RoadVitals

2007 BMW G650X Challenge Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Data refreshed

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
4
Newest Mar 11, 2008
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0

Recall campaigns

4 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

08V111000

SUSPENSION:REAR

Mar 11, 2008
744 units potentially affected
The defect: BMW IS RECALLING 744 MY 2007 G650X CHALLENGER AND COUNTRY MOTORCYCLES. THE MOTORCYCLES MAY HAVE HAD THE WRONG CIRCULAR CLIP INSTALLED ON THE LEFT HAND SIDE OF THE REAR WHEEL BEARING GUIDE. THIS CIRCLIP CAN RUB AGAINST A SPACER BUSHING, CREATING METAL SHAVINGS WHICH MAY ENTER THE WHEEL BEARING, CAUSING IT TO FAIL AND THE ANTILOCK BRAKE SYSTEM (ABS) MAY MALFUNCTION. THIS WOULD BE INDICATED BY ILLUMINATION OF THE ABS WARNING LAMP.
The risk: IF THIS HAPPENED, THE BRAKES WOULD REMAIN FULLY AVAILABLE TO SLOW AND STOP THE MOTORCYCLE. DEPENDING ON TRAFFIC AND ROAD CONDITIONS AS WELL AS A RIDER'S REACTIONS, COULD INCREASE THE RISK OF A CRASH.
The remedy: DEALERS WILL CHECK AND INSTALL A CORRECT CIRCLIP, ALONG WITH A NEW SPACER BUSHING, WHEEL BEARINGS, AND SHAFT SEALING RINGS FREE OF CHARGE. THE RECALL BEGAN DURING APRIL 2008. OWNERS MAY CONTACT BMW AT 1-800-831-1117.
BMW OF NORTH AMERICA, LLCView on NHTSA.gov
08V106000

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

Mar 11, 2008
1,391 units potentially affected
The defect: BMW IS RECALLING 1,391 MY 2007 G650X CHALLENGE, COUNTRY, AND MOTO MOTORCYCLES. THE FUEL LINES MAY HAVE BEEN DAMAGED DURING PRODUCTION, AND COULD DEVELOP A LEAK. THE LEAK COULD OCCUR EITHER THROUGH THE FABRIC INLAY AT THE END OF THE LINE, OR, THROUGH A CRACK IN THE ACTUAL LINE.
The risk: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
The remedy: DEALERS WILL INSPECT AND REPLACE THE FUEL LINES FREE OF CHARGE. THE RECALL BEGAN DURING APRIL 2008. OWNERS MAY CONTACT BMW AT 1-800-831-1117.
BMW OF NORTH AMERICA, LLCView on NHTSA.gov
07V376000

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Aug 22, 2007
764 units potentially affected
The defect: ON CERTAIN MOTORCYCLES, THE FUEL PUMP WIRING SET HAS NOT BEEN MANUFACTURED ACCORDING TO SPECIFICATION. THE CONTACTS IN THE PLUG FOR THE FUEL PUMP CAN BREAK.
The risk: THE FUEL PUMP WILL FAIL AND FUEL DELIVERY TO THE ENGINE WOULD CEASE CAUSING THE ENGINE TO STALL INCREASING THE RISK OF A CRASH.
The remedy: DEALERS WILL REPLACE THE FUEL PUMP UNIT WIRING SET FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 1, 2007. OWNERS MAY CONTACT BMW AT 1-800-831-1117.
BMW OF NORTH AMERICA, LLCView on NHTSA.gov
07V367000

ENGINE AND ENGINE COOLING:ENGINE

Aug 15, 2007
173 units potentially affected
The defect: ON CERTAIN MOTORCYCLES, A LEFT-SIDE CHAIN TENSIONER HAS BEEN INCORRECTLY INSTALLED ON THE RIGHT SIDE. AS A RESULT, A HEX NUT, WHICH IS USED TO SECURE THE CHAIN TENSIONER, IS IMPROPERLY SEATED AGAINST THE TENSIONER.
The risk: LOOSENING OF THE CHAIN TENSIONER AND THE REAR WHEEL AXLE MAY OCCUR. THIS COULD LEAD TO A CONDITION IN WHICH THE MOTORCYCLE IS UNSTABLE, INCREASING THE RISK OF A CRASH.
The remedy: DEALERS WILL INSTALL A NEW RIGHT SIDE CHAIN TENSIONER FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 13, 2007. OWNERS MAY CONTACT BMW AT 1-800-831-1117.
BMW OF NORTH AMERICA, LLCView on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .