Owner-reported complaints naming the fuel system system, filed with NHTSA
Data refreshed
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks. Every record below is an owner-reported complaint about the 2017 Alfa Romeo Giulia submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 48 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
The 25 most recent of 48, in the owner's own words
The contact owns a 2017 Alfa Romeo Giulia. The contact received notification of NHTSA Campaign Number: 25V586000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
The contact owns a 2017 Alfa Romeo Giulia . The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline). The dealer was contacted, and the contact was informed that parts to do the recall repair were unavailable. Additionally, the contact was informed that a limit of ten parts could be ordered at a time as per the manufacturer. The manufacturer was contacted. The contact had not experienced a failure.
My car keeps going into limp mode seasonally, it also emits bad odors when given throttle, and it is definitely lacking power. Situation has also caused a misfire on my 3rd cylinder and a super rough idle and start
The contact owns a 2017 Alfa Romeo Giulia. The contact stated that while driving at an undisclosed speed, the vehicle shut off suddenly. There was no warning light illuminated. The contact stated that on a separate occasion, the vehicle shut off while coming to a complete stop. The contact waited for 30 minutes before restarting the vehicle. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The vehicle was taken to a local dealer and was diagnosed with fuel pump failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was approximately 64,000.
CRITICAL FINANCIAL NON-COMPLIANCE REPORT regarding NHTSA Campaign 25V586 / Alfa Romeo Recall 93C. On July 16, 2026, my vehicle suffered a catastrophic loss of motive power and stalled on the highway due to the exact fuel pump module defect described in Campaign 25V586 (Bristow's Auto Repair Invoice #33733 confirmed code P008A and low fuel pressure at 349mBar). Because the vehicle was entirely inoperable, I paid $2,207.27 out of pocket for an emergency repair. Alfa Romeo Customer Care has twice formally refused in writing to process my pre-recall reimbursement claim, explicitly stating they will not pay until a factory remedy is commercially available. This is a direct violation of the mandatory claim-processing guidelines under federal regulation 49 CFR § 573.13. Manufacturer is unlawfully withholding federally mandated consumer reimbursement.
Hot weather, longish drive, car lost power and started throwing codes. I have a code reader (because this has happened before) and the code reader blamed the problem on fuel delivery system. You issued a recall on this last year (25V-586) but there is not yet a remedy from the company. This car, and many like it may be dangerous to drive and may strand drivers -- as it would have done to me in the past had I need had the code reader and the means to re-set the computer once ambient temperature were lower. You may want to issue a reminder to them that this needs fixing and ASAP. Thanks.
The contact owns a 2017 Alfa Romeo Giulia. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that while driving at various speeds, the vehicle unintendedly went into LIMP Mode, and the vehicle lost automotive power. Several unknown warning lights were illuminated. In addition, the contact stated that while attempting to start the vehicle with the Push-to-Start feature, the engine hesitated while turning over. The vehicle was taken to a local dealer, where it was diagnosed; however, the cause of the failure was not yet determined. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 65,000.
My vehicle is affected by Recall 93C / (NHTSA 25V-586 )for a fuel pump defect that can cause the engine to stall while driving. This safety issue has already occurred — my vehicle stalled while in motion, creating a dangerous situation. The car is currently unsafe to drive. Description of the Incident: I scheduled a recall appointment with the Englewood Cliffs Alfa Romeo dealer after reporting that the car had stalled. When I arrived, the dealer attempted to charge me a $450 diagnostic fee even though the visit was specifically for a federally regulated safety recall. I declined the fee and left because I did not feel comfortable being charged for recall‑related inspection. Manufacturer Response: I contacted Stellantis Customer Care. They stated that they “have no control over how the dealer operates” and that they would require diagnostic documentation from the dealer before providing rental assistance. This means I would still be required to pay the diagnostic fee, even though the issue is recall‑related. Reason for Filing: The dealer’s refusal to perform recall‑related inspection without charging a diagnostic fee prevents me from addressing a known safety defect. The manufacturer’s position leaves me unable to obtain recall service unless I pay out of pocket. I am concerned that this creates a barrier for consumers attempting to address a serious safety recall. Requested Action: I am requesting NHTSA’s review of this dealer’s handling of Recall 93C and Stellantis’ response requiring paid diagnostics before providing recall support. I would like NHTSA to ensure that consumers can obtain recall inspections and remedies without being charged diagnostic fees.
See attached document for complaint.
Manufacturer Recall Number93C has been almost a year and the remedy still not yet available!!
The contact owns a 2017 Alfa Romeo. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
The vehicle is experiencing multiple system malfunctions involving the engine performance, fuel system, and electronic throttle control, including engine shaking while idling, activation of the check engine light, a “start/stop unavailable” message, limp mode (inability to switch between driving modes), and illumination of the electronic throttle control warning light. One dealership suggested the issue may be related to an open fuel pump recall after noting that previously replaced spark plugs were heavily carbon-fouled, indicating excessive fuel combustion; however, another dealership diagnosed the engine as “scored” and recommended major repair. This diagnosis is disputed, as an independent mechanic performed a borescope inspection and reported no visible internal engine damage. The issue is intermittent—some days the vehicle operates normally, while other days it becomes undrivable. This creates a safety risk, as the vehicle may unexpectedly enter limp mode, limiting acceleration and drivability in situations such as merging or navigating traffic. I have not been involved in any accidents related to this issue and avoid driving the vehicle when symptoms are present. The vehicle has been inspected by both a dealership and an independent mechanic, but not by police or insurance representatives. Warning lights and symptoms, including the check engine light, electronic throttle control light, and start/stop warning, began appearing prior to the drivability failure and around the same time I received notice of the fuel pump recall. The vehicle is available for inspection upon request.
Vehicle completely lost power and quite running in the middle of the desert in Arizona. This relates to Saftey Recall 93c. I had to have the car towed and repaired in Scottsdale, AZ. I have been told that this repair (which was expensive) might not remedy the problem and it could reoccur. It's been over six months since the recall was issued and yet no remedy is available and I have not received reimbursement for the repairs I had to have done to get my vehicle running. I think six months is enough time given that I cannot trust the reliability of my vehicle due to this serious problem. When a vehicle just "turns off" in the middle of the freeway it poses a huge safety risk both to the occupants and to other drivers in the area. So my complaint is that it's taking far too long for Stellates to produce parts to remedy this problem.
I was driving on the highway and my car starts sputtering, I figured I pull over and turn my car off and on. My car seemed fine and I continued to drive home from work. As soon as I got off the highway my car completely shut off mid ride, stalls out and my steering wheel locked up. I was able to get my car turned back on and get back home. Filled with anxiety at least. Luckily I have a code reader in my car as soon as I pulled into my driveway and the codes showing where P008A which is directly related to a fuel pump/ fuel delivery issue. This happened on February 28th. I have been scared to drive the car since
The contact owns a 2017 Alfa Romeo Giulia. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while attempting to start the vehicle, the vehicle started shaking and the starter was making a ticking sound. The vehicle failed to start. The warning lights for alternator failure and the electronic throttle body control were illuminated. The vehicle was towed to the dealer to be diagnosed. The vehicle was diagnosed with fuel pump failure. The contact was informed that the fuel pump needed to be replaced. The vehicle was scheduled to be repaired. The manufacturer was made aware of the issue. The failure mileage was unknown.
the vehicle has read off warnings seconds from simply stopping and cutting off in traffic. this has happened at least two times now. it may say full throttle service and flash lights before simply slowing down and the check engine light flashing while on the highway unable to speed up no matter how far down on the gas pedal I push. has been taken to dealer several times. problems started soon after purchasing vehicle. On 3/1/2026 while leaving church service, my family and I were on a major highway with the speed limit at 65 mph. The vehicle just slowed down without giving any power and could not get it up to the speed to continue with traffic. This vehicle could put me and my family at risk for a possible dangerous situation.
Odometer Fraud. The contact owns a 2017 Alfa Romeo Giulia. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact also received notification NHTSA Campaign Number: 24V510000 (Air Bags, Seat Belts), and the recall remedy was available; however, the dealer was charging to complete the recall repair. The dealer had been in possession of the vehicle for approximately a month. Upon picking up the vehicle, it was discovered that there was a mileage discrepancy. The mileage at the time of the dealer drop off was 91,595. The mileage at pickup was 60,000. The manufacturer was made aware of the issue but did not offer further assistance.
DEFECTS INVESTIGATION SUBJECT FRAUDULENT CONCEALMENT OF RECALL 93C AND RECALL 24V518 VIN 4691 NATURE OF COMPLAINT THE DEALERSHIP HAS ENGAGED IN CALCULATED FRAUD AND RECALL INTERFERENCE TO SUPPRESS MY LEGAL RIGHT TO A BUYBACK FOR A DEFECTIVE VEHICLE DETAILS MY VEHICLE HAS BEEN WITHHELD SINCE NOVEMBER 18 2025 FOR 31 CONSECUTIVE DAYS DURING WHICH THE DEALERSHIP HAS IGNORED ALL COMMUNICATION THE VEHICLE WAS PRESENTED FOR ENGINE STALLING AND TOTAL LOSS OF POWER WHICH ARE THE PRIMARY SYMPTOMS OF THE 93C FUEL DELIVERY MODULE RECALL INTAKE DIAGNOSTICS ORIGINALLY CONFIRMED A FUEL PUMP FAILURE RELEVANT TO THIS RECALL HOWEVER IMMEDIATELY AFTER I SERVED THE DEALERSHIP WITH A SETTLEMENT AGREEMENT AND FORMAL INTENT TO SUE THE DEALERSHIP EXPIRED THE ORIGINAL DIAGNOSTIC REPORT AND ISSUED A NEW FRAUDULENT REPORT CLAIMING THE FAILURE IS SUDDENLY UNRELATED TO THE RECALL THIS IS AN OVERT ATTEMPT TO CONCEAL ILLEGAL ACTIVITY AND EVADE MANDATORY BUYBACK REQUIREMENTS DOCUMENTATION PROVES THIS CAR EXCEEDED THE 30 DAY SHOP TIME THRESHOLD WHILE STILL UNDER WARRANTY WHICH MANDATES A BUYBACK UNDER CONSUMER PROTECTION STATUTES THE DEALERSHIP IS IN UNAUTHORIZED POSSESSION OF MY PROPERTY WHILE FAILING TO PERFORM THE RECALL 24V518 SEATBELT SENSOR REPAIR WHICH PREVENTS FRONT AIRBAGS FROM DEPLOYING IN A CRASH I AM ALSO REPORTING ODOMETER FRAUD AS THE NEW ALTERED RECORDS SHOW MILEAGE DISCREPANCIES INTENDED TO MISREPRESENT THE VEHICLES HISTORY I REQUEST A FEDERAL AUDIT OF THE DEALER SERVICE LOGS TO PROVE THE MANIPULATION OF DATA POST LEGAL NOTICE THIS MANUFACTURER HAS A DOCUMENTED HISTORY OF HIDING FUEL PUMP FAILURES AND THIS CONDUCT IS A CONTINUATION OF SYSTEMIC BAD FAITH THAT ENDANGERS PUBLIC SAFETY I REQUEST AN IMMEDIATE INVESTIGATION INTO THESE FRAUDULENT ACTS AND THEFT BY DECEPTION
The contact owns a 2017 Alfa Romeo Giulia. The contact stated that while driving at an undisclosed speed, the vehicle unexpectedly sputtered and then lost motive power, with the check engine warning light illuminated. The vehicle was able to be restarted. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The vehicle was taken to the dealer, but was not diagnosed or repaired. The dealer informed the contact that the failure could not be duplicated and confirmed that parts were not yet available for the recall repair. The manufacturer was made aware of the failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The approximate failure mileage was 173,000.
I am filing a complaint in regard to recall 93c for my 2017 Alfa Romeo. The dealership/manufacturer has failed to provide me with a fix, parts or even just a loaner car due to the safety hazard. My car has gone limp mode several times on the highway at speeds of 70mph. This is unacceptable.
While driving my Alfa Romeo, the vehicle experienced a significant malfunction involving the engine and power-train system. The vehicle will not accelerate properly and repeatedly goes into limp mode, resulting in a sudden and severe loss of power, especially while driving on the highway. The engine warning light is illuminated, and the vehicle hesitates, jerks, and fails to respond. This malfunction created a direct safety risk to me and other drivers on the road. The loss of acceleration occurred while traveling at highway speeds, making it difficult to merge, maintain traffic flow, or avoid surrounding vehicles. The problem has been reproduced multiple times, and the vehicle consistently enters limp mode when attempting to accelerate. The issue has been observed during normal driving conditions and does not appear to be a one-time event. The vehicle and its components are available for inspection by the manufacturer, dealer, insurance representative, or any required agency. At this time, the vehicle has not yet been formally inspected by the manufacturer, police, or insurance company, but I am prepared to provide access for evaluation. No warning lights and symptoms prior to the complete failure.
My 2017 Alfa Romeo Giulia, VIN [XXX] , is currently disabled and inoperable at the authorized dealer, Alfa Romeo Fiat of Daytona (Service Advisor: Kevin Chapman). The vehicle is subject to the active and known Safety Recall 93C (Low-Pressure Fuel Pump). My vehicle is experiencing a total loss of motive power and engine stall, which is the exact safety hazard described in the recall. Furthermore, the initial failure of the low-pressure fuel system appears to have caused secondary consequential damage to the expensive High-Pressure Fuel Pump (HPFP), and the vehicle is also exhibiting a severe and recurring electrical defect (new battery dying, random dash warnings/brake lights flashing). The manufacturer, FCA/Stellantis (Customer Care Case #XXX...), and the dealer are engaging in a runaround to deny basic safety recall provisions: 1. Refusal to Cover Consequential Damage: FCA Customer Care stated that if the issue is 'not the 93C recall then it will all be customer pay,' which conflicts with NHTSA guidelines requiring the manufacturer to remedy the primary defect and all damage proximately caused by it. 2. Refusal to Provide Loaner/Rental Car: FCA stated the loaner is up to the dealer, and the dealer stated it is up to the diagnostic. This runaround has created an unreasonable delay in the repair of a federally mandated safety recall, leaving the owner without transportation for a disabled, unsafe vehicle. I am requesting NHTSA intervention to compel FCA/Stellantis to: a) Authorize a complimentary rental car/loaner until the vehicle is fully repaired. b) Provide a formal commitment that all damage proven to be a direct, proximate consequence of the 93C fuel pump failure will be covered at no cost. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
What component or system failed or malfunctioned, and is it available for inspection upon request? - THE MANUFACTER HAS ACKNOWLEDGED THAT THE FUEL PUMP IS FLAWED. THERE IS NO RESOLUTION PROVIDED AT THIS TIME FOR INSPECTION OR REPAIRS TO BE PERFORMED. How was your safety or the safety of others put at risk? - I AM DEEPLY CONCERN ABOUT THE POTENTIAL RISKS ASSOCIATED WITH THIS DEFECT. A SUDDEN LOSS OF POWER WHILE DRIVING COULD LEAD TO A DANGEROUS SITUATION ON THE ROAD. Has the problem been reproduced or confirmed by a dealer or independent service center? -YES, THE DEALERSHIP IS AWARE OF THIS ISSUE. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? -VEHICLE HAS NOT BEEN FURTHER INSPECTED AS THERE IS NO RESOLUTION TO THIS MATTER AT THIS TIME. FOR THAT REASON, I AM VERY HESITANT TO OPERATE THE VEHICLE UNTIL THIS ISSUE IS PROPERTLY RESOLVED. IS SIGNIFICANT SAFETLY CONCERN FOR ME, MY PASSANGERS AND OTHERS IN THE ROAD AS WELL. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? - NO DIRECT WARNING OR MESSAGE HOWEVER, ELECTRICAL ISSUES HAVE BEEN AN ONGOING PROBLEM BUT NO MAIN SOURCE HAVE EVER BEEN FOUND, EVEN AFTER MULTIPLES APPOINMENTS AND REPAIRS AT THE SHOP. MORE RECENTLY, THE ELECTRICAL ISSUES ARE BECOMING FRECUENT AND I'M AFFRAID ALL IS RELATED TO THIS PUMP ISSUE.
Car stall after driving a long drive specifically when it’s hot weather . Multiple occasions for the past 5 years Will never run again for about 10-15 minutes. When it come back on with a check engine. Code reads low fuel pressure.
Fuel pump and module failed and car stalled while on highway almost causing an accident.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .