2013 BMW X1 Sav

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

In a letter dated September 26, 2013, BMW Group submitted a safety recall notice to NHTSA identifying a defect condition in the vacuum pump oil supply that may result in loss of power assist braking in 76,191 model year (MY) 2012 through 2014 BMW 3-Series, 5-Series, X1 SAV, X3 SAV, and Z4 vehicles equipped with 4-cylinder engines (NHTSA Recall 13V-454).According to BMW, movement of the seal disk within the camshaft may result in blocking of the oil supply to the vacuum pump, resulting in improper pump operation and loss of power assist braking.On July 11, 2013, BMW initiated a change to the camshaft geometry that prevented the seal disk from blocking the oil port.BMW has not received any braking complaints related to loss of power assist after the design change was implemented in production.The owners of all affected vehicles will be contacted by mail and asked to take their vehicle to a BMW dealer who will install a locking ring into the camshaft to keep the seal disk in its proper location.BMW expects to begin dealer and owner notification in November 2013 and complete dealer and owner notification in December when the remedy is expected to be available.Based on the actions taken by BMW, this investigation is closed.

2 MONTHS AFTER REPORTING A DEAD/DRAINED BATTERY, IT HAS HAPPENED AGAIN. THE ALARM STARTS WHINING AND THEN THE CAR NEEDS TO BE JUMPED BECAUSE THE BATTERY IS DEAD. CAR WAS STATIONARY WHEN OCCURRED, AND IS DRIVEN DAILY DURING THE SCHOOL YEAR, BUT CAN SIT FOR A FEW DAYS DURING SCHOOL BREAKS.

NHTSA ID

11291377

Incident

Dec 26, 2019

Mileage

100,800 mi

STRONG ELECTRICAL BURNING SMELL FROM VENTS THE SMELL DOES NOT GO AWAY WHEN RECIRCULATING THE AIR AND I SUSPECT IT IS NOT COMING FROM OUTSIDE OF THE ENGINE BAY B. THIS ISSUE IS VERY SIMILAR TO THE SYMPTOMS DOCUMENTED IN SAFETY RECALL 17V-676 ' BLOWER MOTOR WIRING ' 2006-2011 BMW 3 SERIES

NHTSA ID

11281998

Incident

Nov 23, 2019

Mileage

111,000 mi

BOUGHT THE CAR FROM A DEALER WITH A NEW BATTERY. BATTERY DIED 5 DAYS LATER FOR NO APPARENT REASON. NOTHING WORKED ON CAR. HAD TO JUMP IT. WAS TOLD BY MECHANIC TO BUY A DIFFERENT BATTERY. THAT NEW BATTERY DIED 6 DAYS LATER. NOTHING WORKED ON CAR. HAD TO JUMP IT. APPARENTLY FROM MY RESEARCH, THIS MODEL HAS AN ISSUE WITH THE NEGATIVE BATTERY TERMINAL CABLE AND ALSO WITH PARASITIC COMPONENTS CONSTANTLY DRAINING THE BATTERY. IT SHOULDN'T COST ME $$$ TO HAVE A MECHANIC DIAGNOSE AND RE-PROGRAM CAR COMPUTER, AS WELL AS PURCHASE NEW BATTERIES.

NHTSA ID

11278972

Incident

Oct 9, 2019

Mileage

100,000 mi

PASSENGER AIR BAG LIGHT COMING ON AND OFF AND SEATBELT LIGHT ALWAYS ON WHILE DRIVING TWO DAYS AFTER RECALL FOR DRIVER AIRBAG WAS DONE THIS ISSUE STARTED. THE DEALERSHIP PERSON TOLD ME THAT I HAD TO WAIT UNTIL THE LIGHTS ARE STEADY TO FIX THE PROBLEM , SOMETHING ABOUT A SENSOR OR WEIGHT MAT.

NHTSA ID

11228667

Incident

Jun 1, 2017

MY GOT HIT ON THE DRIVE SIDE DOOR BREAKING THE SIDE VIEW MIRROR. TOOK THE CAR TO THE BODY SHOP AND I WENT TO PICK UP MY CAR, THE CAR DIDN'T START AS IF NO ELECTRICAL POWER, NO POWER AT ALL, THEY JUMP START MY CAR AND I BROUGHT THE CAR HOME, THE NEXT DAY NO ELECTRICAL POWER AGAIN, I CALLED THE SHOP WHERE I GOT MY DENT FIXED AND TOOK THE CAR THEY SAID THEY REPLACE THE BATTERY AND BROUGHT THE CAR BACK TO ME THE NEXT THE DIDN'T START AGAIN NO ELECTRICAL POWER THEY TOOK CAR AGAIN TO SEE WHAT IS WRONG THEY SAID THEY COULDN'T FIGURE OUT WHAT IS WRONG WITH MY CAR, SO THEY TOOK THE BMW DEALER, UNTIL NOW I DON'T HAVE MY CAR. I AM PUZZLED AND WONDERING IF MY CAR WILL EVER FIX.

NHTSA ID

11208947

Incident

May 10, 2019

Mileage

74,300 mi

THE BRAKES WILL NOT HOLD ON WET STREETS. THEY ALSO WILL NOT HOLD ON SNOW COVERED STREETS. YOU HAVE TO PUMP THEM WHEN YOU TRY TO HOLD THEM DOWN .SOMETIMES WHEN YOU HOLD THEM DOWN THEY LOCK IN PLACE. A FAILURE OF THE BRAKE VACUUM PUMP RESULTS IN THE REDUCED BRAKING POWER THAT COUL INCREASE THE RISK OF A CRASH.. THE AIRBAG DEPLOYMENT: IN THE EVENT OF A CRASH CAUSING DEPLOYMENT OF THE DRIVERS FRONTAL AIR BAG, THE INFLATOR COULD RUPTURE WITH METAL FRAGMENTS STRIKING THE DRIVER OR OTHER OCCUPANTS RESULTING IN SERIOUS INJURY OR DEATH.

NHTSA ID

11206641

Incident

Jan 8, 2018

Mileage

43,000 mi

WAS DRIVING ON HIGHWAY 65MPH CAR LOSS POWER CHECK ENGINE LIGHT.MOTOR RADDLE,HAD RAPID DECLARATION LOSS ALL POWER ALMOST GOT HIT FROM REAREND WAS ABLE TO PULL OFF HIGHWAY I WAS IN SLOW LANE.JUST PURCHASED THIS CAR . .CHECK ENGINE LIGHT SAID SAFE TO DRIVE.TOOK BACK TO A CAR DEALER.CAR HAD TURBO MALFUNCTION WASTE GATE ACTUATOR.THIS IS PROBLEM THAT NEEDS TO BE CHECK

NHTSA ID

11192758

Incident

Mar 23, 2019

Mileage

69,900 mi

'TRANSMISSION FAILURE' WARNING ERROR OCCURS WHEN AUTO STOP START (ASS) MODE ENABLED CAUSING TRANSMISSION TO FAIL ; CAR REQUIRES RESTART WHICH IS EXTREMELY HAZARDOUS IN NORMAL DRIVING CONDITIONS. BMW APPEARS UNCERTAIN OF HOW TO RESOLVE ISSUE. 53K MILES WITH ALL REQUIRED SERVICE COMPLETED ON VEHICLE TO-DATE. CAR WILL OPERATE AND TRANSMISSION WILL SHIFT NORMALLY AND ERROR WILL CLEAR AFTER RESTARTING, BUT SAME ERROR OCCURS.

NHTSA ID

11185537

Incident

Mar 8, 2019

Mileage

53,000 mi

The Footwell Module (FRM) limited warranty for defects in materials and / or workmanship has been supplementarily increased to 15 years / 186,000 miles as determined from the original first in-service / delivery date.

The Footwell Module (FRM) limited warranty for defects in materials and / or workmanship has been supplementarily increased to 15 years / 186,000 miles as determined from the original first in-service / delivery date.

The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle “discharged battery” complaints.

For the above-referenced vehicles, BMW of North America, LLC (BMW NA) is extending the limited warranty for the engine timing chain and oil pump drive chain modules to: 7 years/70,000 miles as determined by the vehicle's original in-service date.

BMW of North America, LLC (BMW NA) is extending the limited warranty for the engine timing chain and oil pump drive chain modules to: 7 years/70,000 miles as determined by the vehicle's original in-service date

With the court's FINAL approval, BMW of North America, LLC (BMW NA) has entered into a nationwide settlement with the plaintiffs in the following class action: Gelis, et al. v. Bayerische Motoren Werke Aktiengesellschaft and BMW of North America, LLC.