2003 BMW E36

I RECENTLY PURCHASED A 2003 BMW 325I IN DECEMBER 2007. TODAY (JANUARY 21, 2008), MY WIFE DROVE THE CAR TO WORK AND PARKED SAID VEHICLE IN HER REQUIRED PARKING SPACE. THAN ABOUT TWO HOURS LATER A LOCAL POLICE OFFICER CAME IN AND INFORMED HER THAT THE BMW STARTED BY ITSELF AND CRASHED INTO THE POLICE DEPARTMENT. THE VEHICLE WAS IN FIRST GEAR AND SOME HOW STARTED WITH NO ONE IN THE CAR. THIS VEHICLE CAME WITH A REMOTE START FEATURE WHICH IS LOCATED ON THE KEY. THE KEYS WERE ON THE DESK AND MY WIFE WAS NOT IN THE SAME BUILDING THERE THE KEYS WERE. MY WIFE WAS ACTUALLY IN THE POLICE DEPARTMENT WORKING ON THEIR COMPUTER. THERE WAS DAMAGE TO THE FRONT HOOD. A POLICE REPORT WAS FILED. *TR

NHTSA ID

10215580

Incident

Jan 21, 2008

Mileage

77,000 mi

DELAY IN TRANSMISSION ENGAGEMENT (20-30 SECONDS) WHEN COLD. HAZARD ON HILL AND ENTERING TRAFFIC. *TR

NHTSA ID

10214869

Incident

Jul 18, 2001

Mileage

30,000 mi

DOUBLE VANOS SYSTEM ON SEVERAL MODELS OF BMW FROM 1999 TO 2006, HAVE DEFECTIVE VANOS SYSTEMS. THE E39 DOUBLE VANOS (VARIABLE VALVE TIMING UNIT) HAS A MALFUNCTION PROBLEM. THIS DOUBLE VANOS CAN BE FOUND ON 6-CYL ENGINES M52TU, M54, AND M56, FOUND IN SEVERAL MODEL CARS, E39, E46, ETC, YEARS 99-03. THE MALFUNCTION SYMPTOMS ARE ALMOST ALL SUBTLE AND MOSTLY GO UNNOTICED. THEY INCLUDE LOWER GAS MILEAGE, LOWER PERFORMANCE, DEGRADED EMISSIONS CONTROL, AND POSSIBLY OTHERS. THE M52TU ENGINE (99-00) HAS ONE FURTHER MALFUNCTION SYMPTOM WHICH IS FAR FROM SUBTLE. IT OCCURS ON COLD WEATHER COLD ENGINE STARTS AND TAKES THE FORM OF REPEATED ENGINE ATTEMPTED STALLS AND POSSIBLY A COMPLETE ENGINE STALL. THE ENGINE RPMS DROP DRAMATICALLY AND THEN RECOVER. THIS THEN REPEATS AFTER A FEW SECONDS OF STEADY IDLE. THE PROBLEM CAN BE MORE DEFINITIVELY DIAGNOSED BY DISCONNECTING THE VANOS INTAKE OR EXHAUST SOLENOID ELECTRICAL CONNECTOR. *TR

NHTSA ID

10208870

Incident

Oct 9, 2007

Mileage

37,500 mi

2003 BMW 525I WITH 56K MILES. DRIVER SEAT HEATER WAS TURNED ON WHILE THE ENGINE WAS WARMING UP AND FEW SECONDS LATER, ONE SPOT ON THE SEAT STARTED SMOKING AND BURNING A WHOLE. THE ENGINE AND HEATER WAS TURNED OFF IMMEDIATELY WHICH PREVENTED THE FIRE FROM SPREADING. NOTIFIED BMW NORTH AMERICA AND DEALER AGREED WITH FULL SEAT REPLACEMENT. *TR

NHTSA ID

10206555

Incident

Oct 22, 2007

Mileage

56,030 mi

TL*THE CONTACT OWNS A 2003 BMW S10 (NA). THE CONTACT PURCHASED AFTERMARKET CHROME RIMS ONLINE. WHILE DRIVING 75 MPH, THE RIMS SEPARATED FROM THE TIRES AND SHATTERED INTO SEVERAL PIECES. THE VEHICLE WAS TOWED TO THE DEALER, WHERE IT CURRENTLY REMAINS. THE VIN AND ENGINE SIZE WERE UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 63,000.

NHTSA ID

10200209

Incident

Aug 9, 2007

Mileage

63,000 mi

THERE IS A SERIOUS ELECTRICAL PROBLEM ON MANY BMW E46 MODELS (NEWER CARS). THE TAIL LIGHT HARNESS ON BOTH SIDES HAS WHAT SEEMS TO BE A FAULTY, INCOMPLETE, OR INSECURE GROUNDING WIRE AND THE RESULT IS THAT THE WIRE OVERHEATS AND CORRODES, AND IN SOME CASES ARCS, WHICH CAN IGNITE A FIRE. THE PROBLEM IS OFTEN IDENTIFIED BY INTERMITTENT OR PERSISTENT FAILURE OF THE REAR LIGHTS ON THE CAR AND/OR UNNECESSARY REAR LIGHT WARNINGS ON THE DASH. I HAVE PHOTOGRAPHS TO SUPPORT THIS CASE AND HAVE DONE FURTHER RESEARCH TO FIND COUNTLESS SIMILAR CASES. THE DAMAGE IS MOST OFTEN CHARACTERIZED BY CHARRED DISCOLORATION OF THE BROWN (GROUND) INSULATOR AND MELTING OF THE SURROUNDING PLASTICS WHICH RESULTS IN THE METAL CONNECTORS BECOMING LOOSE. THE REPAIR OF THE PROBLEM WOULD MOST LIKELY CONSIST OF AN UPGRADED REPLACEMENT OF THE WIRING HARNESS. FURTHER WORK INTO THE ELECTRICAL DISTRIBUTION SYSTEM MAY BE NECESSARY DEPENDING ON THE CAUSE OF THE FAULTY GROUND. *TR

NHTSA ID

10199408

Incident

Aug 10, 2007

Mileage

73,000 mi

MY 2003 BMW 330I HAS 85K MILES AND IS IN VERY GOOD CONDITION. RECENTLY, HOWEVER, A "SERVICE ENGINE SOON" LIGHT CAME ON. THE DEALER DIAGNOSED A PROBLEM AND INFORMED ME THAT I NEEDED A NEW TORQUE CONVERTER BECAUSE THE GASKET WAS LEAKING, HOWEVER, THE CAR WAS DRIVING JUST FINE. THEY TOLD ME THAT IF I DIDN'T REPLACE IT NOW THEN DOWN THE ROAD THE WHOLE TRANSMISSION MIGHT FAIL AND NEED REPLACEMENT. I FEEL RIPPED OFF HAVING PAID $3,000 FOR A TORQUE CONVERTER ON A CAR THAT DROVE FINE. AN INDEPENDENT MECHANIC TOLD ME THAT IT'S A COMMON PROBLEM THAT BMW IS AWARE OF, BUT THE COMPANY REFUSED TO HELP OUT WITH THE COST, STATING THAT THERE WERE TOO MANY MILES ON MY CAR. THE LIFE OF THE TRANSMISSION IS SUPPOSED TO BE WAY LONGER THAN 85K MILES. TOO BAD, BMW SAID. *JB

NHTSA ID

10198210

Incident

Jul 17, 2007

Mileage

85,000 mi

MY 2003 BMW 325I WAS INVOLVED IN AN ACCIDENT. THE DRIVER OF MY BMW REAR ENDED ANOTHER VEHICLE AT APPROX. 35 MPH. THERE WAS EXTENSIVE DAMAGE TO MY BMW. IN FACT, THE INSURANCE CO. IS CONSIDERING A TOTAL LOSS AS WE SPEAK. THE AMOUNT OF DAMAGE TO THE FRONT END EXCEEDS $18,000.00 TO INCLUDE SOME STRUCTURAL DAMAGE. MY COMPLAINT IS THAT NEITHER THE FRONT AIR BAGS OR THE SEAT RESTRAINT SYSTEM DEPLOYED. THE FOLKS AT THE REPAIR SHOP AND THE INSURANCE ADJUSTOR CANNOT UNDERSTAND WHY. I BROUGHT MY COMPLAINT TO BMW OF NORTH AMERICA AND THEY SENT AN ENGINEER TO EXAMINE THE DAMAGE. HE FILED A REPORT WITH BMW AND THEY CALLED TO SAY "THE IMPACT DID NOT WARRANT DEPLOYMENT OF THE SAFETY SYSTEM". I STRONGLY QUESTION THIS DETERMINATION GIVEN THE AMOUNT OF DAMAGE TO THE VEHICLE. FURTHER, MY WIFE, THE DRIVER OF THE VEHICLE, SUSTAINED SOME INJURY , AND IS SEEKING TREATMENT AT THIS TIME. PLEASE HELP ME! IF THEY DETERMINE THE VEHICLE TO BE A TOTAL LOSS, THERE WILL NOT BE MUCH TIME TO HAVE AN INSPECTION OF THE VEHICLE. *JB

NHTSA ID

10188850

Incident

Mar 10, 2007

When using the Key Reader to retrieve information from the customer’s key, the data is not updated or current.

Moisture is visible on the inside of one or both headlights

BMW: PROCEDURE FOR DETERMINING AND REPLACING INCANDESCENT AND HALOGEN LIGHT BULBS UNDER WARRANTY. *RM

BMW VEHICLES: FUEL LEVEL SENSOR REPAIRS. WHERE IT IS NECESSARY TO REPLACE THE RIGHT OR THE LEFT SIDE FUEL LEVEL SENSOR DUE TO A FAILURE, THE ENTIRE PUMP AND HOUSING OR DELIVERY UNIT (SUCTION JET ASSEMBLY) DO NOT NEED TO BE REPLACED AS WELL. IN SOME CASES, EPC DOES NOT SHOW THAT THE REPAIR KIT IS AVAILABLE SEPARATELY IN THE ILLUSTRATION, BUT IT IS AVAILABLE IN THE PARTS DESCRIPTION. ALL MODELS. NO MODEL YEARS LISTED. *PE