2006 BMW 760I

DRAINAGE HOLES CLOG AND LEAKS IN TRUNK WHERE AIR COMPRESSOR FOR SUSPENSION AND OTHER IMPORTANT ELECTRICAL COMPONENTS ARE SUSCEPTIBLE TO WATER DAMAGE.

NHTSA ID

10899025

Incident

Aug 20, 2016

Mileage

80,000 mi

AS A CONSUMER AND ALSO READING ABOUT OTHER CONSUMERS HAVING ISSUES WITH THE HIGH PRESSURE FUEL PUMPS, THE OEM PART WHICH BMW IS CHARGING TO FIX THIS PROBLEM IS OVER $6,000. THE PARTS ARE ONLY FOR THE 2006 760I AND THEY SEEMS TO BE GOING OUT ON A LOT OF PEOPLE. SOME CONSUMERS WERE LUCKY TO HAVE IT GO OUT DURING THEIR WARRANTY BUT SOME HAVE TO DEAL WITH THIS TYPE OF EXPENSE AFTER WARDS. IF THIS PART SEEMS TO GO OUT ON A LOT OF 760I MODELS IN BMW THERE SHOULD BE A RECALL OUT THEIR TO FIX THEM. I CAN UNDERSTAND IF THERE WAS A FEW BUT THERE ARE AT LEAST 20 JUST ON THE FORUM THAT I NORMALLY GO TO FOR ANSWERS TO MY QUESTIONS. THIS SEEMS TO BE AN EPIDEMIC AND BMW NEEDS TO TAKE OWNERSHIP OF THIS, ESPECIALLY SINCE THIS IS ONLY ON ONE MODEL AND THAT THE COST OF THIS IS OVERWHELMING.

NHTSA ID

10824325

Incident

Feb 4, 2016

Mileage

84,400 mi

HARD TO START, CRANKS FOR A WHILE TILL IT BUILDS UP PRESSURE THEN STARTS. IDLES ROUGH AND SOMETIMES DIES WHEN SITTING AT STOP LIGHT, AND SPUTTERING POWER AT TIME WHEN TAKING OFF, ALSO WHEN IT STALLS WHILE DRIVING IT IS A TOTAL LOSS OF POWER FOR STEERING AND OTHER CONTROLS, VERY DANGEROUS WHEN IT HAPPENS. I UNDERSTAND THIS IS A FUEL PUMP PROBLEM. CAR HAS 2 FUEL PUMPS. VERY VERY COSTLY REPAIR AT THE DEALER. DEALER SHOULD REPLACE AT THEIR COST.

NHTSA ID

10811856

Incident

Dec 1, 2015

Mileage

65,000 mi

BAD FUEL PUMPS. THIS IS A MAJOR SAFETY ISSUE BECAUSE YOU CAN BE DRIVING AT ANY DRIVING SPEED AND THE CAR WILL SHUT OFF ON YOU WITH NO WARNING. *TR

NHTSA ID

10653974

Incident

Nov 10, 2014

Mileage

103,300 mi

TL* THE CONTACT OWNS A 2006 BMW 760I. THE CONTACT STATED THAT THE SEAT SENSOR MAT AND AIR BAG WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 13V564000 (AIR BAGS). THE DEALER STATED THAT THE DRIVER SIDE SENSOR MAT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 105,000.

NHTSA ID

10629226

Incident

Aug 28, 2014

Mileage

105,000 mi

HAD VEHICLE DIAGNOSED FOR STALLING, ROUGH IDLING, LOSS OF POWER, AND SHUTTING OFF IN TRAFFIC. FIRST BMW REPAIR FACILITY, "LOW PRESSURE FUEL PUMP OUTPUT, AND HIGH PRESSURE PUMPS VERIFIED VEHICLE HAS EXTENDED CRANK. READ OUT FAULT MEMORY AND FOUND NO RELATIVE FAULTS STORED. PROCEEDED TO PERFORMED LOW PRESSURE SYSTEM CHECK. FOUND OUTPUT PRESSURE LOW AND AFTER VEHICLE SHUT OFF SYSTEM LEAKING BACK. PROCEEDED TO REPLACE INTAKE FUEL PUMP AND FUEL FILTER." PROBLEM WAS STILL PRESENT 3 DAYS LATER. SUBMITTED VEHICLE INTO ANOTHER REPAIR FACILITY WHERE A BMW TECHNICIAN WORKS ON WEEKENDS TO RECEIVE INFORMATION FROM THE FACILITY OWNER, THAT BMW TECHNICIAN CANNOT TOUCH MY VEHICLE. SUBMITTED VEHICLE INTO A 3RD REPAIR FACILITY TO FIND THAT BOTH HIGH PRESSURE FUEL PUMPS HAVE FAILED, "REPLACE BOTH HIGH PRESSURE FUEL PUMPS, REPLACE FUEL TANK PRESSURE LEAK DIAG PUMP." BMW REPAIR FACILITY WAS AWARE OF THIS FAULTY READING BEFORE FIXING A PART THAT WAS NOT BROKEN. THEY KNOW THEIR HIGH PRESSURE FUEL PUMPS ARE FAULTY. *TT

NHTSA ID

10583065

Incident

Mar 12, 2014

Mileage

70,149 mi

TL* THE CONTACT OWNS A 2006 BMW 760I. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 5 MPH, THE FRONT DRIVER'S SIDE DOOR UNEXPECTEDLY UNLATCHED. THE VEHICLE WAS EQUIPPED WITH THE COMFORT ACCESS AND SOFT CLOSE AUTOMATIC OPTIONS. THE DOOR WOULD ONLY REMAIN CLOSED WHILE HOLDING WITH YOUR HAND WHILE DRIVING. THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER 12V504000 (LATCHES/LOCKS/LINKAGES) BUT THE VIN WAS NOT INCLUDED. THE VEHICLE WAS CURRENTLY BEING DIAGNOSED BY AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 91,900. *TR

NHTSA ID

10568686

Incident

Mar 4, 2014

Mileage

919,000 mi

VEHICLE WOULD SHIFT TO NEUTRAL ON ITS ON THEN SHUT OFF IN THE MIDDLE OF TRAFFIC. IT WAS ALSO ROUGH IDLING, LOSS OF POWER, AND EXTENDED IGNITION START. *TR

NHTSA ID

10567466

Incident

Mar 5, 2014

Mileage

70,110 mi

The basic conditions for initializing the power windows are not met.

The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle “discharged battery” complaints.

Engine will crank but not start. There is no communication with the integrated fuel module (TFE) whendiagnosing with ISTA. The following two fault codes will be stored in the DME: 032B43 - Low fuel pressure system, electric fuel pump: pressure value too low CDA594 - Message (- 0x33E) missing, receiver DME, transmitter TFE

Customers may state that the alarm system (DWA) is not active after locking their unoccupied vehicle. Depending on the vehicle’s equipment and settings, no acoustic or optical confirmation (folding the mirrors/blinking confirmation) is noticeable. Additionally, the red anti-theft alarm LED in the interior mirror does not briefly flash every 2 seconds, indicating the alarm is armed.

Component-Specific Limited Warranty Extension. For the eligible vehicles, BMW of North America, LLC (BMW NA) is extending the limited warranty for the vehicle's Radiator Grille Upper and Lower Active Air Flaps to: 15 years/150,000 miles as determined by the vehicle's original in-service date. 1. Air flap control (link) active, upper (G12, G30 and G32) 2. Air flap control (drive), active, upper 3. Air flaps, upper (assembly) 4. Air flaps, lower (assembly) For eligible MY 2017 BMW 530i (B460) vehicles that are currently registered in the State of California (CA) or a State that has fully adopted the State of California PZEV/SULEV regulation (CT, ME, MD, MA, NJ, NY, RI, and VT), the standard emission-related coverage for the Radiator Front Grille Air Vent Flaps is15 years/150,000 miles. This component-specific limited warranty extension applies to defects in materials or workmanship.' This coverage is subject to the same vehicle eligibility requirements, limitations, and exclusions that apply to the BMW New Vehicle Limited Warranty for Passenger Cars and Light Trucks. A check control message or MIL (Malfunction Indicator Lamp) may be illuminated with faults stored related to the upper and/or lower active air flap(s). Potential causes include: Faulty upper air flap link (G12, G30, G32) Faulty upper air flap actuator (G01, G02, G12, G30, G32) Faulty upper flap assembly (G01, G02, G12, G30, G32) Faulty lower air flap assembly (G01, G02, G12, G30, G32) Software error in the DME affecting the upper flap (G01, G02 only) Or: Upon visual inspection, the passenger side upper active air flaps are either stuck open or closed, and they will not move and there are no faults stored for the active air flaps (With no check control message or check engine light or displaying)

Component-Specific Limited Warranty Extension For the eligible vehicles, BMW of North America, LLC (BMW NA) is extending the limited warranty for the vehicle's front and rear air suspension strut assemblies (item # 1 Front and # 2 Rear, shown) to: 8 years/80,000 miles, as determined by the vehicle's original in-service date. Other air suspension system-related components/issues are excluded from this coverage. This component-specific limited warranty extension applies to defects in materials or workmanship. This coverage is subject to the same vehicle eligibility requirements, limitations, and exclusions that apply to the BMW New Vehicle Limited Warranty for Passenger Cars and Light Trucks.