RoadVitals

2005 Yamaha YP400 Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Data refreshed

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
2
Newest Apr 23, 2008
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
1 investigation on file

Recall campaigns

2 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

08V180000

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Apr 23, 2008
9,600 units potentially affected
The defect: YAMAHA IS RECALLING 9,600 MY 2006-2007 CP250 AND MY 2005-2007 YP400 MOTORCYCLES. THE ENGINE COULD STALL AND BE DIFFICULT TO RESTART BECAUSE THE WIRE TERMINALS IN THE FUEL PUMP WIRE COUPLER HAVE CORRODED. WATER CAN ENTER FROM THE MAIN WIRE HARNESS END AND RUN THROUGH THE HARNESS TO THE FUEL PUMP COUPLER.
The risk: IF THE WATER REMAINS IN THE COUPLER FOR AN EXTENDED PERIOD OF TIME, THE TERMINALS CAN BECOME CORRODED, WHICH CAN PREVENT THE FUEL PUMP FROM OPERATING PROPERLY. IF THIS CORROSION AFFECTS FUEL PUMP OPERATION WHILE THE SCOOTER IS BEING RIDDEN, THERE COULD BE A CRASH RESULTING IN INJURY OR DEATH.
The remedy: DEALERS WILL INSTALL A SUB-HARNESS WHICH IS DESIGNED TO ALLOW ANY WATER BETWEEN THE WIRE HARNESS AND THE FUEL PUMP TO DRAIN OUT BEFORE IT REACHES THE FUEL PUMP. THE DEALER WILL ALSO INSPECT THE CONNECTORS. IF EITHER THE MAIN WIRE HARNESS CONNECTOR OR THE FUEL PUMP CONNECTORS IS ALREADY CORRODED, THE CORRESPONDING ASSEMBLY(IES) WILL ALSO BE REPLACED. THE RECALL BEGAN ON MAY 9, 2008. OWNERS MAY CONTACT YAMAHA AT 1-800-962-7926.
YAMAHA MOTOR CORPORATION, USAManufacturer number M2008-002RView on NHTSA.gov
07V219000

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

May 24, 2007
13,958 units potentially affected
The defect: ON CERTAIN MOTORCYCLES, A LEAK AT THE FUEL PUMP SEAL MAY ALLOW FUEL LEAKAGE.
The risk: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
The remedy: DEALERS WILL REPLACE THE FUEL PUMP SEAL FREE OF CHARGE. THE RECALL BEGAN ON JUNE 18, 2007. OWNERS MAY CONTACT YAMAHA AT 1-800-962-7926.
YAMAHA MOTOR CORPORATION, USAManufacturer number M2007-011RView on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect, and it is not a recall.

PE08018ClosedPreliminary Evaluation

MOTORSCOOTER STALLING

Opened Mar 18, 2008
Closed May 13, 2008

ODI OPENED THIS PE BASED ON OWNER AND EWR FIELD REPORTS ALLEGING THE SUBJECT SCOOTERS WOULD STALL WHILE UNDERWAY.AFTER OPENING THIS INVESTIGATION, YAMAHA DECIDED TO CONDUCT A CORRECTIVE SAFETY RECALL (08V-180) IN LIEU OF RESPONDING AN ODI INFORMATION REQUEST.WITH THAT RECALL, THIS PE IS CLOSED.

ELECTRICAL SYSTEMLed to recall 08V180000

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .