2010 BMW 328I Engine Problems

I am filing a formal complaint against BMW Seattle for violating federal recall remedy mandates under 49 U.S.C. Chapter 301. The vehicle was delivered for mandatory safety recall 23V-707 after an on-road mechanical shear of the covered VANOS bolts. The dealer has created illegal commercial barriers and failed to fully execute the federal remedy. First, the service department issued a written estimate for $4,405.67, claiming the CAS module and locks failed and required replacement to resolve a no-start condition. I challenged the repair on technical grounds and authorized a new battery and valid key only, the dealer admitted in writing that the electrical sync restored seamlessly and the engine started. They attempted to extract thousands for a functioning module before verifying the recall. Second, the VANOS bolts sheared resulting in certain valve-piston contact. The dealer claimed the engine passed a compression check but refused to provide raw ISTA diagnostic logs to verify this safety threshold. Instead, they demanded an additional out-of-pocket fee of $669.60 to re-perform a test they claimed to have completed, creating a commercial barrier to basic remedy verification. Third, the dealer demanded $2,136.69 to replace a compromised valve cover and PCV valve which functioned without issue pre-failure. Valve cover removal is required for vanos repair and requiring consumer expense for mandatory safety repair is legally prohibited. Indeed, Under BMW SIB 11 09 23, collateral damage must be routed through corporate TSARA, not the consumer. Fourth, the steel VANOS bolt heads sheared completely off. The official remedy mandates dropping the oil pan to locate and remove these fragments to prevent total oil pressure loss. Despite my repeated requests for verification of removal, nothing was provided, the car was inoperable, and I was advised that the recall repair was complete and the vehicle was in outdoor fenced lot awaiting arrangements for removal.

NHTSA ID

11742298

Incident

Jun 5, 2026

The contact owns a 2010 BMW 328I. The contact stated that the vehicle was taken to the dealer for an unknown recall repair, but the vehicle experienced the failure after the repair. The contact stated that while driving at an undisclosed speed, the vehicle lost automotive power, and the check engine warning light was illuminated. The vehicle was taken back to the dealer, where it was initially diagnosed that the oil cap had failed. The dealer later informed the contact that the camshaft solenoid had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 110,000.

NHTSA ID

11733290

Incident

Apr 23, 2026

Mileage

110,000 mi

The contact owns a 2010 BMW 328I. The contact received notifications of NHTSA Campaign Numbers: 24V513000 (Air Bags), 23V707000 (Engine and Engine Cooling), and 22V119000 (Engine and Engine Cooling); however, the parts to do the recall repairs were unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The contact stated that while accelerating from the vehicle idling, and turning left or right, the transmission hesitated before shifting hard. Occasionally, while attempting to accelerate, the vehicle unintendedly decelerated, hesitated, and failed to accelerate as intended. The vehicle intermittently stalled, and the contact would release the accelerator pedal, depress the brake pedal, and allow the steering wheel failure to self-correct. The failures became more persistent. The ABS, check engine, X-Drive Fluid, ESC, and TPMS warning lights were illuminated. The contact stated that after adding fluid, the failure persisted. The driver's front seat air bag failed to activate intermittently while the driver's seat was occupied. The heating system occasionally failed to operate. The contact became aware of fluid under the vehicle. The dealer was contacted, but the vehicle was not repaired. The vehicle was taken to a certified mechanic to be diagnosed, and the air bag and traction control warning lights were illuminated. The certified mechanic recommended an oil change because the engine oil was dirty. The vehicle was not repaired. The contact radiator was repaired to resolve the failure with the heating system, but the failures persisted. The manufacturer was not informed of the failures. The failure mileage was unknown.

NHTSA ID

11733200

Incident

Mar 17, 2026

The contact owns a 2010 BMW 328I. The contact stated that when the vehicle was started, the vehicle was idling rough and occasionally, the vehicle lost automotive power. The contact stated that the failure was intermittent but was more frequent. The contact stated that the check engine warning light was illuminated. While the vehicle was idling, the RPM was fluctuating between 800 - 1,000 RPM. The vehicle was taken to an independent mechanic, who diagnosed the vehicle and determined that there was a failure with the VANOS valve timing system. The contact was informed that the VANOS valve timing system needed to be replaced. The contact researched online and related the failure to NHTSA Campaign Number: 23V707000 (Engine and Engine Cooling); however, the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was informed of the failure and advised the contact that recalls were VIN-specific and that the VIN was not included in the recall. The failure mileage was approximately 130,000.

NHTSA ID

11723902

Incident

Aug 18, 2025

Mileage

130,000 mi

2010 bmw 328i xdrive: Had in for recall PCV 1/08/2025. This vehicle has had a prior recall for same issue before i owned in 2014. Motorwerks BMW failed to complete recall, as parts and repair bulletin from BMW OF AMERICA has parts list. Motorwerks just CHOSE to put items, subtitled under other services/self pay. When I asked about this they responded that CAR WAS OUT OF WARRANTY ....as build date put it a year out? A RECALL IS A RECALL ITS FOREVER, OR THE LIFE OF CAR. not when they the dealer/shop and BMW right? i have filed and called and complained to numerous places including NCDS, BMW of AMERICA and have gotten no traction or reasonable response. Now I'm having VANOS related issues, serious issues, but no recall listed?, even though the year and style and build date put it in parameters of SAFETY RECALL not just manufacture voluntary recall.

NHTSA ID

11722638

Incident

Mar 2, 2026

A few months ago, I tried to get the above-referenced recall item taken care of at BMW of West Houston (Texas). I was told by the dealership service advisor that it would take at least two days to get the work done. The recall notice, of course, says the work should take about four hours. I was also told that in many cases the valve cover gets bent when performing this work and the cost of the replacement valve cover would be my responsibility. I was very disappointed of course. I don't think that I should pay for anything related to getting a safety recall taken care of. Safety recalls are very serious and for that reason I have sent the enclosed letter to BMW of North America I have also sent a letter to BMW of West Houston, 20822 Katy Freeway, Katy, TX 77449 expressing my disappointment. I am hopeful that I can get this recall, and the several other recalls this particularly car is subject to, taken care· of soon and without much drama. I would appreciate any guidance you can provide.

NHTSA ID

11659690

Incident

Apr 24, 2025

The contact owns a 2010 BMW 328I. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated the vehicle lost motive power, and the contact drifted over to the shoulder of the roadway. The vehicle was restarted and driven to the intended destination. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 135,645.

NHTSA ID

11649521

Incident

Mar 13, 2025

Mileage

135,645 mi

The contact owns a 2010 BMW 328I. The contact stated while driving at an undisclosed speed, the vehicle lost motive power. There was no warning light illuminated. The vehicle was towed to the dealer but was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The approximate failure mileage was 96,000.

NHTSA ID

11626422

Incident

Nov 20, 2024

Mileage

96,000 mi

I have problems consistent with SI B11 07 14- VANOS gear bolt breaking. BMW lied and said that the problem affected only 200,000 cars when in reality it affected a lot more cars. I am losing oil at a slow rate but after than normal oil loss of a healthy engine and have no external leaks, meaning there is an internal leak. I have a metallic rattling noise as well. These problems are consistent with broken VANOS gear bolt(s). I also have a timing issue code popping up with a check engine light that can be caused by this incident. The car is available for inspection upon request. If the problem persists, the engine could experience critical failure causing harm to the components as well as the driver/passengers. I have not been to a dealer yet. I have a scheduled appointment with NEW COUNTRY BMW on Monday to address the airbag issue. A diagnostic for the issue would cost a lot of money that I do not have.

NHTSA ID

11617834

Incident

Oct 2, 2024

The contact owns a 2010 BMW 328I. The contact received notification of NHTSA Campaign Number: 23V707000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ID

11611185

Incident

Aug 27, 2024

The contact owns a 2010 BMW 328I. The contact received notifications of NHTSA Campaign Numbers: 24V513000 (Air Bags) and 23V707000 (Engine and Engine Cooling); however, the parts to do the recall repairs were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ID

11604079

Incident

Dec 1, 2023

The contact owns a 2010 BMW 328I. The contact received notification of NHTSA Campaign Number: 23V707000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ID

11593141

Incident

Jun 7, 2024

The contact owns a 2010 BMW 328I. The contact received notification of NHTSA Campaign Number: 23V707000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while his daughter was driving at an undisclosed speed, the vehicle stalled and lost motive power. In addition, the check engine warning light illuminated. The vehicle was taken to an independent mechanic where it was misdiagnosed. The contact stated that several parts were replaced, including a new radiator hose, a new water pump, and several unknown sensors. The failure reoccurred and became persistent. The contact stated that the vehicle had to be towed to the residence three times. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 107,500. VIN tool confirms parts not available.

NHTSA ID

11592137

Incident

Feb 3, 2024

Mileage

107,500 mi

The contact owns a 2010 BMW 328I. The contact stated while driving at various speeds, the vehicle lost motive power, stalled, and failed to restart. The contact received notification of NHTSA Campaign Number: 23V707000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 158,000. VIN tool confirms parts not available.

NHTSA ID

11590521

Incident

May 22, 2024

Mileage

158,000 mi

The contact owns a 2010 BMW 328I. The contact received notification of NHTSA Campaign Number: 23V707000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ID

11590240

Incident

May 22, 2024

The recall for the failed Vanos bolts has been issued for over half a year, and no remedy is available. It does not make sense to wait this long for an engine fix recall. Before the remedy is available, some BMW owners have even experienced engine failure due to the Vanos bolts issue, but there is no compensation. Please put pressure on them to address this recall in a timely manner. Thank you!

NHTSA ID

11589817

Incident

Oct 31, 2023

The contact owns a 2010 BMW 328I. The contact received notification of NHTSA Campaign Number: 23V707000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated while driving at an undisclosed speed, the vehicle went into "Safe Mode" and decelerated with the check engine warning light illuminated. The cause of the failure was not yet determined. The failure mileage was 105,000. VIN tool confirms parts not available.

NHTSA ID

11588647

Incident

May 1, 2024

Mileage

105,000 mi

The contact owns a 2010 BMW 328I. The contact stated that while driving at unknown speeds, the vehicle stalled. The contact stated that there was a rattling sound coming from the engine compartment. The vehicle was towed to an independent mechanic and was diagnosed with starter failure. The vehicle was repaired; however, the contact was informed that the rattling sound was related to an engine issue. The vehicle was not repaired. The contact received the notification of the NHTSA Campaign Number: 23V707000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was approximately 76,000. VIN tool confirms parts not available.

NHTSA ID

11588109

Incident

May 15, 2023

Mileage

76,000 mi

My 2010 BMW is under Recall 23V707 for vanos bolt replacement since October 2023. The check engine light is now on, and the dealer still (May 10, 2023) reports that BMW North America has not sent out replacement bolts. Six months seems like a long time for BMW to not be able to find new bolts and Valve Gasket Covers for the affected vehicles.

NHTSA ID

11588060

Incident

May 10, 2024

The contact owns a 2010 BWM 328I. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to an independent mechanic, who diagnosed failures with the camshaft position sensor and VANOS assembly bolts. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 23V707000 (Engine and Engine Cooling). The VIN was included, but parts were not yet available. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was unknown.

NHTSA ID

11587244

Incident

May 6, 2024

The contact owns a 2010 BMW 328I. The contact received notification of NHTSA Campaign Number: 23V707000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The contact stated while driving at approximately 35 MPH, the vehicle was sputtering, jerking, shuddering, and stalled. The check engine warning light was illuminated. The contact was able to restart the vehicle and drove to her destination; however, the failure reoccurred. The vehicle was taken to the dealer. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was unknown. VIN tool confirms parts not available.

NHTSA ID

11584678

Incident

Apr 9, 2024

My wife was driving on the highway when the engine suddenly stalled on her. She had never been through this situation and had no idea what to do. She tried to turn it back on but it would not start. She was frightened, the vehicle was partially on the slow lane and on the shoulder. She turned on the emergency blinkers and immediately called me freaking out, I told her to compose herself, watch her surroundings, to get away from the vehicle and closer to the shoulder. The fact that this happened out of nowhere in the middle of the highway put my wife and others in danger. Luckily she reacted quickly and started making her way towards the shoulder on the right. This could've caused an accident, injuries or even death. A good samaritan stopped and helped her move the bmw out of the lane and into the shoulder. The reason why this occurred to the vehicle is because of the Vanos timing chain assembly. I had Christian Brothers Automotive diagnose a check engine light and a noise that was coming from the engine on March [XXX]. They warned me that this could've happened and to take it to the dealer because it has an open recall on it. I called the bmw dealership and told me they couldn't do anything about it because they did not have a remedy at this time. We knew it was a risk but it's the only car she has to use to work. She strictly used it just for work for that same reason. After it broke down, I got it towed to my house and had an independent mechanic diagnose the issue and he confirmed as well that it was the Vanos timing chain assembly. I towed it to my nearest BMW dealership and told them the situation and about the recall. They said they will diagnose it and look into the recall. We just really need this fixed as soon as possible. Right now I'm having to drop her off at work and she has to find an Uber back home because I'm still working. I'm hoping that with this report, it will help me and others get the problem fixed that we desperately need. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (F

NHTSA ID

11583956

Incident

Apr 16, 2024

The contact owns a 2010 BMW 328I. The contact received notification of NHTSA Campaign Number: 23V707000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The contact stated while driving at undisclosed speeds, the check engine warning light illuminated, then the vehicle stalled and shuddered when the accelerator pedal was depressed. The failure recurred several times. The dealer was contacted. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 200,000. VIN tool confirms parts not available.

NHTSA ID

11583390

Incident

Apr 10, 2024

Mileage

200,000 mi

The contact owns a 2010 BMW 328I. The contact stated while driving at an undisclosed speed, the vehicle briefly jerked and lost motive power. The contact was able to arrive to his destination, where the vehicle failed to restart. The check engine warning light was illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 23V707000 (Engine and Engine Cooling), and the VIN was included, but parts were not yet available. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 170,000.

NHTSA ID

11582587

Incident

Apr 12, 2024

Mileage

170,000 mi

The contact owns a 2010 BMW 328I. The contact received notification of NHTSA Campaign Number: 23V707000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, there was an abnormal grinding sound coming from the engine compartment. Additionally, the check engine warning light illuminated, and the engine seized. The vehicle was towed to the dealer where it was diagnosed with three detached VANOS bolts. The contact was informed that the VANOS bolts needed to be replaced. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 103,000. VIN tool confirms parts not available.

NHTSA ID

11582165

Incident

Dec 11, 2023

Mileage

103,000 mi