Recalls, owner-reported complaints, investigations and safety data
Data refreshed
Our database contains 6 NHTSA owner-reported complaints for the 2009 BMW G 650 Gs US, most frequently naming the engine, brakes and driver assistance categories. 10 manufacturer communications are on file.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
When owners filed reports about this model year
| Month | Complaints filed | Cumulative |
|---|---|---|
| Sep 2009 | 1 | 1 |
| May 2010 | 1 | 2 |
| Aug 2010 | 2 | 4 |
| Sep 2011 | 1 | 5 |
| Apr 2015 | 1 | 6 |
Complaints grouped by the component NHTSA recorded
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
No recalls in our database for this model year
That does not guarantee a specific vehicle is unaffected — recalls are issued against VINs, and new campaigns are announced regularly. Check a VIN on NHTSA.gov.
Reports submitted to NHTSA, shown in the owner's own words
ENGINE FREQUENTLY STALLS AT IDLE, INCLUDING WHEN SLOWING FROM HIGHWAY SPEEDS. SOMETIMES IT STALLS BETWEEN GEARS IF NOT SHIFTING FAST ENOUGH, CREATING A DANGEROUS ENGINE OFF SCENARIO ON A HIGHWAY. DEALER COULD NOT FIND A PROBLEM. IT SEEMS TO BE A PERSISTENT PROBLEM WITH OWNERS OF THIS MOTORCYCLE. *TR
MY MOTORCYCLE WILL START AND RUN FOR A WHILE BUT WILL RANDOMLY SHUT OFF WHEN THE ENGINE GETS DOWN TO IDLE. THIS PROBLEM IS NOT PERSISTENT AND SEEMS TO HAPPEN ONE DAY, BE FINE FOR A FEW DAYS, AND THEN ARISE AGAIN. WHEN THE BIKE IS RUNNING AND I 'M UP AT SPEED IT RUNS FLAWLESSLY, BUT EVERY NOW AND THEN THE BIKE DOESN'T WANT TO IDLE AND IT WILL DIE WHEN I COME TO A STOP OR IF I KEEP IN THE CLUTCH TOO LONG AND THE RPM DROPS TOO LOW. THERE HAVE BEEN SOME INSTANCES WHERE I'VE COME TO A STOP, NEEDED TO GO ABRUPTLY, AND WASN'T ABLE TO BECAUSE MY BIKE HAD JUST DIED, CREATING A POTENTIALLY HAZARDOUS SITUATION FOR ME SINCE I WAS NOT ABLE TO GET OUT OF THE WAY OF DANGER. *TR
TL* THE CONTACT OWNS A 2009 BMW G 650 GS US MOTORCYCLE. THE CONTACT WAS BRAKING FROM 5-10 MPH AND THE REAR FOOT BRAKE FAILED. THE VEHICLE WOULD NOT RESPOND AND THE CONTACT HAD TO UTILIZE THE EMERGENCY HAND BRAKE TO STOP THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER TWICE PRIOR TO THE FAILURE AND THE REAR BRAKE MASTER CYLINDER WAS REPLACED EACH TIME. THE FAILURE MILEAGE WAS 5,078.
MY 2009 BMW G650GS MOTORCYCLE HAS 1346 MILES ON IT. THIS AFTERNOON I WENT OUT FOR A RIDE AND FORTUNATELY I CUT THE RIDE SHORT BECAUSE AS I ROUNDED THE CORNER FOR MY HOME I SMELLED GASOLINE. AS I PULLED UP IN THE DRIVEWAY GAS WAS POURING DOWN THE SIDE OF THE BIKE. MY HUSBAND TOOK THE SEAT OFF AND LIFTED THE COVER TO THE FUEL PUMP AND GAS WAS POURING OUT OF THE FUEL PUMP HOSE. TURNS OUT THE CLAMP ON THE FUEL PUMP HOSE HAD NEVER BEEN CRIMPED AND EVENTUALLY THE HOSE HAD WORKED ITS WAY LOOSE. I LUCKED OUT BECAUSE I COULD HAVE GONE DOWN IN A BLAZE OF GLORY. BMW NEEDS TO ADD THIS TO THEIR SAFETY CHECK LIST. *TR
TL* THE CONTACT OWNS A 2009 BMW G650 GS US MOTORCYCLE. THE CONTACT STATED WHEN DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD STALL WITHOUT WARNING. ONCE THE VEHICLE WAS RESTARTED, IT WOULD NOT IDLE. THE DEALER ADVISED THAT THE FAILURE WAS DUE TO ETHANOL IN THE FUEL SYSTEM AND THERE WERE NO RECALLS FOR THE FAILURE. THERE WERE NO REPAIRS MADE TO THE VEHICLE. THE CONTACT CONFIRMED THAT THE VEHICLE HAS STALLED AT LEAST 40 TIMES. THE FAILURE MILEAGE WAS 200 AND THE CURRENT MILEAGE WAS 5300.
APPROXIMATELY 5 MINUTES OF DRIVING 30 MPH, THEN 5 MINUTES OF 45 MPH. THROTTLE WENT UNCONTROLLABLY TO FULL. ENGAGED CLUTCH, MOTOR RPM INCREASED VERY HIGH. DISENGAGED CLUTCH, ATTEMPTED THROTTLE CHANGE WITH NO EFFECT. PRESSED KILL SWITCH, COASTED TO STOP. MOTOR THEN FAILED TO START. BROUGHT VEHICLE INTO SERVICE. FIX WAS: "USED GT1 TO RESET ALL ADAPTATION VALUES". *TR
A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.
ELECTRICAL SYSTEM
The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle âÂÂdischarged batteryâ complaints.
ELECTRICAL SYSTEM; EQUIPMENT; EQUIPMENT ADAPTIVE/MOBILITY
Discharged Battery Energy Diagnosis Must Be Performed: The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle "discharged battery" complaints. In order to properly repair the vehicle the first time in the workshop, it is very important that the diagnostic test plans are performed to completion, with all results taken into consideration. Without performing the energy diagnosis test plan, the root cause of the discharged battery cannot be identified. This increases the chances of a repeat repair.
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)
BMW: CRANKCASE PRESSURE DIAGNOSIS AND INFORMATION FOR ALL VEHICLES. *RM UPDATED ON 4/24/2013. *KB
WHEELS:RIM
BMW: THE SPROCKET CARRIER OF THE REAR WHEEL COULD HAVE A DEGREE OF RUN OUT DUE TO ECCENTRICITY OF THE BORE IN THE WHEEL HUB. THIS CAN CAUSE THE SPROCKET CARRIER BEING INSTALLED UNDER TENSION WHICH CAN PRODUCE IRREGULARITY IN CHAIN ACTION OR LEAD TO ACCELERATED WEAR OF THE REAR-WHEEL BEARING. IT CAN ALSO CAUSE GRINDING NOISES WHEN THE MOTORCYCLE IS BEING RIDDEN OR PUSHED. G 650 GS. *RM
STRUCTURE:FRAME AND MEMBERS
BMW: THE FRONT TANK BAG BRACKET CANNOT BE INSTALLED ON SOME FRAMES DUE TO THE THREADED POSTS THAT HAVE BEEN WELDED TOO FAR APART ON THE FRAME. G 650 GS. *RM
EXTERIOR LIGHTING
BMW: PROCEDURE FOR DETERMINING AND REPLACING INCANDESCENT AND HALOGEN LIGHT BULBS UNDER WARRANTY. *RM
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.