RoadVitals

2001 BMW 530IA

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
11
Latest Nov 11, 2018
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
3
Latest Oct 24, 2003
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
5
1 injuries, 0 deaths reported

Overview

Our database contains 11 NHTSA owner-reported complaints for the 2001 BMW 530IA, most frequently naming the engine, airbags and electrical categories. 3 safety recalls have been issued covering this model year; and 12 manufacturer communications are on file.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

  • Engine436.4%
  • Airbags218.2%
  • Electrical218.2%
  • Heating & air conditioning19.1%
  • Powertrain (other)19.1%
  • Transmission19.1%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

3 campaigns cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
03V421000

AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE

Oct 24, 2003
23,000 units potentially affected
The defect: ON CERTAIN PASSENGER VEHICLES, A MICROPROCESSOR IN THE AIR BAG CONTROL MODULE, WHICH ACTIVATES THE FRONT AIR BAGS, THE SIDE AIR BAGS, THE FRONT SEAT SAFETY BELT PRETENSIONERS, AND THE BATTERY SAFETY TERMINAL, MAY HAVE A MALFUNCTION THAT COULD LEAD TO AN UNINTENDED ACTIVATION OF ONE OR MORE OF THESE COMPONENTS.
The risk: UNEXPECTED DEPLOYMENT OF THE AIR BAG(S) COULD CAUSE SERIOUS INJURY IF AN OCCUPANT IS TOO CLOSE TO THE DEPLOYING AIR BAG(S). IN ADDITION, THE BATTERY SAFETY TERMINAL MAY ALSO BE ACTIVATED. IF THAT HAPPENS, THE STARTER CABLE WOULD BECOME DISCONNECTED FROM THE BATTERY, AND THE ENGINE COULD NOT BE RESTARTED.
The remedy: DEALERS WILL REPLACE THE AIR BAG CONTROL MODULE. OWNER NOTIFICATION BEGAN NOVEMBER10, 2003. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
BAYERISCHE MOTOREN WERKEView on NHTSA.gov
02V138000

ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN

May 16, 2002
1,550 units potentially affected
The defect: ON CERTAIN PASSENGER VEHICLES, THE ENGINE AUXILIARY/COOLING FAN OPERATION, INCLUDING VARIABLE SPEED, IS ELECTRONICALLY CONTROLLED. FAILURE OF THE FAN MOTOR CAN CAUSE THE ELECTRICAL CIRCUITRY OF THE FAN CONTROL UNIT TO OVERLOAD AND FAIL, CAUSING THE FAN TO STOP OPERATING.
The risk: IF THIS WERE TO OCCUR, ENGINE OVERHEATING AND SUBSEQUENT ENGINE DAMAGE COULD RESULT. IN ADDITION, IT IS POSSIBLE FOR THE FAILURE OF THE ELECTRICAL CIRCUITRY TO CAUSE A FIRE IN THE FAN CONTROL UNIT LOCATED IN THE FRONT OF THE ENGINE COMPARTMENT.
The remedy: DEALERS WILL REPLACE THE FAN. OWNER NOTIFICATION BEGAN SEPTEMBER 28, 2001. THIS IS A SUPPLEMENT TO A RECALL THAT BEGAN DURING SEPTEMBER 2001 (SEE RECALL CAMPAIGN 01V206). OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.
BAYERISCHE MOTOREN WERKEView on NHTSA.gov
01V206000

ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN

Jun 21, 2001
76,469 units potentially affected
The defect: VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE ENGINE AUXILIARY/COOLING FAN OPERATION, INCLUDING VARIABLE SPEED, IS ELECTRONICALLY CONTROLLED. FAILURE OF THE FAN MOTOR CAN CAUSE THE ELECTRICAL CIRCUITRY OF THE FAN CONTROL UNIT TO OVERLOAD AND FAIL, CAUSING THE FAN TO STOP OPERATING.
The risk: IF THIS WERE TO OCCUR, ENGINE OVERHEATING AND SUBSEQUENT ENGINE DAMAGE COULD RESULT. IN ADDITION, IT IS POSSIBLE FOR THE FAILURE OF THE ELECTRICAL CIRCUITRY TO CAUSE A FIRE IN THE FAN CONTROL UNIT LOCATED IN THE FRONT OF THE ENGINE COMPARTMENT.
The remedy: DEALERS WILL REPLACE THE FAN. OWNER NOTIFICATION BEGAN SEPTEMBER 28, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.
BAYERISCHE MOTOREN WERKEView on NHTSA.gov

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

View all 11
Engine
Filed Nov 11, 2018
Fire reported

VEHICLE WAS PARKED AT WALMART. LESS THEN 5 MINUTES AFTER WALKING INTO THE STORE THE VEHICLE BURST INTO FLAMES. THE FIRE STARTED IN THE FRONT OF THE ENGINE.

NHTSA ID
11150794
Incident
Nov 10, 2018
Mileage
125,000 mi
Electrical
Filed May 13, 2017
Fire reported

I PARKED MY CAR AND FOUND THAT THE ELECTRICAL SYSTEM HAD ALMOST CAUGHT FIRE, MELTING THE CARPET AND PLASTIC INTERIOR, GLOVEBOX AND MULTIPLE ELECTRICAL COMPONENTS AND WIRING HARNESS. THE AIRBAGS HAD DEPLOYED AND THERE WAS BLACK SOOT COVERING THE INTERIOR. I FOUND THAT THERE WAS WATER ACCUMULATED BENEATH THE PASSENGER FOOTWELL, WHERE THERE IS A MAJOR ELECTRICAL FUSE PANEL. THE CAR IS CURRENTLY IN FRONT OF MY HOME AND I'VE HAD TO FIND A REPLACEMENT VEHICLE DUE TO THE EXTENSIVE DAMAGE TO THE WIRING HARNESS AND MODULES. ALSO THE SMOKE DAMAGE WOULD PREVENT ME FROM WANTING TO DRIVE THE CAR. IT HAD BEEN RAINING REGULARLY FOR THE PREVIOUS MONTHS DURING WINTER AND I BELIEVE IT'S POSSIBLE THAT WATER WAS BEING DIVERTED TO THIS AREA WHERE THE MAIN ELECTRICAL FUSES WERE LOCATED. THERE DO NOT APPEAR TO BE ANY PROVISIONS TO KEEP WATER FROM ACCUMULATING OR TO PROTECT THE FUSES FROM WATER INTRUSION. THE ANGLE AT WHICH THE CAR WAS PARKED WAS WITH THE FRONT POINTED UP AT AN INCLINE OF APPROXIMATELY 15 DEGREES. THIS OCCURRED ON A CITY STREET. THE CAR IS IRREPARABLE AND MUST BE DISPOSED OF.

NHTSA ID
10985482
Incident
Apr 4, 2017
Mileage
130,000 mi
Airbags
Filed Dec 12, 2016

TL* THE CONTACT OWNS A 2001 BMW 530IA. WHILE DRIVING 35 MPH, THE PASSENGER SIDE AIR BAG DEPLOYED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 206,000.

NHTSA ID
10934778
Incident
Dec 7, 2016
Mileage
206,000 mi
Powertrain (other)
Filed Nov 6, 2011

2001 BMW 530IA REVERSE?!?! THE CAR HAS NEVER BEEN ABUSED AND ALWAYS SERVICED AS RECOMMENDED BY THE ON BOARD COMPUTER AND OWNERS MANUAL. REVERSE FOR NO REASON STOPPED WORKING AT THE WORST POSSIBLE TIME!!! IT HAS ENOUGH POWER TO ROLL VERY SLOWLY IF YOU REV THE MOTOR OUT OF A FLAT PARKING SPOT BUT IT DOESN'T HAVE ANY POWER TO BACK UP ANY INCLINE AT ALL. I HAVE NEVER ABUSED THE CAR OR HAD ANY PROBLEMS WITH THE DRIVE TRAIN. THE DEALERSHIP TOLD ME IT HAS A SEALED TRANSMISSION AND YOU CAN'T CHECK OR ADD FLUID. I GOT STUCK AGAINST A CURB WHILE TRYING TO PERFORM A U-TURN BLOCKING ONCOMING TRAFFIC AND HAD TO GET A TOW TRUCK TO REMOVE MY CAR A FEW FEET BACK. I THOUGHT THAT I DID SOMETHING WRONG BUT AFTER RESEARCHING I SEE THAT TONS OF PEOPLE HAVE ENCOUNTERED THIS SAME DEFECT!! WHY HASN'T THIS BEEN RECALLED? IT'S A VERY EXPENSIVE REPAIR COSTING THOUSANDS FOR A NEW TRANSMISSION. I WORKED AT A BMW DEALERSHIP IN SALES AND THE SERVICE PROVIDER I SPOKE TO SAID IT'S A COMMON PROBLEM WITH BMW THAT SHOULD BE ADDRESSED. *TR

NHTSA ID
10434352
Incident
Sep 24, 2008
Mileage
97,000 mi
Transmission
Filed Aug 22, 2009

CAR FAILED TO OPERATE IN REVERSE WHEN AUTOMATIC TRANSMISSION WAS PLACED IN REVERSE. *TR

NHTSA ID
10281388
Incident
Aug 15, 2009
Mileage
112,300 mi
Heating & air conditioning
Filed Aug 17, 2005
Fire reported

ON DECEMBER 19, 2004 I WAS DRIVING MY 2001 BMW 530I WITH THE DRIVER SIDE SEAT HEATER IN THE ON POSITION. I PARKED THE CAR IN A PARKING LOT, SHUT OFF THE ENGINE, AND WAS EXITING ON THE DRIVER SIDE, WHEN I NOTICED THAT THE BACK SUPPORT PORTION OF THE DRIVER SIDE SEAT HAD CAUGHT ON E AND BURNED A HOLE THROUGH THE LEATHER INTERIOR. IT ALSO SINGED MY WINTER COAT THAT I WAS WEARING AT THE TIME. I PUT OUT THE FIRE AND REALIZED THAT THE SEAT HEATER ELEMENT HAD MALFUNCTIONED AND CAUSED THE FIRE. TO DATE, I'VE BEEN WORKING TO HAVE THE SEAT REPLACED THROUGH BMW AND ITS DEALERSHIP HERB CHAMBERS BMW OF BOSTON, BUT THEY HAVE DELAYED THE REPLACEMENT, EVENTHOUGH THEY HAVE AGREED TO REPLACE THE SAME. NO REASON WAS PROVIDED FOR THE DELAYS.*AK

NHTSA ID
10133216
Incident
Dec 19, 2004
Airbags
Filed Nov 19, 2003
1 injury reported

ON OCTOBER 31, 2003 AT 9:30PM, AIRBAGS(FRONT, HEAD - DRIVER SIDE/FRONT, SIDE, HEAD - PASSENGER SIDE) DEPLOYED AS DRIVER WAS STARTING THE ENGINE OF A PARKED CAR. THE IMPACT SHATTERED THE FRONT WINDSHIELD AND DRIVER RECEIVED A CONCUSSION. DRIVER IS CURRENTLY SUFFERING FROM HEADACHES, RINGING IN THE EAR, SLEEP-DISORDER, SORE/STIFFNESS. *AK

NHTSA ID
10047187
Incident
Oct 31, 2003
Electrical
Filed Oct 11, 2001
Fire reported

CAR CAUGHT FIRE WHILE PARKED IN GARAGE. *AK

NHTSA ID
753120
Incident
Oct 4, 2001

Manufacturer communications

A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.

B510819

ELECTRICAL SYSTEM; VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

The basic conditions for initializing the power windows are not met.

B160623

ENGINE AND ENGINE COOLING; FUEL SYSTEM, GASOLINE

Engine will crank but not start. There is no communication with the integrated fuel module (TFE) whendiagnosing with ISTA. The following two fault codes will be stored in the DME: 032B43 - Low fuel pressure system, electric fuel pump: pressure value too low CDA594 - Message (- 0x33E) missing, receiver DME, transmitter TFE

B653423

ELECTRICAL SYSTEM; EQUIPMENT

Customers may state that the alarm system (DWA) is not active after locking their unoccupied vehicle. Depending on the vehicle’s equipment and settings, no acoustic or optical confirmation (folding the mirrors/blinking confirmation) is noticeable. Additionally, the red anti-theft alarm LED in the interior mirror does not briefly flash every 2 seconds, indicating the alarm is armed.

B013118

AIR BAGS

TAKATA AIR BAG RECALL-RELATED SHORT-TERM ALTERNATE TRANSPORTATION AND CONSEQUENTIAL REPAIRS This Service Information bulletin supersedes SI B01 31 18 dated October 2018.

B013118

AIR BAGS

TAKATA AIR BAG RECALL-RELATED SHORT-TERM ALTERNATE TRANSPORTATION AND CONSEQUENTIAL REPAIRS This Service Information bulletin supersedes SI B01 31 18 dated October 2018.

B011618

AIR BAGS; AIR BAGS: AIR BAG/RESTRAINT CONTROL MODULE

TAKATA CLASS ACTION SETTLEMENT. CUSTOMER SUPPORT PROGRAM. FRONT DRIVER SIDE AIRBAG MODULES.

Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Compare model years

Complaint and recall counts across every year of this model

BMW 530IA by model year
YearComplaintsRecallsInvestigationsIssue Index
2003130041.4
2002510—
2001Viewing113059.2
1995110—
1994110—
1993010—
1992010—
1991010—
1990010—
1989010—

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.