is on file.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
When owners filed reports about this model year
| Month | Complaints filed | Cumulative |
|---|---|---|
| Nov 2006 | 1 | 1 |
| Mar 2007 | 2 | 3 |
| May 2007 | 3 | 6 |
| Jun 2007 | 1 | 7 |
| Jul 2007 | 1 | 8 |
| Aug 2007 | 1 | 9 |
| Jan 2008 | 1 | 10 |
| May 2009 | 2 | 12 |
| Jun 2009 | 1 | 13 |
| Jul 2010 | 1 | 14 |
| Jun 2011 | 1 | 15 |
| May 2012 | 1 | 16 |
| Jun 2018 | 1 | 17 |
| Jul 2018 | 1 | 18 |
Complaints grouped by the component NHTSA recorded
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
2 campaigns cover this model year
Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.
Check a VIN on NHTSA.govENGINE AND ENGINE COOLING
VEHICLE SPEED CONTROL
Reports submitted to NHTSA, shown in the owner's own words
(11104769) WHILE RIDING ON A CITY STREET AT APPROXIMATELY 25-30 MPH, THE TRANSMISSION LOCKED UP ALONG WITH THE REAR WHEEL. THE BIKE STALLED AND SKIDDED TO A STOP IN THE INSIDE TRAFFIC LANE. I COULD SHIFT INTO NEUTRAL BUT THE REAR TIRE WAS LOCKED UP AND COULD NOT MOVE TO THE SIDE OF THE ROAD. ANOTHER BIKER AND MOTORIST STOPPED, AND WE WERE ABLE TO DRAG THE BIKE OUT OF THE TRAFFIC LANES. I RETURNED LATER AND LOOSENED THE BACK AXLE, SLIPPED THE DRIVE BELT AND ROLLED THE BIKE BACK TO MY HOUSE WHICH WAS APPROXIMATELY A MILE AND A HALF AWAY. AFTER DOING SOME RESEARCH ON THE WEB, I TOOK THE DRIVE PULLEY COVER OFF TO INSPECT THE PULLEY. THERE WAS NO PULLEY RETAINING NUT OR LOCK WASHER. THE PULLEY HAD COME OFF THE SHAFT AND WEDGED ITSELF IN THE HOUSING CAUSING THE REAR WHEEL TO LOCK UP. THE METHOD FOR ATTACHING THE FRONT DRIVE PULLEY ( 22MM NUT AND A WASHER W/ BENDABLE TABS) APPEARS TO BE A FAULTY DESIGN, A SIMPLE SEARCH IN ONLINE FORUMS YIELDS SCORES OF COMPLAINTS WITH STORIES OF IMPROPER TORQUE, WASHER TABS NOT HOLDING, AND THE NUT COMING LOOSE. I HAVE ONLY HAD THIS BIKE SINCE MARCH AND HAVE ONLY PUT ABOUT A THOUSAND MILES ON IT. IT HAD AROUND 10,977 WHEN I BOUGHT IT FROM A DEALER ON EBAY. I WAS JUST ABOUT TO DO THE 12K SERVICE ON THE BIKE WHEN THIS HAPPENED. IN MY OPINION, THIS IS A FLAW THAT CAN VERY WELL CAUSE SEVERE INJURY OR DEATH TO THE RIDER. I THANK GOD I WAS IN CITY TRAFFIC AT LOWER SPEEDS WHEN THIS OCCURRED. IF IT HAD HAPPENED JUST HOURS EARLIER WHEN I WAS DOING 70 MPH ON THE 405, I PROBABLY WOULD NOT BE WRITING THIS. THIS IS NOT A WALK AROUND VISUAL INSPECTION TYPE OF ITEM THAT AN EVERYDAY RIDER WOULD GO THROUGH. THERE ARE SIX (6) 8MM HEX HEAD BOLTS HOLDING THE COVER ON THAT WOULD HAVE TO BE REMOVED IN ORDER TO INSPECT THE INTEGRITY OF PULLEY, NUT, AND WASHER. A SLOTTED NUT WITH A PIN WOULD WORK BETTER THAN THIS SETUP. I'M THANKFUL I WASN'T CARRYING A PASSENGER.
TL* THE CONTACT OWNS A 2005 YAMAHA XV1700. WHILE DRIVING LOW SPEEDS, THE ENGINE SEIZED WITHOUT WARNING. PRIOR TO THE FAILURE, THE CONTACT HEARD AN ABNORMAL NOISE COMING FROM THE ENGINE. AN UNKNOWN LOCAL DEALER WAS CONTACTED AND STATED THAT IT SOUNDED LIKE THE DRY PULLEY NEEDED TO BE REPLACED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 12,001.
TL* THE CONTACT OWNS A 2005 YAMAHA ROADSTAR 1700. THE CONTACT WAS DRIVING APPROXIMATELY 45 TO 50 MPH WHEN HE HEARD A GRINDING NOISE IN THE MOTOR AND THE REAR WHEEL SEIZED. THE CONTACT CONFIRMED THAT A BOLT DETACHED FROM THE DRIVE PULLEY. THE VEHICLE WAS NOT TAKEN TO THE DEALER BUT IT WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED. THE FAILURE AND CURRENT MILEAGE WAS 19,100.
TL* THE CONTACT OWNS A 2005 YAMAHA XV1700. THE CONTACT STATED DURING WARM WEATHER CONDITIONS FUEL WOULD LEAK OUT OF THE CARBURETOR ONTO THE EXHAUST AND THE MOTOR. THE FAILURE OCCURRED MORE FREQUENT AFTER FUEL WAS ADDED TO THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO A DEALER WHO WAS UNABLE TO DUPLICATE THE FAILURE. THE CONTACT WAS CONCERNED SINCE THE FUEL LEAK WAS A MAJOR CONCERN, A FIRE HAZARD, AND THE VEHICLE WAS UNSAFE TO DRIVE. THE FAILURE MILEAGE WAS 4,000.
MY 2005 YAMAHA ROADSTAR WAS LEAKING FUEL FROM THE CARBURETOR WHEN RESTARTING AFTER FUELING UP DURING A LONG ROADTRIP. THE HOT FUEL WAS POURING OUT OF THE CARB AND ONTO MY HOT MUFFLERS. AFRAID THE BIKE WOULD CATCH ON FIRE, I HAD TO WAIT FOR IT TO COOL DOWN TO RESTART WHICH IT DID. I TOOK THE BIKE TO HONDA/YAMAHA OF SAVANNAH WHERE THEY CLEANED THE CARB, REPLACED THE FUEL FILTER AND CLEANED OUT THE WHOLE GAS TANK. THE TECH STATED THERE MIGHT HAVE BEEN DEBRIS IN THE FUEL SYSTEM LEAVING THE NEEDLE VALVE IN THE CARB UNSEATED AND ALLOWING FUEL TO PASS THROUGH AND LEAK OUT. THE TECH TOOK IT FOR A 5 MINUTE TEST RIDE AND THERE WAS NO LEAK AFTER RESTARTING. I DROVE ABOUT 200 HIGHWAY MILES AND REFUELED. WHEN I TRIED TO START THE BIKE, FUEL AGAIN POURED OUT OF THE CARB AND ONTO MY HOT EXHAUST. I LET THE BIKE COOL AND HAD A MECHANIC AT THE STATION LOOK AT THE FUEL FILTER AND CARB NO DEBRIS. I HELPED HIM PULL THE TANK AND WE CHECKED FOR DEBRIS. THERE WAS NO TRASH IN THE FUEL. THE PROBLEM CONTINUES ONLY DURING RESTARTING A HOT ENGINE. I'M CONCERNED ABOUT MY SAFETY AND WOULD LIKE YAMAHA TO LOOK INTO THIS AS THIS IS A COMMONLY REPORTED PROBLEM. *TR
AFTER DRIVING VEHICLE AND MOTOR IS HOT, STOPPING FOR APPROX 15 MIN, THEN WHEN TRYING TO RESTART THE CARB SPRAYS GAS OUT ALL OVER THE BASE OF HOT ENGINE AND EXHAUST PIPE. DOES IT EVERY TIME AFTER TRYING TO RESTART THE HOT(NOT OVERLY HOT, JUST HOT WEATHER) ENGINE. GAS IS BOILED AND VAPORIZED IMMEDIATELY. SEEMS TO BE AN OVERALL DESIGN PROBLEM. *TR
FUEL (GASOLINE) IS SPRAYED FROM REAR PORT OF CARBURETOR. AS MUCH AS 2 OZ. MAY BE EMITTED AND SPRAYED ON HOT EXHAUST PIPES AND ENGINE. THE FUEL IS IMMEDIATELY VAPORIZED. THIS ONLY SEEMS TO OCCUR WHEN THE ENGINE IS HOT, THEN SHUT OFF AND ALLOWED TO SIT FOR APPROXIMATELY 15 MINUTES. IT DOES NOT SPRAY LIQUID GAS IF IMMEDIATELY STARTED OR IF ALLOWED TO COOL. MOTORCYCLE MAY CATCH FIRE IF THE OPERATOR TRIES TO START THE ENGINE AND IT HAPPENS TO COUGH OR BACKFIRE THROUGH THE INTAKE AT THE SAME INSTANT. PROBLEM IS FREQUENT. *TR
IN APRIL OF 2008 I INSTALLED A METZELER 880 MARATHON MOTORCYCLE TIRE ON MY BIKE. THE TIRE WAS PURCHASED FROM RONAYERS, WHICH IS AN ONLINE MOTORCYCLE PARTS STORE. IMMEDIATELY AFTER INSTALLING THE TIRE I WENT FOR A RIDE AND NOTICED A CONSTANT SHAKING OF THE HANDLEBARS....ITS AS IF I'M RIDING ON A VERY VERY WINDY DAY. THE BIKE WILL NOT TRACK STRAIGHT DOWN THE ROAD. THIS ONLY HAPPENS AT HIGHWAY SPEEDS OF 50 MPH OR HIGHER. I IMMEDIATELY CONTACTED THE DISTRIBUTOR RONAYERS WHO TOLD ME TO CONTACT METZELER WHICH IS A DIVISION OF PIRELLI TIRES. THE MANUFACTURER TOLD ME TO TAKE IT TO A DEALER AND LET THEM CHECK IT BY RIDING AND SEE WHAT THEY TELL ABOUT THE TIRE. BELLS SUZUKI IN LEXINGTON WAS NICE ENOUGH TO RIDE THE MOTORCYCLE AT NO CHARGE....THEY ALSO CHECKED THE BALANCING, ALL OF WHICH WERE IN SPECS. THE TECH SAID THAT HE COULD INDEED FEEL WHAT I WAS TALKING ABOUT AND I SHOULD AGAIN GET IN TOUCH WITH THE MANUFACTURER. WELL IT IS SPRING HERE IN KENTUCKY AND AFTER RIDING THE BIKE YESTERDAY AND FEELING HOW THIS BIKE HANDLES I HAVE BEEN INCLINED TO FILE THIS COMPLAINT. METZELER IS SUPPOSED TO BE THE BEST TIRE AVAILABLE FOR MOTORCYCLES, BUT THE BALD TIRE I TOOK OFF WAS BETTER THAN THIS TIRE. THE TIRE HAS LESS THAN 1000 MILES ON IT AND IS UNSAFE. I HAVE A METZELER 880 MARATHON TIRE ON THE REAR OF MY BIKE AND IT IS FINE BUT THE FRONT TIRE IS DEFINITELY BAD. I WANTED TO HAVE MY CASE DOCUMENTED BEFORE SOMETHING HAPPENS TO ME ON THIS MOTORCYCLE. *TR
A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.
ENGINE AND ENGINE COOLING:ENGINE
ACCESSORY BIG BAR ENGINE GUARD WASHER PLACEMENT - ALL XV1700 (ROAD STAR) MODELS. *PE
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.
Complaint and recall counts across every year of this model
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.