2011 BMW R 1200 RT

This vehicle was subject to a recall under bulletin 16 0114. The issue was a fuel pump which cracked at flanges which leaked fuel onto the hot engine, which could cause safety issues with fire. My vehicle listed above, had the fuel pump replaced with 12,505 miles on it under the recall. The replacement fuel pump, which is apparently no better than the original that was replaced under recall, cracked again leaking fuel onto the hot motorcycle engine. This happened with 20,300 miles on the vehicle, which is less than 8000 miles later. BMW is refusing to replace under the recall or a warranty the fuel pump which means I am stuck with the bill. I believe that BMW should be replacing a defective part with a new design and better part not an old design faulty part. I would encourage you to issue another recall on the vehicles in question under bulletin 160114 in the interest of motorist safety.

NHTSA ID

11681917

Incident

Aug 20, 2025

The contact owns a 2011 BMW R1200 RT Motorcycle. The contact stated that while starting the motorcycle, fuel was spraying from the fuel line. There were no warning lights illuminated. The contact called the local dealer but the motorcycle was not diagnosed or repaired. The contact related the failure to NHTSA Campaign Number: 20V471000 (Fuel System, Gasoline) however, the VIN was not included. The manufacturer was contacted but no additional assistance was provided. The approximate failure mileage was 37,528.

NHTSA ID

11485901

Incident

Sep 1, 2022

Mileage

37,528 mi

Development of a major fuel leak after starting motorcycle, leak is coming from the high pressure fitting on the fuel pump. Very dangerous as the fuel is dripping on the hot exhaust and pooling on top of the fuel pump. Risk of fire and possibility of fuel getting on pant leg and burning riders leg. I talked to a couple dealers in the Phoenix area and it’s more common than not.

NHTSA ID

11483260

Incident

Sep 5, 2022

The contact owns a 2011 BMW R 1200 RT. The contact received notification of NHTSA Campaign Number: 20V471000 (Fuel System, Gasoline). The dealer was contacted and informed that the parts were not available. The contact called back the same dealer on two separate occasions and was informed that parts were still unavailable. The manufacturer was notified of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ID

11430640

Incident

Dec 1, 2020

The contact owns a 2011 BMW R 1200 RT Motorcycle. The contact stated that fuel was leaking from motorcycle. There were no warning lights illuminated. The contact received notification of NHTSA campaign number: 20V471000 (Fuel System. Gasoline) however, the part to do the recall repair was unavailable. The contact called the local dealer who stated that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified however, no further assistance was provided. The failure mileage was approximately 17,000. Parts distribution disconnect.

NHTSA ID

11428477

Incident

Jun 15, 2021

Mileage

17,000 mi

The contact owns a 2011 BMW R 1200 RT. The contact received notification of NHTSA campaign number: 20V471000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The contact took the vehicle to the local dealer and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ID

11427749

Incident

May 1, 2021

THROTTLE CABLE BELL CRANKS/CAMS CRACK DUE TO POOR QUALITY PLASTIC MATERIAL. THIS CAUSES MOTORCYCLE TO SUDDENLY LOSE POWER AS THE HAND THROTTLE NO LONGER WORKS AND ENGINE RETURNS TO IDLE RPM. THIS IS A SERIOUS SAFETY HAZARD AS FAILURE CAN OCCUR WHILE ENTERING TRAFFIC, TURNING THRU TRAFFIC, OR TRAVELING ON A HIGH SPEED ROADWAY WITH NO AREA TO PULL OFF. THESE CRACKS, (AND IMPENDING FAILURE OF THE PARTS), WERE DISCOVERED BY SERVICE PERSONNEL DURING SERVICE WORK.

NHTSA ID

11408223

Incident

Apr 15, 2021

Mileage

23,494 mi

TENGO PROBLEMAS CON EL FUEL PUMP LIQUEA MUCHO Y TAMBIEN CON EL ENCENDIDO LOS CALIPERS SE ATORAN

NHTSA ID

11355042

Incident

Aug 30, 2020

Mileage

37,000 mi

The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle “discharged battery” complaints.

Since October 2023, a new maintenance schedule is valid for all K5x models. For the first time, maintenance positions for the cardan shaft (Driveshaft) are included. NOTICE: 1. The new maintenance schedule is not limited to vehicles affected by the SI 33 02 22 (SERVICE ACTION: Swingarm Drain retrofit and Driveshaft Check), but is valid for all K5x models - including retroactively. In case of retroactive validity (model year 2023 and older), affected customers will be informed about the change. This will be in the form of a direct-to-customer letter with a description of the new maintenance schedule, specific owner’s manual insert, and consumer warranty book insert. 1. For vehicles affected by SI 33 02 22 (SERVICE ACTION: Swingarm Drain retrofit and Driveshaft Check), this service action must be performed first. All conditions described in this bulletin apply after the open Service Action has been completed. No additional communication is required for K5x models model year 2024 and onwards. Those models have the new maintenance schedule in their owner’s manual.

BMW Motorrad USA has become aware of a potential durability issue with the film type fuel level sender “Fuel Strip” equipped on certain model year 2005 to 2013 R and K series motorcycles.

Multiple factors may cause the driveshaft to become damaged; among them are corrosion in certain parts ofthe driveshaft, and wear and tear exacerbated by certain climatic conditions.

BMW Motorrad is aware of a number of cases in which the screw connections of the Paralever link and/or the rear brake caliper have loosened in customer vehicles while driving.

Multiple factors may cause the driveshaft to become damaged; among them are corrosion in certain parts of the driveshaft, and wear and tear exacerbated by certain climatic conditions.