2003 BMW 745LI

In a letter dated October 16, 2012, BMW of North America, LLC (BMW) submitted a Defect Information Report (DIR), NHTSA Recall No. 12V-502 to NHTSA identifying a safety defect involving the possibility of unattended vehicle rollaway in MY 2005 through 2008 BMW 7-Series (approximately 45,000) vehicles equipped with the Comfort Access Option.The Comfort Access option allows the driver to start and stop the engine (by pressing the engine start / stop button) without inserting the key fob into the vehicles key slot in the instrument panel.Subject vehicles not equipped with the Comfort Access option require the key fob be inserted the key slot to start the engine.Upon removal of the key from the key slot the vehicle will automatically shift to Park if the driver has not done so using the gearshift lever.Sunject vehicles equipped with the Comfort Access option are designed such that when the vehicle is stopped with the service brakes applied and the transmission in Drive or Reverse, the driver can push the engine start/stop button one time, stopping the engine and automatically shifting the transmission to Park.In its DIR, BMW identified a condition such that if the driver depressed the start-stop button multiple times in rapid succession, the transmission could shift to Neutral instead of Park.With the transmission in neutral, depending on the slope of the road, the vehicle could rollaway if unattended.In review of data submitted to the Office of Defects Investigation (ODI) and of reports submitted to BMW, ODI identified 20 reports alleging vehicle rollaway involving vehicles equipped with Comfort Access.The vehicles identified in these reports are all subject to recall 12V-502.Ten of these reports were identified as likely related to the defect described in recall 12V-502.Two of the reports are likely related to other mechanical failures.The remaining 8 allegations of vehicle rollaway could not be associated with a specific cause.There are 32 reports alleging vehicle rollaway in the subject vehicles not equipped with the Comfort Access option.A vehicle based safety defect trend was not identified in these reports.Subject vehicles not equipped the Comfort Access option will automatically shift to Park once the key fob is removed from the key slot.In this regard these vehicles behave similarly to those with traditional mechanical keys where the key cannot be removed from the ignition unless the vehicle is shifted to Park.The difference between these vehicles and the subject vehicles with the Comfort Access option is that in the Comfort Access equipped vehicles, the engine can be started and stopped without the key fob in the key slot.ODI reports 10429922 and 10419177 noted in the EA opening resume were determined to be vehicles not equipped with the Comfort Access option and ODI did not identify a vehicle based safety defect associated with these incidents.This investigation is closed.The ODI report cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10185770

In response to the Office of Defects Investigation's (ODI) Information Request (IR) for PE11-025, BMW provided ODI with 1 complaint and 46 field reports relating to either incidents of unattended vehicle rollaway or vehicle movement after the driver expected the vehicle gearshift to automatically shift to park. ODI's analysis of the data provided by BMW identified 14 crashes and 5 alleged injuries. ODI has also identified 3 additional reports in its database alleging vehicle rollaway incidents of which 2 resulted in crashes.The subject vehicles are all equipped with push-buttons (Start/Stop button) to control starting/stopping the engine and Shift-by-Wire gearshift systems controlled by a column mounted selector lever behind the steering wheel. The Start/Stop button also controls switching the ignition and the radio ready state On and Off. Shift-by-wire systems replace the traditional mechanical connection (e.g., cable or linkage) between the gearshift and automatic transmission with an electronic connection controlled by a computer module. When parking the vehicle, the driver has the capability to manually shift the vehicle to park by pressing the Park button on the end of the electronic gearshift lever. However, the instructions for engine shutoff provided in the owner's manual state that pressing the Start/Stop button serves the dual function of switching off the engine and automatically shifting the transmission to Park.In response to ODI's information request for PE11-025, BMW described several circumstances where the subject vehicles may shift to neutral when the driver may expect it to automatically shift to park. First, for Comfort Access System (CAS) vehicles, if the transmission is in neutral when the key fob is in the ignition slot and the Start/Stop button is pressed to shut-off the engine, the transmission will remain in neutral. This is referred to as the Carwash mode and is a normal operating feature of the vehicles that is described in the owner's manual. BMW also described two circumstances that are not normal operating features and are not described in the owners' manual: (1) with the transmission in drive or reverse and the engine running, if the Start/Stop button is pushed 2 or 3 times within a 0.3 second to 0.5 second interval, the engine will stop and the transmission will shift to Neutral; and 2) if the Park button on the gearshift lever is pressed at the same time that the gearshift lever is actuated (i.e., toggled up or down) to select drive, reverse or neutral; the transmission will shift to neutral or remain in neutral.Beginning in model year (MY) 2005, BMW introduced CAS as an optional feature package for the subject vehicles.The key for CAS equipped vehicles is an electronic code that is sent to the engine control module by a remote transmitter (key fob). An optional docking port (key slot) is provided for driver convenience or to put the vehicle into Car Wash mode, which allows for engine shutoff in neutral. BMW sold approximately 45,000 subject vehicles with CAS and approximately 94 percent of the CAS equipped vehicles were produced from MY 2006 through 2008. Non-CAS subject vehicles were produced from MY 2002 through 2008 and require the remote control to be in the ignition slot located next to the Start/Stop button to start the engine.The 50 incidents identified by ODI's analysis of complaints and field reports include 18 involving CAS vehicles (39.6 incidents per 100,000 vehicles) and 32 involving non-CAS vehicles (42.0 incidents per 100,000 vehicles). Because the incidents are considered random events, the failure rates were also adjusted for vehicle exposure, resulting in rat

The contact owns a 2003 BMW 745LI. The contact stated while driving approximately 70 MPH, the brake fluid warning light illuminated. The vehicle was taken to the local dealer and diagnosed with rotors, brake wear sensors, and brake failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 174,500.

NHTSA ID

11474996

Incident

Jul 1, 2022

Mileage

174,500 mi

IT SHOWED UP ON MY DASH BOARD AND NOW ITS NOT GOING AWAY

NHTSA ID

11366227

Incident

May 6, 2020

Mileage

115,000 mi

THE AIRBAG LIGHT AND WARNING NEVER CLEARS WHEN DRIVING THE PASSGNERS AIRBAG WARNING LIGHT IS ON , SAYING BRING TO NEAREST BMW DEALER SHIP.

NHTSA ID

11234197

Incident

Apr 9, 2012

Mileage

75,000 mi

TL* THE CONTACT OWNS A 2003 BMW 745LI. AFTER PLACING THE VEHICLE IN PARK, THE CONTACT NOTICED THAT THE GEAR SHIFTED INDEPENDENTLY INTO NEUTRAL. THE CONTACT CALLED BMW OF STERLING LOCATED IN STERLING, VIRGINIA AND WAS INFORMED THAT HE HAD TO PAY FOR A DIAGNOSTIC TEST. THE VEHICLE WAS NOT REPAIRED. IN ADDITION, THE PASSENGER AIR BAG MALFUNCTION WARNING INDICATOR ILLUMINATED CONTINUOUSLY. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 181,000.

NHTSA ID

11031541

Incident

Oct 1, 2016

Mileage

181,000 mi

MY CAR IS HAVING SEVERE TRANSMISSION PROBLEMS THAT WERE RECALLED ON OTHER CARS OF THE SAME YEAR, MAKE AND MODEL. ALSO THE PARK LIGHTS WON'T WORK MOST OF THE TIME. THE TRACTION CONTROL AS WELL AS THE ANTILOCK BRAKES GO IN AND OUT. THE STABILITY CONTROL ON THE FEONT PASSENGER SIDE GOES OUT. IT HAPPENS WHILE DRIVING.

NHTSA ID

10966711

Incident

Mar 11, 2014

WHILE DRIVING APPROXIMATELY 25 MPH AND APPLYING PRESSURE TO THE BRAKE PEDAL IT BECAME DIFFICULT TO ENGAGE THE BRAKES AND ALMOST REAR ENDED A STOPPED VEHICLE. THE BRAKES WHERE NO LONGER FUNCTIONING PROPERLY AFTER THAT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE I WAS TOLD VACUUM BRAKE PUMP, THE LOCK RING SEAL, AND THE BRAKE BOOSTER NEEDED TO BE REPLACED. AFTER SOME RESEARCH I FOUND OUT THAT THERE WAS A RECALL FOR MY VEHICLE. I CONTACTED THE LOCAL BMW DEALER AND WAS TOLD THAT THE RECALL WAS CLOSED FOR MY VEHICLE AND I WOULD HAVE TO PAY OUT OF POCKET EXPENSE TO REPAIR.THE APPROXIMATE FAILURE MILEAGE WAS 116,000. *TR

NHTSA ID

10935554

Incident

Dec 13, 2016

Mileage

116,000 mi

TL* THE CONTACT OWNS A 2003 BMW 745LI. THE CONTACT STATED THAT THE AIR BAG INDICATOR REMAINED ILLUMINATED. THE DEALER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS NOT AVAILABLE.

NHTSA ID

10925064

Incident

Aug 1, 2016

TL* THE CONTACT OWNS A 2003 BMW 745LI. AFTER THE VEHICLE WAS SERVICED, THE AIR BAG WARNING LIGHT ILLUMINATED CONTINUOUSLY. IN ADDITION, THE TENSION SEAT BELT WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 202,082.

NHTSA ID

10884208

Incident

Apr 14, 2016

Mileage

202,082 mi

The basic conditions for initializing the power windows are not met.

Engine will crank but not start. There is no communication with the integrated fuel module (TFE) whendiagnosing with ISTA. The following two fault codes will be stored in the DME: 032B43 - Low fuel pressure system, electric fuel pump: pressure value too low CDA594 - Message (- 0x33E) missing, receiver DME, transmitter TFE

Customers may state that the alarm system (DWA) is not active after locking their unoccupied vehicle. Depending on the vehicle’s equipment and settings, no acoustic or optical confirmation (folding the mirrors/blinking confirmation) is noticeable. Additionally, the red anti-theft alarm LED in the interior mirror does not briefly flash every 2 seconds, indicating the alarm is armed.

Vehicle cannot be opened or closed using comfort access, engine start is not possible, and the vehicle may not start when placing the key against the steering column.

NAVIGATION SYSTEM: REPORTING MISSING OR INCORRECT ROAD MAP DATA: The route guidance is inaccurate and therefore irritating to the customer; or it is not possible to locate certain addresses, for instance:

NAVIGATION SYSTEM: REPORTING MISSING OR INCORRECT ROAD MAP DATA: The route guidance is inaccurate and therefore irritating to the customer; or it is not possible to locate certain addresses, for instance: