RoadVitals

2002 BMW 540I

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

NHTSA has issued a “do not drive” advisory affecting this model year.

Campaign 19V015000. Confirm whether your specific vehicle is covered using its VIN before acting on this.

Check your VIN on NHTSA.gov
Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
12
Latest Jan 23, 2018
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
2
Latest Jan 14, 2019
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
1

Overview

Our database contains 12 NHTSA owner-reported complaints for the 2002 BMW 540I, most frequently naming the electrical, steering and airbags categories. 2 safety recalls have been issued covering this model year; and 13 manufacturer communications are on file.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

  • Electrical531.3%
  • Steering531.3%
  • Airbags212.5%
  • Engine212.5%
  • Fuel system16.3%
  • Exterior lighting16.3%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

2 campaigns cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
19V015000NHTSA advisory: do not drive

AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

Jan 14, 2019
157,549 units potentially affected
The defect: BMW of North America, LLC (BMW) is recalling certain model year 2000-2003 525i Sedan, 530i Sedan, 540i Sedan, 2001-2003 525i Sports Wagon and 540i Sports Wagon vehicles, and 2000-2004 X5 SAV 3.0i, X5 SAV 4.4i, and X5 SAV 4.6is vehicles. This recall affects certain vehicles where the original steering wheel has been replaced with the optional sports steering wheel. The sports steering wheel has a frontal air bag inflator that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
The risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
The remedy: Owners are advised not to drive their vehicles until the vehicle has been remedied. BMW will notify owners, and dealers will inspect the vehicle for an optional sports steering wheel with an affected inflator. Dealers will replace the air bag module as necessary, free of charge. The recall began March 14, 2019. Owners may contact BMW customer service at 1-800-525-7417.
BMW of North America, LLCView on NHTSA.gov
15V318000NHTSA advisory: do not drive

AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

May 28, 2015
419,235 units potentially affected
The defect: BMW of North America, LLC (BMW) is recalling certain model year 2002-2005 325i, 325xi, 330i, and 330xi Sedans, and 325xi and 325i Sportswagons, 2002-2006 330Ci, 325Ci, and M3 Convertibles and 325i, 330i, and M3 Coupes, 2002-2003 M5, 540i, 525i Sedan, and 530i Sedans, and 540i and 525i Sportswagons, and 2003 X5 3.0i and 4.4i Sports Activity Vehicles. Please note that the 5-series and X5 vehicles are only included if they are equipped with the optional sports steering wheel. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture.
The risk: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.
The remedy: Owners are advised not to drive their vehicles until the vehicle has been remedied. BMW will notify owners, and dealers will replace the front driver air bag module, free of charge. The recall began Aug 2016. Owners may contact BMW customer service at 1-800-525-7417. Note: This recall supersedes recall 14V-348 in its entirety. Additionally, vehicles that have had their driver side frontal air bag replaced previously as part of a recall remedy need to have their air bag replaced under this recall as well. Note: On December 17, 2015 BMW removed the model year 2004 X5 3.0i and 4.4i Sports Activity vehicle from this recall. Those vehicles were mistakenly identified as including the air bags that are subject to this recall.
BMW of North America, LLCView on NHTSA.gov

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

View all 12
Airbags
Filed Jan 23, 2018
Crash reported

TL* THE CONTACT OWNED A 2002 BMW 540I. WHILE THE CONTACT'S VEHICLE WAS AT A STOP SIGN, IT WAS REAR ENDED BY ANOTHER VEHICLE. THE AIR BAGS FAILED TO DEPLOY. THERE WERE NO INJURIES AND A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED AND DEEMED A TOTAL LOSS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 40,000. *BF *TR

NHTSA ID
11064447
Incident
Dec 17, 2017
Mileage
40,000 mi
Electrical
Filed Dec 9, 2016

TL* THE CONTACT OWNS A 2002 BMW 540I. THE CONTACT STATED THAT IT TOOK TEN ATTEMPTS TO START THE VEHICLE. THE FAILURE OCCURRED AT LEAST THIRTY TIMES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 166,000.

NHTSA ID
10934048
Incident
Dec 9, 2016
Mileage
166,000 mi
Airbags
Filed Jul 22, 2016

TL* TAKATA RECALL. THE CONTACT OWNS A 2002 BMW 540I. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V318000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT. ...UPDATED 09/14/16 *BF UPDATED 10/18/16.*JB

NHTSA ID
10887705
Incident
May 28, 2015
Exterior lighting
Filed Jun 24, 2015

THE PLASTIC COVERS ON THE HEADLIGHTS OF MY BMW BECAME CRAZED/FROSTED. EVERY BMW OF THIS VINTAGE HAS THE SAME PROBLEM. I SHOWED THIS TO OCCUR IN 2010 AT 100,000 MILES, BUT IN FACT IT WAS A STEADY DEGRADATION OVER SEVERAL YEARS. IT'S A SAFETY ISSUE, BECAUSE THE LIGHT OUTPUT IS SIGNIFICANTLY REDUCED. CAUSING RISK AT NORMAL HIGHWAY SPEEDS. IN ADDITION, THE CRAZING/FROSTING RESULTS IN ADDITIONAL GLARE TO ONCOMING TRAFFIC. I ASKED ABOUT RECALLS/REPLACEMENT PROGRAM FOR THIS DEFECT AT MY LOCAL BMW DEALER; THE SERVICE TECHNICIAN DISMISSED IT AS A NORMAL AGING ISSUE. I STRONGLY DISAGREE. A CAR OF THIS PRICE, OR ANY PRICE, SHOULD HAVE HEADLIGHTS THAT LAST LONGER THAN A FEW YEARS. I REPLACE THE HEADLAMP COVERS IF THEY WERE AVAILABLE, BUT THE ONLY SOLUTION IS TO REPLACE THE ENTIRE HEADLAMP ASSEMBLY AT A COST OF $1238 FOR EACH SIDE. YES, $1238. THIS WAS A QUITE EXPENSIVE AUTO, BUT REGARDLESS OF COST, THIS SAFETY ISSUE SHOULD RESULT IN A RECALL....UPDATED 07/30/15 *BF THE DEALER INFORMED THE CONSUMER IT WAS A NORMAL AGING ISSUE. THE CONSUMER STATED THE LIGHT OUTPUT WAS SIGNIFICANTLY REDUCED. UPDATED 09/01/15. *JB

NHTSA ID
10730119
Incident
Jun 1, 2010
Mileage
100,000 mi
Steering
Filed May 12, 2015

POWER STEERING PUMP MOUNTING BRACKETS BROKE OFF ( ON A POWER STEERING PUMP ITSELF), CAR THUS LOST POWER STEERING, BELT GOT OFF, IN A TURN IT WOULD HAVE BEEN A DISASTER , SOMEHOW I WAS ABLE TO STEER IT CLEAR IN A TURN. I GUESS I WAS LUCKY.

NHTSA ID
10715825
Incident
Apr 23, 2015
Mileage
86,000 mi
Steering
Filed Apr 9, 2015

I WAS DRIVING AND MY SERPENTINE BELT FELL OFF. AFTER INSPECTION THE BRACKET FOR MY POWER STEERING PUMP BROKE AND CAUSED THE BELT TO FALL OFF. LOST POWER STEERING WHILE DRIVING. *TR

NHTSA ID
10704846
Incident
Apr 4, 2015
Mileage
96,000 mi
ElectricalEngineSteering
Filed Dec 16, 2013

AFTER STARTING UP MY CAR, THERE WAS A SLIGHT WHINE UNDER THE HOOD. I GAVE THE CAR A LITTLE BIT OF THROTTLE TO SEE IF THE WHINE WENT AWAY AND HEARD A LOUD BANG. THE CAR WAS STILL RUNNING BUT MY BATTERY LIGHT WAS ON. I NEEDED TO GET HOME, AND I THOUGHT THAT MY CAR MAY NOT START AGAIN IF I TURNED IT OFF SO I DROVE HOME. IMMEDIATELY I NOTICED THAT I DIDN'T HAVE ANY POWER STEERING. AS I DROVE MY ENGINE TEMPERATURE GOT HIGHER AND I BARELY MADE IT HOME WITHOUT OVERHEATING. A FEW DAYS LATER I LOOKED IN THE ENGINE COMPARTMENT AND SAW THAT THE POWER STEERING PUMP HAD BROKEN FREE OF THE ENGINE - THE BRACKET HAD SHEARED OFF. THAT IN TURN CAUSED THE BELT TO FALL OFF WHICH WAS TURNING THE WATER PUMP AND ALTERNATOR. I GOT ON THE COMPUTER AND LOOKED UP THE PROBLEM AND FOUND A LOT OF PEOPLE EXPERIENCING THE SAME PROBLEM, SOME DRIVING DURING THE INCIDENT. THIS IS A REAL DEFECTIVE DESIGN AND CAUSES ME TO BE CONCERNED ABOUT THE SAFETY. I HOPE NOTHING TRAGIC HAS TO HAPPEN TO SOMEONE FOR THIS TO BE CONSIDERED A RECALL. *TR

NHTSA ID
10556285
Incident
Dec 10, 2013
Mileage
151,345 mi
ElectricalEngineSteering
Filed Oct 2, 2012

I WAS DRIVING IN STOP AND GO TRAFFIC WHEN I NOTICED THE STEERING FELT A LITTLE STIFFER THAN USUAL. AFTER ABOUT 5 MILES AND BETTER FLOWING TRAFFIC I PULLED INTO A RESTAURANT FOR DINNER WHEN MY UPPER RADIATOR HOSE EXPLODED. I PULLED INTO A STALL AND OPENED THE HOOD TO INSPECT WHAT HAPPENED. THE HOSE WAS VERY APPARENT AND AFTER FURTHER INVESTIGATION I NOTICED THE POWER STEERING PUMPS PULLEY AT A VERY SHARP ANGLE COMPARED TO LINEAR WITH THE SERPENTINE BELT. I CAN ONLY ASSUME THAT FROM THE BRACKET ON THE PUMP BREAKING, IT CAUSED A CHAIN REACTION OF EVENTS. FIRST THE BRACKET BROCKET PUTTING THE PUMP AT A STEEP ANGLE N FORCING THE BELT TO GO OFF TRACK WHICH THEN CAUSED ALL THE OTHER ACCESSORIES TO BE DISABLED INCLUDING THE WATER PUMP WHICH OVERHEATED THE CAR. *TR

NHTSA ID
10478241
Incident
Sep 30, 2012
Mileage
76,854 mi

Manufacturer communications

A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.

B510819

ELECTRICAL SYSTEM; VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

The basic conditions for initializing the power windows are not met.

B160623

ENGINE AND ENGINE COOLING; FUEL SYSTEM, GASOLINE

Engine will crank but not start. There is no communication with the integrated fuel module (TFE) whendiagnosing with ISTA. The following two fault codes will be stored in the DME: 032B43 - Low fuel pressure system, electric fuel pump: pressure value too low CDA594 - Message (- 0x33E) missing, receiver DME, transmitter TFE

B653423

ELECTRICAL SYSTEM; EQUIPMENT

Customers may state that the alarm system (DWA) is not active after locking their unoccupied vehicle. Depending on the vehicle’s equipment and settings, no acoustic or optical confirmation (folding the mirrors/blinking confirmation) is noticeable. Additionally, the red anti-theft alarm LED in the interior mirror does not briefly flash every 2 seconds, indicating the alarm is armed.

B013118

AIR BAGS

TAKATA AIR BAG RECALL-RELATED SHORT-TERM ALTERNATE TRANSPORTATION AND CONSEQUENTIAL REPAIRS This Service Information bulletin supersedes SI B01 31 18 dated October 2018.

B013118

AIR BAGS

TAKATA AIR BAG RECALL-RELATED SHORT-TERM ALTERNATE TRANSPORTATION AND CONSEQUENTIAL REPAIRS This Service Information bulletin supersedes SI B01 31 18 dated October 2018.

B011618

AIR BAGS; AIR BAGS: AIR BAG/RESTRAINT CONTROL MODULE

TAKATA CLASS ACTION SETTLEMENT. CUSTOMER SUPPORT PROGRAM. FRONT DRIVER SIDE AIRBAG MODULES.

Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Compare model years

Complaint and recall counts across every year of this model

BMW 540I by model year
YearComplaintsRecallsInvestigationsIssue Index
2025100—
2024510—
2023500—
2022301—
2021851—
2020350—
2019111052.2
2018292055.4
2017201144.8
2003720—
2002Viewing122044.3
2001154056.6
2000312051.3
1999221036.1
1998261038.8
1997270038.2
1996000—
1995102050.2
1994840—
1993010—
1992010—
1991010—
1990010—
1989010—

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.