2015 Acura ILX

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Check airbag system light keeps coming on and worried airbag may rupture or explode

NHTSA ID

11686105

Incident

Jul 25, 2025

Check air bag system keeps turning on..

NHTSA ID

11654549

Incident

Apr 14, 2025

The contact owns a 2015 Acura ILX. The contact stated while driving at an undisclosed speed, the brake pedal was depressed, with the ABS warning light illuminated. The vehicle was restarted; however, the failure recurred. The vehicle was taken to an independent mechanic where it was diagnosed that the electronic braking control module had failed and needed to be replaced. The vehicle was not repaired. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 50,000.

NHTSA ID

11609370

Incident

Aug 19, 2024

Mileage

50,000 mi

The contact owns a 2015 Acura ILX. The contact stated while driving 30-40 MPH, the vehicle started pulling to the right. The contact was able to steer the vehicle and continued driving. Additionally, the contact stated that while driving at various speeds, the steering wheel abruptly jerked and violently turned to the left, causing the vehicle to pull to the left. The contact stated that he was unable to turn the steering wheel to the right. The contact stated that he depressed the brake pedal and came to a complete stop. The contact was then able to pull to the side of the road. The contact stated that the failure recurred several times while driving. The vehicle was taken to the dealer, where it was diagnosed that the steering column needed to be replaced. The vehicle was not repaired. The contact related the failure to an unknown recall. The manufacturer was not notified of the failure. The failure mileage was approximately 139,000.

NHTSA ID

11544573

Incident

Jul 14, 2023

Mileage

139,000 mi

Takata front passenger side ceiling airbag and front passenger seat airbag deployed without impact or collision after I left my garage and drove less than a quarter of a mile. There was an excessive heat warning and higher-than-average humidity. I suffered auditory injuries due to the high-decibel explosion the Takata airbags produced in the sealed cab of my car. My insurance has ruled my vehicle a total loss (with no fault of my own). Still, I have yet to accept the insurance's total loss offer, and I wanted to provide an opportunity for further inspection of the Takata airbag system to help this ongoing crisis further. Two Acura representatives called after I registered my airbag deployment on Honda's website. The first representative treated me, "I can have you arrested." during our phone conversation on July 12th, 2023. The second representative requested that I turn over my vehicle to Acura "So we can do our internal investigation." I declined, and his rebuttal was to take my car from the bank since there was a lien on it. I replied that my vehicle has no lien; it's paid in full. My insurance company initially told me they were going to inspect the vehicle. However, I was offered a total loss settlement within 48 hours. I've requested an inspection report multiple times for the cause, but my insurance company has not provided me with anything other than a total loss, with "no fault of my own report." There were no warning lamps, messages, or anything to alert me before the faulty deployment of the airbags. No passenger was seated in the passenger seat at the time of this incident.

NHTSA ID

11536683

Incident

Jul 10, 2023

TL* THE CONTACT OWNS A 2015 ACURA ILX. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED INTERMITTENT PUSH TO START FAILURES WITH SEVERAL UNKNOWN WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT STATED THAT SEVERAL ATTEMPTS WERE NEEDED TO START THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 45,000.

NHTSA ID

11395299

Incident

Nov 1, 2020

Mileage

45,000 mi

LAST COUPLE MONTHS PASSENGER SIDE DOOR LOCKS AND UNLOCKS ON ITS OWN WHENEVER CAR STARTS. YESTERDAY DRIVER SIDE DOOR FLEW OPEN AS I WAS DRIVING DOWN THE ROAD. TOOK CAR TO SHOP AND THEY ARE REPLACING DOOR LOCK AT THIS TIME.

NHTSA ID

11282464

Incident

Nov 25, 2019

Mileage

130 mi

RECALL ON AIRBAGS 3/14/2019 AND I PURCHASED CAR USED 4/17/2019 NOT KNOWING ABOUT THE RECALL. FUEL PUMP FAILURE CAUSING CAR NOT TO START. MECHANIC FOUND IT BURNED

NHTSA ID

11229573

Incident

Jul 2, 2019

Mileage

72,898 mi

Service Bulletin - Warranty Extension: Customer Support Program For Driver's Airbag Inflator for 2013-14 ILX Hybrid and Other Listed Years and Models.

Service Bulletin - This bulletin is a notification of a class action settlement relating to airbag inflators. American Honda is offering a Customer Support Program (Warranty Extension) to cover any manufacturing defects in the replacement driver's airbag inflator only.

Service Bulletin - This bulletin is a notification of a class action settlement relating to airbag inflators. American Honda is offering a Customer Support Program (Warranty Extension) to cover any manufacturing defects in the replacement driver's airbag inflator only.

ServiceNews Article - When removing and installing a cable reel, you need to keep both the cable reel and the steering angle sensor in position. If you don't, the VSA indicator may come on along with one or more VSA DTCs. And when you run the Neutral Memorization Procedure in the i-HDS, it won't complete.

Service bulletin - This bulletin is a notification of a class action settlement relating to airbag inflators. American Honda is offering a Customer Support Program (Warranty Extension) to cover any manufacturing defects in the replacement front passengers airbag inflator only.

Service bulletin - This bulletin is a notification of a class action settlement relating to airbag inflators. American Honda is offering a Customer Support Program (Warranty Extension) to cover any manufacturing defects in the replacement driver's airbag inflator only.