2016 Audi A3 Fuel system Problems

The automobile refuses to accept fuel from the gas pump. It quickly stops accepting gasoline and spills over the top of the gas cap area even though the gas gauge indicates fuel is required. I understand this is under warranty for front wheel drive variations of the A3 but my Cabriolet happens to be an All-Wheel Drive Quattro model. The Dealer I called claimed my exact VIN isn't on the recall list, even though the tank configuration suffers identical symptoms as the front wheel drive model. This is a common problem and should be covered since it is a danger having gasoline spill out of the vehicle when fueling. There are no warning lights yet I cannot fuel my car properly.

NHTSA ID

11776891

Incident

Oct 15, 2026

Electrical problems and fuel leak

NHTSA ID

11730283

Incident

Apr 9, 2026

FUEL LEAKED ALL MY GARAGE ALMOST CAUSING A FIRE IN MY HOME WHILE I WAS SLEEPING. I HAVE HAD THE FUEL TANK REPLACED 3 TIMES. AND I HAD TO PAY OUT OF POCKET TO HAVE IT REPLACED BECAUSE AUDI WOULD NOT REPLACE THE RECALL OF IT SO I AM REACHING OUT TO YOU SO YOU CAN REACH OUT TO AUDI ABOUT NOT STANDING BY THE RECALL PROCEDURE!

NHTSA ID

11690869

Incident

Sep 24, 2025

Mechatronics unit failed, stalled on freeway nearly caused an accident behind me.

NHTSA ID

11653834

Incident

Apr 10, 2025

The contact owns a 2016 Audi A3. The contact stated that while the vehicle was parked, there was a strong fuel odor coming from the vehicle, and the vehicle hesitated while starting. Additionally, the contact stated that the failure persisted before starting. The vehicle was driven to an independent mechanic where it was diagnosed that there was an engine misfire and a leak in the fuel pump. The vehicle was not repaired. The VIN was not included in NHTSA Campaign Number: 16V647000 (FUEL SYSTEM, GASOLINE, ENGINE AND ENGINE COOLING). The manufacturer was not notified of the failure. The approximate failure mileage was 92,000.

NHTSA ID

11622918

Incident

Sep 23, 2024

Mileage

92,000 mi

The contact owns a 2016 Audi A3. The contact stated that while refueling the vehicle, fuel started leaking from the vehicle. The contact stated that the vehicle was sputtering while being started. The failure occurred intermittently. There were no warning lights illuminated. The contact removed the EVAP hose and became aware that the hose was filled with gasoline. The contact became aware of NHTSA Campaign Number: 24V110000 (Fuel System, Gasoline); however, the VIN was not included. The dealer was contacted and made aware of the failure. The dealer confirmed that there were no recalls on the VIN. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was 95,000.

NHTSA ID

11617242

Incident

Sep 16, 2024

Mileage

95,000 mi

The contact owns a 2016 Audi A3. The contact stated while driving at an undisclosed speed, the vehicle stalled with the check engine and low oil warning lights illuminated. The contact also became aware that there was fuel leaking from the charcoal canister. The vehicle was restarted; however, the failure recurred. The vehicle was taken to the dealer and was diagnosed and determined that the evaporative emissions and charcoal canister needed to be replaced. The contact was informed that the fuel tank needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was unavailable.

NHTSA ID

11607390

Incident

Aug 8, 2024

Audi continues to tell me that this recall has been completed yet Audi’s website clearly states of the recall has not been completed your website. States of the recalls not completed and car fractures that recalls not been completed. Yet they refuse to complete the recall in my car.

NHTSA ID

11606020

Incident

Aug 2, 2024

The suction jet pump inside the fuel tank is designed to purge fuel from the Evaporative Emissions (EVAP) system. This mechanism could leak and cause a fire. I have informed Audi about the issue but they indicated there isn't a fix for the repair currently. They even stated there isn't a deadline or date they could give me for the repair.

NHTSA ID

11605800

Incident

Jun 7, 2024

The contact owns a 2016 Audi A3. The contact stated that while driving at an undisclosed speed, the engine seized. The contact stated that there was an abnormally strong fuel odor inside the vehicle. Additionally, the contact stated that there was fuel leaking from the fuel tank. The vehicle was taken to the dealer where it was diagnosed with a failed suction jet pump. The contact was informed that the fuel tank and the EVAP charcoal canister needed to be replaced. The vehicle was not repaired. The contact later received notification of NHTSA Campaign Number: 24V110000 (Fuel System, Gasoline). The contact expressed that the failure was very scary. The manufacturer was made aware of the failure. The failure mileage was approximately 41,259.

NHTSA ID

11605359

Incident

Jun 28, 2024

Mileage

41,259 mi

24V110-The suction jet pump inside the fuel tank, designed to purge fuel from the EVAP system is defected and if a specific seal inside an affected suction jet pump fails, the fuel may flow directly into the EVAP system. If this happens, fuel could accumulate in the EVAP system and may leak through the charcoal canister filter element. Leaking fuel, in the presence of an ignition source, may result in a fire. My live and the live of my children is at risk every time I/we drive my car, due to the fact that my car could catch on fire. It is just a matter of time and I am not willing to risk getting caught in a fire, getting hurt or even dying inside my car. There is no repair available and I can not wait any longer. I am requesting replacement of my car ASAP

NHTSA ID

11598704

Incident

Jul 3, 2024

EPC WARNING LIGHT IS COMING AND FUEL TANK NOT RESPONDING

NHTSA ID

11586270

Incident

Apr 24, 2024

What component or system failed or malfunctioned, and is it available for inspection upon request? Power Train system failed also engine light is now on How was your safety or the safety of others put at risk? Me and my toddler were in the vehicle when it started to jerk in bad traffic. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, the mechanic said this is a serious problem and i should be concerned. He stated i should not drive my vehicle. It was inspected by a certified mechanic. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No, everything happen at one time.

NHTSA ID

11582005

Incident

Apr 5, 2024

EL AUTO TIENE UN OLOR FUERTE A GAS Y CUANDO ME DETUVE VOTO GASOLINA POR LA PARTE DE ATRAS EN EL LADO TRASERO DEL PASAJERO. DESPUES INTENTE HECHARLE GAS Y SE LLENA EL CUELLO DEL TANQUE HASTA DESVOLDARSE. NO PERMITE LA ENTRADA DE GAS. AUTO NO TIENE CODIGO DE FALLA. ESTOY PREOCUPADO PORQUE ESTA SITUACION PODRIA OCACIONAR UN INCENDIO. ENCONTRE UN RECALL 20Y6/20Y5 EL CUAL SE REFIERE A MI PROBLEMA. QIERO SABER SI ESTE RECALL ME APLICA. GRACIAS

NHTSA ID

11555847

Incident

Nov 16, 2023

Car start running loosing fuel.

NHTSA ID

11554733

Incident

Nov 11, 2023

Cust gasoline is spilling out of the rear part of the unit. The following complaint, was escalated to AUDi USA related to recall of the suction pump, campaign number 16V647000. My vehicle was replaced or completed the recall on 2017, as requested, approximately 1 years or less of the purchase. Now my vehicle presents the same situation with only 32,000miles and Audi, may be a quotation over $5300 to repair a car that have the same behavior or symptoms that the suction pump recall, with its a safety recall. The car didn't present in the dashboard any flag of malfunction to advise of the danger situation, was in the store parking and one person point me that the car is spill gasoline. The car was moved in the trolley crane to the mechanic's shop. The mechanics, told me that Audi, is responsible for this situation because was a recall. I called to Audi Puerto Rico, and uSA and told me that the car has 7 years, and it is out of warranty. I reiterated, that is a manufactured detects and Audi will be responsible because is a safety issue and the car didn’t present any advice of .

NHTSA ID

11549263

Incident

Aug 24, 2023

I had a safety issue with the gas tank not accepting gas and spilling over and out. I replaced the gas tank and vapor canister, and costly labor. My car was taken to: Palm Beach Performance RO#: 11887 1761 Latham Rd West Palm Beach, FL 33409 Tel#: 561-932-8840

NHTSA ID

11493878

Incident

Nov 10, 2022

The component failing seems to be the fuel system. It is unsafe because the vehicle shoots out fuel all over the place (which is a fire hazard) when I attempt to add fuel to the car. Even though this problem (for our vehicle) is listed on an Audi Technical Service Bulletin, they said that they have nothing to do with the problem. Audi won't inspect the problem just said I have to pay for any repairs. There were no warning lamps, etc. One day the car just starting spitting gas out and has become progressively worse as time has passed. Can only add an extreme minimum amount (about $5.00 worth or less) of fuel to the fuel tank before it shoots out all over the place. The Audi Technical Service Bulletin is uploaded below. We purchased the 2016 car about two years ago but haven't driven it much until recently.

NHTSA ID

11479765

Incident

Jul 16, 2022

Upon parking in my garage, the vehicle leaked fuel from the rear-wheel on passenger side. There were no warning lights to indicate the fuel line or other component was compromised or malfunction. The vehicle was towed to the Audi service center for inspection. The inspection revealed fuel was in the charcoal canister, filter and leak diagnostic pump; replacements were needed. Please see video: https://api.mykaarma.com/video-walkaround/details?inspection_uuid=62b08d040e1dff5107d5e511&fileType=image_and_video The fuel leak was similar to the 2016 Audi Recall 16V647000; it was due to a problem with the suction pump inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system. As fuel accumulated in the EVAP system, it leaked out through the charcoal canister filter element.

NHTSA ID

11470551

Incident

Jun 17, 2022

AUDI A3 QUATTRO 2016 MALFUNCTION INDICATOR LAMP (MIL) CAME ON WHILST DRIVING SLOWLY IN TRAFFIC. I BELIEVE THE VERSION OF THE ECM IN MY VEHICLE IS DEFECTIVE AND MAY BE RELATED TO "SAFETY RECALL 24DF": HTTPS://STATIC.NHTSA.GOV/ODI/RCL/2017/RCONL-17V508-5502.PDF HTTPS://STATIC.NHTSA.GOV/ODI/RCL/2017/RCAK-17V508-2021.PDF CROSS REFERENCING "APPLICATION FOR EMISSIONS CERTIFICATION 2016 MODEL YEAR" "TEST GROUP: GVGAV02.0APA", IN PARTICULAR PAGE 79 FOR MY ENGINE CODE "CNTC" WHICH LISTS SOFTWARE ID "5G0906259L": HTTPS://IASPUB.EPA.GOV/OTAQPUB/DISPLAY_FILE.JSP?DOCID=43249&FLAG=1 THE ECU PART NUMBER WAS SUPERSEDED WITHOUT BEING PROPERLY RELEASED FOR EDIR OR CAL ID AND CVN INFORMATION. PLEASE NOTE THE DIFFERENCE IN PART NUMBER SUFFIX. "B" VS "L". I AM CONCERNED THAT MY CAR IS CURRENTLY DANGEROUS TO DRIVE AND NEEDS REPAIRING. BELOW IS OUTPUT FROM VCDS DIAGNOSTIC TOOL SHOWING THE FAULT AND ECU SOFTWARE ID "5G0 906 259 D" 0001 (FULL OUTPUT CAN BE PROVIDED): ------------------------------------------------------------------------------- ADDRESS 01: ENGINE (J623-CNTC) LABELS:. 06K-907-425-V1.CLB PART NO SW: 5G0 906 259 D HW: 06K 907 425 B COMPONENT: 2.0L R4 TFSI H13 0001 REVISION: --H13--- CODING: 0A1D00124426000F2000 SHOP #: WSC 06385 790 00016 ASAM DATASET: EV_ECM20TFS0205G0906259D 001002 ROD: EV_ECM20TFS0205G0906259D.ROD VCID: 2F3B1884879B11D3269-807A 1 FAULT FOUND: 15059 - FUEL RAIL/SYSTEM PRESSURE P0087 00 [104] - TOO LOW INTERMITTENT - CONFIRMED - TESTED SINCE MEMORY CLEAR FREEZE FRAME: FAULT STATUS: 00000001 FAULT PRIORITY: 2 FAULT FREQUENCY: 2 MILEAGE: 119924 KM DATE: 2021.03.17 TIME: 12:39:23

NHTSA ID

11405759

Incident

Mar 17, 2021

Mileage

74,517 mi

I CANT GET GAS , IT GOES OUT OF THE TANK

NHTSA ID

11297295

Incident

Jan 3, 2020

Mileage

62,300 mi