2009 BMW 335I Engine Problems

The contact owns a 2009 BMW 335I. The contact stated while driving at various speeds, the vehicle independently entered limp mode with the service transmission warning message on the instrument panel. The contact restarted the vehicle and cleared all warning codes before he resumed normal driving. The dealer was notified of the failure and informed the contact that the vehicle was not under recall. A DTC reader determined that the cause of the failure was related to a defective fuel pump. The manufacturer had yet to be notified of the failure. The vehicle had yet to be repaired. The failure mileage was approximately 55,000.

NHTSA ID

11469415

Incident

Jan 1, 2021

Mileage

55,000 mi

The contact owned a 2009 BMW 335i. The contact stated that he parked his vehicle in the driveway of his residence and the next morning his wife informed him that the vehicle was engulfed in flames. There was no damage to the residence from the flames. The fire department was contacted and arrived to extinguish the flames. A fire report was made. There was no injury sustained. The police arrived and started an investigating however, a police report was not filed. The local dealer was contacted and informed the contact that the Vin was not under recall. The vehicle was deemed a total loss by the fire department. The insurance provider was contacted and informed the contact that fire coverage was not included in his policy. The contact mentioned NHTSA Campaign Number: 17V676000 (ELECTRICAL SYSTEM) as a possible solution to the failure however, the Vin was not included in the recall. The manufacturer was notified of the failure however, no further assistance was provided. The failure mileage was approximately 138,000.

NHTSA ID

11420297

Incident

Dec 8, 2020

Mileage

138,000 mi

I WAS DRIVING ON THE INTERSTATE WHEN MY CAR STARTED TO LOSE ACCELERATION. I COULD NOT ACCELERATE UP AN INCLINE. THEN I HEARD A RATTLING. THE NEXT EXIT WAS A REST STOP AND AS I WAS EXITING MY VEHICLE FAILED AND SHUT DOWN. I HAD NO POWER AT ALL. I COASTED TO A PARKING STALL AND TURNED THE VEHICLE OFF AFTER PARKING IT SAFELY. WHEN I OPENED THE HOOD THE VEHICLE WAS NOT HOT OR SMOKING SO I TRIED TO START IT. THE CAR STARTED BUT WITH A VERY LOUD KNOCKING AND RATTLING SO I SHUT IT OFF AGAIN AND PHONED THE DEALERSHIP. I TOWED THE VEHICLE TO THE DEALERSHIP OVER 30 DAYS AGO AND HAVE NOT BEEN CONTACTED BY THEM NOT 1X. I HAVE CALLED WEEKLY TO NO AVAIL.

NHTSA ID

11361169

Incident

Aug 12, 2020

Mileage

128,000 mi

2009 BMW 335I. CONSUMER WRITES IN REGARDS TO DEFECTIVE INDEX 9 FUEL INJECTORS. *LD THE CONSUMER STATED THE INDEX 9 FUEL INJECTORS WERE DISCONTINUED. ALL 6 FUEL INJECTORS HAD TO BE REPLACED WITH AN INDEX 12. THE CONSUMER REQUESTED TO BE REIMBURSED THE REPAIR COSTS. *JS *JS

NHTSA ID

11298770

Incident

Oct 29, 2019

I WENT TO THE BMW DEALERSHIP (TO HAVE THE SEVERAL RECALL PERFORMED ON MY CAR LASTWEEK 1. RECALL ID 263858 2. RECALL ID 190318 3. RECALL ID 190319 4. RECALL ID 190320 5. RECALL ID 174817 THE SERVICE GUY (HTTPS://WWW.STEVENSCREEKBMW.COM) TOLD ME THAT THEY CANT HONOR THE RECALL BECAUSE MY CAR HAS A REBUILT/SALVAGE TITLE MY CALL VIN NUMBER [XXX] CAR BMW 335I 2009 BASE ON MY UNDERSTANDING RECALLS ARE A SAFETY ISSUE AND BY LAW HAVE TO BE COMPLETED ON THE CAR NO MATTER THE BRANDING ON TITLE. PLEASES LET ME KNOW THE WAY TO GET THE RECALL PROCESS. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID

11046648

Incident

Nov 14, 2017

WHEN STARTING CAR ENGINE, ITS TAKE A LONG TIME TO CRANK UP AND GET THE ENGINE GOING. IT ALSO SOUND REALLY WEAK UNLIKE WHEN I FIRST BOUGHT IT. ENGINE ALSO SHOW WARNING ENGINE MALFUNCTION LIGHT UP FROM TIME TO TIME.

NHTSA ID

10944323

Incident

Jun 13, 2015

Mileage

81,000 mi

MY VEHICLES FUEL CONSUMPTION HAS WORSENED. HEADLIGHTS FLICKERS. VEHICLE GOES INTO LIMP MODE OFTEN. VEHICLE FEELS LIKE IT'S CHOKING OR RUNNING ON LESS CYLINDERS. I HAVE TO CONSTANTLY CHANGE MY CLOCK. MISFIRING STILL OCCURRING EVEN AFTER TUNE UP. LOSS OF POWER. WASTE GATE RATTLE.

NHTSA ID

10838120

Incident

Feb 22, 2016

Mileage

81,400 mi

DRIVING OR STANDING THE ENGINE STALLS. ONE RECALL WAS DONE AND WITH NO RESULTS. *TR

NHTSA ID

10714514

Incident

Feb 23, 2015

Mileage

84,000 mi

TL* THE CONTACT OWNS A 2009 BMW 335I COUPE. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE VEHICLE BEGAN TO LOSE POWER AS THE ENGINE MALFUNCTION REDUCE POWER WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE DEALER WAS NOTIFIED AND ADVISED THE CONTACT THAT SHE NEEDED TO TURN THE VEHICLE OFF FOR 15 MINUTES TO CORRECT THE FAILURE. THE CONTACT TURNED THE VEHICLE OFF AND ALLOWED IT TO SIT BEFORE RESTARTING. THE VEHICLE WAS RESTARTED AND FUNCTIONED NORMALLY FOR SEVERAL WEEKS BEFORE THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE BUT PROVIDED NO ASSISTANCE. THE FAILURE MILEAGE WAS 58,000.

NHTSA ID

10486473

Incident

Mar 7, 2012

Mileage

58,000 mi

IT IS A VERY DANGEROUS PROBLEM WITH THIS VEHICLE THAT BMWNA IS WELL AWARE OF, BUT INSISTS THAT IT IS "NORMAL BEHAVIOR" FOR MY CAR/TRANSMISSION. I BROUGHT THE CAR INTO THE DEALER, AND THEY WERE ABLE TO REPRODUCE IT, BUT THEY WERE TOLD BY BMW THAT THIS WAS "NORMAL BEHAVIOR." THE PROBLEM OCCURS WHEN YOU SLOW DOWN- LIKE FOR A TURN, BUT DO NOT COME TO A COMPLETE STOP. THE DCT TRANSMISSION SEEMS TO HAVE TROUBLE FIGURING OUT WHAT GEAR TO SELECT BECAUSE WHEN YOU STEP ON THE GAS TO ACCELERATE, THERE IS A VERY SIGNIFICANT DELAY IN THE ONSET OF POWER- UP TO 2-3 SECONDS. BY THIS TIME, THE DRIVER IS USUALLY REALLY DIGGING INTO THE THROTTLE. THE TRANSMISSION FINALLY PICKS A GEAR, WHICH RESULTS IN THE CAR SUDDENLY LURCHING FORWARD, SOMETIMES INVOKING THE ANTI-SKIP CONTROL. THE DANGER IN THIS BEHAVIOR OCCURS WHEN MAKING A TURN INTO ON-COMING TRAFFIC AFTER SLOWING DOWN TO AROUND 10-15 MPH. AFTER THE TURN, THE CAR IS POSITIONED IN THE TRAFFIC LANE, BUT YOU HAVE NO POWER TO ACCELERATE INTO THE FLOW OF TRAFFIC. THE ONCOMING CARS ARE NOW CLOSING IN ON YOUR CAR AT A FAST RATE, AND YOU'RE BASICALLY STUCK. THIS SITUATION IS MOST PRONOUNCED IN THE "AUTO" MODE OF THE DCT TRANSMISSION, BUT ALSO OCCURS TO A LESSER DEGREE WHILE IN THE MANUAL MODE WHEN YOU SELECT SECOND GEAR IN PREPARATION FOR THE TURN. IT IS ALSO VERY REPEATABLE IN BOTH MODES. THESE PROBLEMS STARTED OCCURRING AFTER A PREVIOUS RECALL ON THIS TRANSMISSION WHERE THE ENGINE WOULD STALL UNDER HARD BRAKING OR NOT SHIFT UNDER HARD BRAKING. THE RECALL FIXED THAT PROBLEM, BUT INTRODUCED THIS PROBLEM, WHICH OCCURS ALMOST EVERY DAY WHEREAS THE PREVIOUS PROBLEM ONLY OCCURRED DURING A SPECIFIC SITUATION. THANK YOU FOR LOOKING INTO THIS DANGEROUS MATTER. *TR

NHTSA ID

10474481

Incident

Sep 10, 2012

Mileage

20,400 mi

I BUY MY 2009 BMW 335I WITH 39,700 MILES, FULL BMW SERVICE WAS DONE THE SAME DAY, MY NEXT SERVICE WAS AT 49,000 MILES HOWEVER AT AROUND 48,000 MILES. WHEN DRIVING TO WORK ON THE HIGHWAY GOING 50MPH I HAD TO MOVE OVER TO THE PASSING LANE AND WHEN I ATTEMPTED TO ACCELERATE ABOUT AT 65MPH THE CAR STARTED TO SHAKE VERY BAD AND THE ENGINE LIGHT CAME ON AND I LOSS POWER HAD TO SLOW DOWN TO 20-25MPH COULD HAVE CAUSE AN ACCIDENT AS I WAS IN THE FASTER LANE AND CAR SLOW DOWN RAPIDLY!! THANK GOD I WAS ABLE TO MOVE ALL THE WAY OVER TO THE SLOWER LANE WITH LITTLE ISSUE. AFTER I PULLED OVER I TURNED THE CAR OFF AND OPEN THE HOOD AS MY OIL TEMP WAS JUST ABOUT AT 250*, UNDER HOOD TEMPS WAS HOT BUT NOT ANYTHING CRAZY, EVERYTHING LOOKS GOOD SO I STARTED THE CAR AND IT IDLE LIKE NORMAL AND THE ENGINE LIGHT WAS NOW GONE, I CLOSE THE HOOD AND WAS ABLE TO DRIVE THE CAR LIKE NORMAL, SO I TOOK THE CAR TO THE LOCAL BMW DEALER IN MY WORK AREA AND THEY TOLD ME THE ISSUE I AM HAVING IS CAUSE BY THE HPFP HIGH PRESSURE FUEL PUMP, SO THEY REPLY IT AND EVERYTHING SEEMS NORMAL FOR ANOTHER 2,000 MILES THEN I HAD THE SAME ISSUE AGAIN! THIS TIME I WAS HEADING HOME AND IT HAPPENED WHEN I WAS TRYING TO ACCELERATE WITH MOVING TRAFFIC OMG THAT WAS BAD ALL MOST CAUSE A MAJOR ACCIDENT WITH ALL THE CARS, TRUCKS BEHIND ME HAD TO SLOW DOWN RAPIDLY .. WAS GOING 30MPH AND TRIED TO SPEED UP TO 60 .. AT AROUND 45MPH CAR LOST POWER AND WAS SHAKING WORST THAN THE FIRST TIME THIS HAPPENED, ENGINE LIGHT CAME ON, AGAIN THANK GOD I WAS ABLE TO PULL OVER, I TURN THE CAR OFF AND WAITED FOR 5-6MIN THAN TURN IT BACK ON, THIS TIME THE ENGINE LIGHT REMAIN ON, MY OIL TEMP WAS AROUND 190*, THE CAR STILL IDLE AND DRIVE AS NORMAL EVEN WITH THE ENGINE LIGHT ON, TOOK IT TO MY LOCAL BMW DEALER IN MY HOME AREA AND THEY FOUND THIS TIME IS TWO BAD INJECTORS ONE AT CYLINDER 1 AND THE OTHER AT CYLINDER 5 .COST OF REPAIR $1.1K. *JS

NHTSA ID

10455612

Incident

Mar 12, 2012

Mileage

48,000 mi

2009 BMW 335I HAS HAD ENGINE RUN AT HALF POWER NUMEROUS TIMES. ONLY ONCE WAS IT ABLE TO BE TAKEN TO THE DEALERSHIP IN TIME FOR THEM TO RETRIEVE ANY DIAGNOSTIC INFORMATION AND ACT ON IT AT THAT POINT IN TIME, HOWEVER IT HAS SUFFERED SIMILAR BEHAVIOR SINCE THIS POINT AND SUPPOSEDLY THEY ARE UNABLE TO RETRIEVE DATA, EVEN WITHIN A WEEK OR TWO OF THE EVENT OCCURRING AND STATE THAT NOTHING IS WRONG WITH IT. THE FIRST TIME THIS HAPPENED I WAS MAKING A LEFT TURN AND WAS RELYING ON THE ACCELERATION OF THE VEHICLE TO MAKE A TURN AT A REASONABLE SPEED PRIOR TO TRAFFIC ARRIVING AND THE CAR SIMPLY GAVE OUT AND REDUCED ITSELF TO HALF POWER (PER THE ERROR ON THE SCREEN). QUITE NEARLY GOT ME IN AN ACCIDENT. THE FILING DATE ON THIS IS THE MOST RECENT, TO MY KNOWLEDGE, OF THE INCIDENT OCCURRING. I WASN'T AWARE OF THIS SITE UNTIL NOW SO IT'S POSSIBLE THE DATE IS OFF BY AS MUCH AS 4-6 WEEKS. *TR

NHTSA ID

10377129

Incident

Nov 20, 2010

Mileage

25,000 mi

10/8/2010 - WHILE TRAVELING ON ALLIGATOR ALLEY IN SOUTHERN FLORIDA, 2009 BMW 335I EXPERIENCED A SEVERE LOSS OF POWER WITH ENGINE LAMP TURNING ON. LOSS OF POWER WORSENED FOR THE NEXT SEVENTY FIVE MILES UNTIL THE CAR COULD NOT GO OVER FORTY MILES PER HOUR AND HAD INSUFFICIENT TORQUE TO GO UP ANY INCLINED HIGHWAY OFF RAMPS. TOOK CAR BACK TO BMW DEALERSHIP AND WAS INFORMED LOSS OF POWER WAS DUE TO FAILURE OF HIGH PRESSURE FUEL PUMP, AND WAS INFORMED THAT THE PUMP WOULD BE REPLACED AND ENGINE SOFTWARE UPDATED. CAR HAD APPROXIMATELY 10,000 MILES AT THE TIME OF INCIDENT. *TR

NHTSA ID

10360230

Incident

Oct 8, 2010

Mileage

10,300 mi

MY BMW TURNED OFF ON THE HIGHWAY. ENGINE LIGHT CAME ON AND CAR STOPPED. *TR

NHTSA ID

10343920

Incident

Jul 18, 2010

Mileage

8,000 mi

INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) I AM THE OWNER OF A 2009 BMW 335I PURCHASED AUGUST 2009. ON APRIL 6, 2010, I STARTED THE ENGINE IN THE MORNING AND WAS GREETED WITH LONG CRANKS AND THE CHECK ENGINE LIGHT TURNED ON WITH AN ERROR MESSAGE OF ENGINE FAILURE, REDUCED POWER. THE CAR HAS BEEN FINE BEFORE THIS MORNING AT 7,200 MILES APPROX. I CONTACTED THE DEALER AND WAS TOLD TO BRING IT IN. THE CAR WAS STILL DRIVABLE. ON THE WAY TO THE DEALERSHIP, THE CAR STALLED AND COMPLETELY LOSE POWER ON THE HIGHWAY AND ON THE INSIDE STREET CAUSING ME TO HAVE TO QUICKLY PUT THE GEAR IN P AND RESTART THE CAR. I INFORMED THE DEALER ABOUT THE STALL AND ENGINE FAILURE BUT WAS MET WITH NO REGARDS. THE DEALER INFORMED ME THAT IT IS A HIGH PERFORMANCE FUEL PUMP FAILURE. PLEASE INVESTIGATE THE ISSUE AS I DO NOT WANT TO BE DRIVING ON THE HIGHWAY AND HAVE THE ENGINE COMPLETELY STALL AND SHUT DOWN AGAIN. [XXX] *TR

NHTSA ID

10325696

Incident

Apr 6, 2010

Mileage

7,200 mi

VEHICLE LOST POWER, ENGINE LITE CAME ON. TOOK FOR REPAIR, WAS TOLD SINCE IT WASN'T DOING IT @ TIME I BROUGHT IT IN BMW WOULDN'T REPAIR. A COUPLE MONTHS LATER> SAME THING HAPPENED BUT IT DIED THIS TIME & LEFT ME STRANDED. MY NEW CAR NOW HAS 7,000 MILES AND I DON'T TRUST IT! CALLING THEM TO COME GET IT TODAY. *TR

NHTSA ID

10324633

Incident

Dec 15, 2009

Mileage

3,000 mi