RoadVitals

2016 Aprilia Caponord Rally

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
1
Latest Oct 23, 2017
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
1
Latest Sep 26, 2016
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

Overview

Our database contains 1 NHTSA owner-reported complaint for the 2016 Aprilia Caponord Rally, most frequently naming the electrical category. 1 safety recall has been issued covering this model year.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

  • Electrical1100.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

1 campaign cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
16V691000

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER

Sep 26, 2016
1,628 units potentially affected
The defect: Piaggio Group Americas, Inc. (Piaggio) is recalling certain model year 2014-2015 Aprilia Tuono V4 1000, 2016 Tuono V4 1100, 2015 Caponord 1200 ABS/ADD, and 2016 Caponord Rally motorcycles manufactured June 18, 2013, to June 13, 2016. The affected motorcycles have a front brake master cylinder that may allow air into the hydraulic circuit, causing a longer than expected braking distance.
The risk: If an abnormal distance is required to stop the motorcycle, there is an increased risk of a crash.
The remedy: Aprilia will notify owners, and dealers will replace the front brake master cylinder pushrod and boot assembly, free of charge. The recall began October 04, 2016. Owners may contact Aprilia customer service at 1-866-705-1727.
Piaggio Group Americas. Inc.View on NHTSA.gov

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

Electrical
Filed Oct 23, 2017

THE BIKE WAS ON THE HIGHWAY IN 4TH GEAR TRAVELING AT ABOUT 60MPH AND THE ENGINE CUT OUT. THERE WERE NO WARNING LIGHTS THAT APPEARED ON THE DASH OR ANY OTHER APPARENT INDICATION OF A FAULT ON THE BIKE. I WAS ABLE TO COAST TO THE SIDE OF THE ROAD BUT THE ENGINE WOULD NOT RESTART. I THEN EXERCISED ALL OF THE SWITCHES: THE TURN SIGNAL, THE HIGH BEAM, THE SIDE STAND, THE CLUTCH, BOTH BREAK PEDALS, THE LED LIGHT SWITCH, THE CRUISE CONTROL, AND THE HEATED GRIPS BUT THE BIKE WOULD STILL NOT RESTART. I TURNED THE IGNITION OFF FOR 2-3 MINUTES AND WAS ABLE TO TURN IT BACK ON AND GET THE BIKE RESTARTED. I DROVE FOR ANOTHER MILE AND THE SAME ISSUE HAPPENED AGAIN BUT I WAS NOT ABLE TO GET THE BIKE RESTARTED. I CHECKED THE CONNECTIONS THAT I HAD ACCESS TO: FUSES, HAND CONTROLS, TIP OVER SENSOR AND THEY ALL SEEMED TO BE FULLY SEATED. AFTER ABOUT 15 MINUTES, THE BIKE STARTED AGAIN WITH NO REASONABLE INFORMATION AS TO WHAT COULD HAVE BEEN THE REASON.

NHTSA ID
11035920
Incident
Oct 20, 2017
Mileage
2,000 mi