2015 BMW X1 Sav

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

TL* THE CONTACT OWNS A 2015 BMW X1 SAV. WHILE THE VEHICLE WAS STOPPED, IT INDEPENDENTLY SHIFTED INTO NEUTRAL WITHOUT WARNING. AFTER THE FAILURE OCCURRED, A WARNING MESSAGE APPEARED INDICATING THAT THE VEHICLE NEEDED TO BE SERVICED. THE CONTACT TOOK THE VEHICLE TO UNITED BMW (1501 ALPHARETTA HWY, ALPHARETTA, GA 30009, (678) 430-3775), BUT THE FAILURE COULD NOT BE DIAGNOSED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 65,500.

NHTSA ID

11270208

Incident

Oct 18, 2019

Mileage

65,500 mi

TL* THE CONTACT OWNS A 2015 BMW X1. THE CONTACT STATED THAT WHILE IDLED AT A RED LIGHT, THE VEHICLE WAS REAR ENDED CAUSING THE VEHICLE TO CRASH INTO ANOTHER VEHICLE. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED: (190801030). THE CONTACT SUSTAINED HEAD, NECK AND CHEST INJURIES AND THE PASSENGER THAT WAS A CHILD SUSTAINED A HEAD INJURY THAT NEEDED MEDICAL ATTENTION. THE CONTACT WAS UNAWARE FOR THE OTHER DRIVERS THAT HAD INJURIES. THE VEHICLE WAS TOWED TO THE CONTACTS RESIDENCE. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED 4 MONTHS AGO UNDER NHTSA CAMPAIGN NUMBER: 16V071000 ( AIR BAGS). THE APPROXIMATE FAILURE MILEAGE WAS 72,000.

NHTSA ID

11241303

Incident

Aug 1, 2019

Mileage

72,000 mi

DRIVING ON HWY AT 75 MPH EASTBOUND TOWARDS WICHITA FALLS TX - CALM EVENING, SUDDENLY THE FRONT PANEL OF THE SUNROOF ON THE BMW X1 EXPLODED FOR NO APPARENT REASON. PULLED OVER TO LOOK AT THE REMNANTS, REMAINING GLASS LOOKED LIKE THE EXPLOSION WAS PUSHING THE GLASS OUT FROM THE INSIDE. VERY SCARY ON THE HWY.

NHTSA ID

11230559

Incident

Jul 8, 2019

Mileage

350 mi

MY TIRES ARE WORN OUT PAST ACCEPTABLE TO PASS STATE INSPECTION AND YET THE DEALER INSPECTED MY CAR AND PASSED IT AND REGISTERED IT. CHASSIS CORRODED AND WHEELS ROTTING. I BOUGHT THE CAR ON THE 14TYH AND DEALER DIDN'T DELIVER IT UNTIL THE 21ST BECAUSE OF APPARENT MISSING TITLE. THE CAR NEEDED SERVICE AND AIR FILTER AND DURING THE SERVICE, THE OTHER (BMW) DEALER FOUND THE ISSUES ATTACHED. I HAVE DOCUMENTATION LISTING A 90 LIMITED WARRANTY AND WAS WONDERING IF THE PURCHASE DEALER OWES ME TO FIX SOME OF THOSE ITEMS, PARTICULARLY TIRES THAT ARE BEYOND SAFE. I ALMOST SKID AND HIT ANOTHER CAR TODAY ON THE HIGHWAY DUE TO THE POOR STATE OF THE TIRES....

NHTSA ID

11228690

Incident

Jun 28, 2019

Mileage

42,600 mi

ON MARCH 29, 2019 I TOOK MY CAR IN DUE TO A COOLANT INDICATOR WARNING LIGHT. NALLEY BMW INDICATED IT WAS DUE TO A NEED FOR A RADIATOR. THIS IS THE FOURTH RADIATOR NALLEY BMW AND GLOBAL BMW HAVE REPLACED WITH THE LAST TWO YEARS. I HAVE PAID OUT OF POCKET FOR REPAIRS ASSOCIATED WITH THE FOUR REPLACEMENTS OF A RADIATOR IN UNDER TWO YEARS. THEY WILL REPAIR THE RADIATOR AND ALLOW DELIVERY OF THE VEHICLE BACK TO ME. I WILL DRIVE ABOUT 500 MORE MILES BEFORE THE COOLANT LIGHT COMES BACK ON INDICATING TROUBLE. EACH TIME, THE COOLANT LIGHT COMES ON, THE RADIATOR HAS HAD TO BE REPLACED. THIS HAPPENS AT ALL TIMES. MARCH 29TH WOULD MAKE THE FOURTH TIME THE RADIATOR HAS BEEN REPLACED IN UNDER TWO YEARS.

NHTSA ID

11194065

Incident

Mar 29, 2019

Mileage

145,000 mi

VEHICLE COULD NOT STOP GOING DOWNHILL AND CRASHED INTO 2 PARKED CARS BEFORE OVERTURNING; FELT LOSS OF BRAKE PRESSURE.

NHTSA ID

11185460

Incident

Mar 8, 2019

Mileage

71,000 mi

TL* THE CONTACT OWNS A 2015 BMW X1. WHILE DRIVING APPROXIMATELY 52 MPH ON A SLIGHT INCLINE, THE INSTRUMENT PANEL ILLUMINATED. THE CONTACT NOTICED DARK SMOKE UNDERNEATH THE HOOD. THE VEHICLE WAS PULLED OVER TO THE SIDE OF THE ROAD AND THE CONTACT EXITED THE VEHICLE. THE CONTACT WAS IMMEDIATELY ALERTED BY SOMEONE THAT THE VEHICLE WAS ON FIRE. THE FIRE WAS EXTINGUISHED BY THE RAIN. A FIRE REPORT WAS NOT FILED. THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO BRAMAN BMW JUPITER (561-609-0144, LOCATED AT 1555 W INDIANTOWN RD, JUPITER, FL 33458) WHERE THE CONTACT WAS ASSIGNED A TECHNICIAN TO OVERSEE AN INVESTIGATION. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ORDERED AN INVESTIGATION. THE CONTACT DID NOT STATE IF THE VEHICLE WAS TOTALED; HOWEVER, THE MANUFACTURER OFFERED TO BUY BACK THE VEHICLE. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 47,800.

NHTSA ID

11180384

Incident

Oct 8, 2018

Mileage

47,800 mi

2015 BMW X1. CONSUMER WRITES IN REGARDS TO VEHICLE CUTTING OFF WHILE DRIVING. *LD *JS

NHTSA ID

11061709

Incident

Nov 2, 2017

The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle “discharged battery” complaints.

For the above-referenced vehicles, BMW of North America, LLC (BMW NA) is extending the limited warranty for the engine timing chain and oil pump drive chain modules to: 7 years/70,000 miles as determined by the vehicle's original in-service date.

BMW of North America, LLC (BMW NA) is extending the limited warranty for the engine timing chain and oil pump drive chain modules to: 7 years/70,000 miles as determined by the vehicle's original in-service date

With the court's FINAL approval, BMW of North America, LLC (BMW NA) has entered into a nationwide settlement with the plaintiffs in the following class action: Gelis, et al. v. Bayerische Motoren Werke Aktiengesellschaft and BMW of North America, LLC.

BMW of North America, LLC BMW NA is extending the limited warranty for the engine timing chain and oil pump drive chain modules to: 7 years/70,000 miles as determined by the vehicle's original in-service date

With the court's FINAL approval, BMW of North America, LLC (BMW NA) has entered into a nationwide settlement with the plaintiffs in the following class action: Gelis, et al. v. Bayerische Motoren Werke Aktiengesellschaft and BMW of North America, LLC.