2019 Audi Q7 Fuel system Problems

Drive System malfunction code appeared while driving. Engine then shut off immediately. Had it towed to Audi dealership. Fuel Pump and Fuel Pump Module Codes reported in diagnostics check: codes P3044, P1158, and P0148. There is a NHTSA campaign number 22V516 (Audi recall number 20DR) that has been reported on this same issue with the fuel pump, however, my model 2019 is one year shy of the 2020 Q7 to 2021 affected vehicle range. Asking NHTSA to look into other repeated fuel pump issues for the same model vehicle, but for 2019 models. I have read of other 2019 model fuel pump complaints that match the 2020-2021 recall. The 2019 models need to be included in the investigation and recall.

NHTSA ID

11691309

Incident

Oct 2, 2025

During high weather temperature the fuel lines pops off and leaks fuel everywhere.

NHTSA ID

11600498

Incident

Jul 6, 2024

On [XXX} Friday morning, I was driving at 35 mph on local road after existing from highway. Suddenly the screen displayed this message: Drive system malfunction. The car was totally broken down. I couldn't start the engine any more so I turned on hazard light and pulled over to the curb pending AAA rescue truck. Luckily it was not happened on highway. Otherwise the car could be wrecked to cause fatal accident. It was the first time since I had this brand new Audi Q7 in November 2019 running 26,600 miles. After Audi certified tech inspected, he concluded the fuel pump defective and needed to replace a new one for $3000+. Here is the link the tech completed his walkaround video [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11593396

Incident

May 24, 2024

Faulty fuel sensor. Sensor showing low fuel warning while the tank is full

NHTSA ID

11588208

Incident

May 7, 2024

I have been told that I have a fuel rail leak, which can cause a fire in the engine compartment. This is the same as NHTSA Campaign Number 19V035000, but that campaign only covers model years 2016-2018 for the Audi Q7. This same issue has surfaced with my 2019 Q7.

NHTSA ID

11585200

Incident

Jan 23, 2023

In the first 10K miles the motherboard had to be replaced. Then the volume dial twice. Then the fuel sensor broke and because of its placement the entire gas tank had to be replaced. Next up at 45K the Medtronic (brains of the transmission had to be replaced and then the differential was having problems and they were debating working on it. I went to sell it at 48K miles before the warranty expired and during the inspection it was noted the two engine mounts were leaking and needed to be replaced. After I sold it to an Audi dealer, different than the Audi dealer I had purchased the car from and where I had all the warranty work done, I found out the CARFAX report showed NONE of the repairs made by the original Audi dealer to the car. Seems fradulent to me by the original Audi dealership who did all the major repairs.

NHTSA ID

11574894

Incident

Oct 18, 2023

Filling up the tank registers only half a tank. It seems similar to this recall which wasn't for my car's year. NHTSA campaign number: 22V155

NHTSA ID

11545957

Incident

Aug 1, 2023

The component that failed was the fuel level sender. The attachment shows that I had it repaired by Audi. They found low static resistance which is the same issue they recalled 46,000 other vehicles for including 2019, just not Q7. The car is available for inspection. My safety was put at risk because the gas and did not work on the safety of others was put at risk because I could have run out of gas anywhere and it anytime. You took over a month to get an appointment. The issue has been corrected in June 2023. Audi was the only one that inspected the vehicle. There was one warning when it failed. .

NHTSA ID

11531737

Incident

Mar 31, 2023

The contact owns a 2019 Audi Q7. The contact stated that while operating the vehicle the message “emergency vehicle malfunction" displayed and the vehicle began to sputter and hesitate before stalling. The vehicle was towed to the local dealer who diagnosed that the fuel pump had failed and needed to be replaced. The fuel pump was replaced, and the vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was 51,000.

NHTSA ID

11510654

Incident

Dec 19, 2022

Mileage

51,000 mi