2010 BMW X5 Problems

The contact owns a 2010 BMW X5. The contact stated that while driving at an undisclosed speed, the vehicle stalled and was pulled over to the side of the road. There was no warning light illuminated. The vehicle was towed to be repaired under NHTSA Campaign Number: 23V707000 (Engine and Engine Cooling); however, after the recall repair was performed, the vehicle failed to start. The contact stated that the recall repair indicated that a diagnostic test was required to determine that an engine failure was a direct result of a fractured VANOS bolt. The contact stated that the dealer declined a diagnostic test or the repair. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 135,000.

My husband and I brought our 2010 X5 (VIN ), mileage: to BMW of El Cajon on 09/29/2025 for a recall service. Before the recall repaire, the vehicale was in normal working condition: -No check engine lights or warning indicators -No unusual noises -Fully drivable on a daily basis After the recall was completed, the dealership informed me that: -multiple check engine/warning lights appeared -The vehicle developed a very loud/high pitch noise -They do not recommend driving the vehicle in its currently condition. They did not warn us about his initial, they did after informed them we do not feel safe driving the car in this condition. The dealership explained this happened because they had open a valve to perform the recall, which they claim disturbed "sludge". They are now refusing to correct the problem unless we pay out of pocket. The issue did not exist before the recall and occurred only as a direct result of the recall repair. The recall left my car unsafe and undriveable, and I am being told to pay for a problem that only arose due to a federally mandated recall work. The recall resulted in a vehicle that is no longer safe to drive, with multiple warning lights and severe engine noise. The dealers refusal to fix this without charing me undermines the purpose of a recall, which is to ensure safety at no cost to the owner. I ask NHTSA to investigate this matter and ensure BMW and its dealerships perform recall repairs properly, at no cost to consumers, and do not return vehicles in unsafe conditions.

Front passenger seat occupancy mat (OC3) problem safety code. Supplemental Restraint System (SRS/AIR BAG SYSTEM) I contacted BMW OF NORTH AMERICA and they stated my 2010 BMW X5 is to old, one way to look at it. I requested assistance and BMW will not help out. I am the original owner and MY VEHICLE is garage kept. This air bag will not deploy and the passenger could be killed and or injured in a accident.

SRS failure on the passenger front seat air bag. BMW has many safety issues with the Code OC3. Passenger seat occupancy mat failure, seat pad requires replacement at a cost of $2,000 BMW is aware and is tone deaf to this safety defect. BMW should care about people possible dying from the airbag failure to deploy.

My husband and I brought our 2010 X5 (VIN ), mileage: to BMW of El Cajon on 09/29/2025 for a recall service. Before the recall repaire, the vehicale was in normal working condition: -No check engine lights or warning indicators -No unusual noises -Fully drivable on a daily basis After the recall was completed, the dealership informed me that: -multiple check engine/warning lights appeared -The vehicle developed a very loud/high pitch noise -They do not recommend driving the vehicle in its currently condition. They did not warn us about his initial, they did after informed them we do not feel safe driving the car in this condition. The dealership explained this happened because they had open a valve to perform the recall, which they claim disturbed "sludge". They are now refusing to correct the problem unless we pay out of pocket. The issue did not exist before the recall and occurred only as a direct result of the recall repair. The recall left my car unsafe and undriveable, and I am being told to pay for a problem that only arose due to a federally mandated recall work. The recall resulted in a vehicle that is no longer safe to drive, with multiple warning lights and severe engine noise. The dealers refusal to fix this without charing me undermines the purpose of a recall, which is to ensure safety at no cost to the owner. I ask NHTSA to investigate this matter and ensure BMW and its dealerships perform recall repairs properly, at no cost to consumers, and do not return vehicles in unsafe conditions.

The contact owns a 2010 BMW X5. The contact stated while starting the vehicle, after several minutes the vehicle failed to turn off as needed. There was no warning lights illuminated. The vehicle was towed to an independent mechanic where it was diagnosed that metal shavings were found in the engine, and the oxygen heat sensor had failed. The vehicle was repaired. The contact advised the previous owner was notified of NHTSA Campaign Number: 16V746000 (FUEL SYSTEM, GASOLINE). The contact was not aware of the recall notification. The contact stated that the prior owner had the recall repair performed; however, the failure occurred. The manufacturer was not notified of the failure. The failure mileage was 127,911.

My husband and I brought our 2010 X5 (VIN ), mileage: to BMW of El Cajon on 09/29/2025 for a recall service. Before the recall repaire, the vehicale was in normal working condition: -No check engine lights or warning indicators -No unusual noises -Fully drivable on a daily basis After the recall was completed, the dealership informed me that: -multiple check engine/warning lights appeared -The vehicle developed a very loud/high pitch noise -They do not recommend driving the vehicle in its currently condition. They did not warn us about his initial, they did after informed them we do not feel safe driving the car in this condition. The dealership explained this happened because they had open a valve to perform the recall, which they claim disturbed "sludge". They are now refusing to correct the problem unless we pay out of pocket. The issue did not exist before the recall and occurred only as a direct result of the recall repair. The recall left my car unsafe and undriveable, and I am being told to pay for a problem that only arose due to a federally mandated recall work. The recall resulted in a vehicle that is no longer safe to drive, with multiple warning lights and severe engine noise. The dealers refusal to fix this without charing me undermines the purpose of a recall, which is to ensure safety at no cost to the owner. I ask NHTSA to investigate this matter and ensure BMW and its dealerships perform recall repairs properly, at no cost to consumers, and do not return vehicles in unsafe conditions.

The contact owns a 2010 BMW X5. The contact stated that while the vehicle was parked, her nephew attempted to start the vehicle, and the vehicle failed to start. The contact stated there was an abnormal odor coming from the vehicle. The check engine warning light was illuminated. The contact replaced the battery; however, the vehicle failed to restart. The vehicle was towed to Firestone, where it was diagnosed that the starter and fuel pump had failed and needed to be replaced. The vehicle was not yet repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 116,546.

IN FEB 2016 DURING DRIVING ON THE HIGHWAY, LOST POWER STEERING AND BATTERY LIGHT COME ON. CAR WAS TOWED TO THE GARAGE TO DETERMINATE CAUSE AND FIX THE PROBLEM. BOLT THAT HOLD PULLEY TENSIONER WAS BROKEN AND BELT FELL OFF. THERE WAS NO EASY WAY TO REMOVE BRONEK HEAD BOLT OFF FROM ENGINE BLOCK. CAR WAS AT MECHANIC FOR A WEEK, REPLACEMENT BOLT WAS AROUND $6 BUT THE LABOR WAS ALMOST $700.

THE ENGINE BELT IDLER PULLEY BOLT BROKE CAUSING A SUDDEN LOSS OF POWER STEERING WHEN THE SERPENTINE BELT CAME OFF THE ALTERNATOR AND POWER STEERING PUMP. THIS IS THE SAME PROBLEM ASSOCIATED WITH RECALL 12V550000 A FEW YEARS AGO. THE DEALER SAID THE VEHICLE WAS FIXED UNDER THE RECALL BUT IT WAS BEFORE I OWNED IT SO I DON'T KNOW FOR SURE. I BELIEVE THE RECALL SHOULD BE REINSTATED. THE VEHICLE WAS MOVING ON A RESIDENTIAL STREET AT LESS THAN 25 MPH AND MY MOM WAS DRIVING. IF SHE HAD BEEN GOING ANY FASTER SHE WOULD HAVE CRASHED.

I own a 2010 BMW X5 xDrive30i (VIN: [XXX] ) with two active recalls: the VANOS bolt recall (23V-707) and the PCV valve heater recall (22V-119). Despite these being federally mandated safety repairs, Sharpe BMW in Grand Rapids, MI refused to perform the work without a paid diagnostic and potential full repair payment upfront, stating reimbursement would be decided afterward. I was sent home in an unsafe, recalled vehicle that visibly and audibly shakes at startup and frequently stalls. Other engine components have now failed due to the VANOS issue and the vehicle is now inoperable. BMW NA has acknowledged contact, but has only redirected me back to the same dealer without offering resolution. This has created financial hardship and an ongoing safety concern. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

AS I WAS DRIVING ON A BRIDGE MY CAR COMPLETELY WENT INTO A STOP. BREAKS INSTANTLY LOCKED AND MY CAR WOULD NOT DRIVE, TURN ON, OR GO ON NEUTRAL THE BREAKS STAYED IN LOCK. POLICE OFFERUP EVEN TRIED TO SEE IF IT'S A SIMPLE BREAK BUTTON. NOTHING WORKED I WAS IN THE MIDDLE OF A BRIDGE LUCKY THE CAR BEHIND ME SWERVED RIGHT AWAY AND MYSELF AND MY DAUGHTER WERE SAFE. I CALLED MY SISTER WHO LIVED DOWN THE STREET, SHE CAME RIGHT AWAY AND PARKED BEHIND ME WITH HER EMERGENCY SAFETY LIGHTS ON. THE CAR WENT INTO SHOCK I COULDN'T EVEN PUT IT IN NEUTRAL SO I CAN MOVE IT FROM THE MIDDLE OF THE BRIDGE. TOWED IT TO BMW NOW THEY SAY IT'S THE COMPUTER SYSTEM AND THE WIRES OF THE CAR THAT CONNECTS TO THE COMPUTER. COST TO FIX IS OVER 3,500 I CAN NOT AFFORD TO FIX. I HAVE 4 TEENAGE KIDS AND NOW NO CAR BECAUSE I CANNOT AFFORD TO PAY FOR THE CAR SERVICES. IN THE PAST 3 YEARS I HAVE PAID OVER 8K IN REPAIRS BY BMW DEALERSHIP SERVICES. THIS IS NOT FAIR

FRONT PASSENGER SEAT MAT SENSOR FAULTY LEAVING THE FRONT PASSENGER WITHOUT AIRBAG PROTECTION. I'LL INSTALL A BYPASS DEVICE BECAUSE THEY ARE COMMON AND INEXPENSIVE AND AVAILABLE BECAUSE SO MANY BMWS HAVE THIS ISSUE. THE BYPASS DEVICE WILL ALLOW THE PASSENGER AIRBAGS TO DEPLOY WHETHER A PASSENGER IS IN THE SEAT OR NOT. THE YEARS 2006 AND 2007 SAW RECALL ON THE PASSENGER SEAT SENSOR. THIS NEEDS TO BE ADDRESSED.

TL* THE CONTACT OWNS A 2010 BMW X5. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT AND PASSENGER RESTRAINT SYSTEM INDICATORS WERE ILLUMINATED ON THE INSTRUMENT PANEL. THE DEALER WAS NOTIFIED OF THE FAILURE. THE CONTACT STATED THAT THE VEHICLE WAS NOT INCLUDED IN A RECALL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 36,000.

Headlight wiring loom insulation on both passenger and driver sides degrading heavily to the point of disintegration on touch. My driver side headlights have stopped working despite best attempts at isolating wires. I have received multiple headlight(low/DRL) warnings and errors because of this issue. It has been verified by countless independent mechanics and hobbyists on this generation of car with no aftermarket or OE solutions. I have since almost collided with objects in the road while driving at night due to this faulty manufacturing. I also fear for an electrical fire which is bound to happen due to exposed wiring. This has been happening for a few months with no improvement and further degradation. I have not had it inspected by BMW.

MAY 10, 2017 WE PURCHASED A 2010 BMW X5 WITH APPROX 70KMILES FROM EAST PROVIDENCE AUTO FOR $16,000. TWO DAYS LATER WE BROUGHT THE VEHICLE BACK BECAUSE THE WINDSHIELD WIPER FLUID LEAKED ONTO THE DRIVER SIDE FLOOR, THE SUNROOF WOULDN'T CLOSE AND A BURNING OIL SMELL WAS COMING FROM THE INSIDE OF THE VEHICLE. AFTER INSPECTING, THE MECHANIC SAID THE HOSE FROM THE WINDSHIELD WIPER TANK WAS NEEDED REPLACEMENT, HE UNJAMMED THE SUNROOF AND ADDED 2 QUARTS OF OIL; HOWEVER, HE COULDN'T FIX ANYTHING. MAY 22 WE RETURNED B/C THE OIL LIGHT WAS ON AND THE BURNING OIL SMELL STILL EXISTED. BUT THE GARAGE WAS LOCKED. THE SALESMAN SAID WE WOULD HAVE TO COME BACK. MAY 24 WE RETURNED AFTER BLUE SMOKE WAS COMING FROM THE EXHAUST. THE MECHANIC SAID THE OWNER WAS IN PORTUGAL FOR TWO WEEKS AND HE COULDN'T WORK ON THE VEHICLE WITHOUT PERMISSION. AFTER RETURNING AND CALLING MANY TIMES OVER THE NEXT MONTH WE MET WITH THE OWNER WHO SAID HIS MECHANIC LEFT, WE WOULD HAVE TO WAIT. JULY 3 WE HAD THE VEHICLE INDEPENDENTLY INSPECTED (SEE ATTACHED REPORT). HE INSPECTED THE ENGINE AND DRAINED THE OIL. HE RECOMMENDED THE ENGINE BE REMOVED FOR FURTHER DIAGNOSIS AND IF NOT RESOLVED THE ENGINE WILL EVENTUALLY NEED TO BE REPLACED. AFTER RETURNING TO EP AUTO THE OWNER SAID THE 30 DAY WARRANTY WAS UP SO WE FILED A COMPLAINT WITH THE RHODE ISLAND DEALERS LICENSE AND REGULATIONS OFFICE (COMPLAINT NUMBER AM-1702213). WE ARE AWAITING A RESPONSE FROM THE HEARING BOARD. THE CASE MANAGER ADVISED THAT IT'S IMPOSSIBLE TO FORCE EP AUTO TO TAKE THE VEHICLE BACK BECAUSE WE HAVE TO PROVE THE ISSUES ARE PRE-EXISTING AND SHE IS ANTICIPATING THE HEARING BOARD WILL NOT RULE IN OUR FAVOR. AT THIS POINT WE ARE EXTREMELY RELUCTANT TO DRIVE THE VEHICLE DUE TO THE SAFETY CONCERNS. I RECENTLY RECEIVED A RECALL NOTICE FROM YOU ALLEGING DEFECTIVE AIRBAGS MADE BY TAKATA. PLEASE FEEL FREE TO CONTACT ME. THANK YOU FOR YOUR HELP.

Sunroof drains - front and back overflow and drone down the pillars into the front and rear electronic boxes. A KNOW PROBLEM for this BMW. I want BMW to repair and fix this problem. Water damaged control boxes are thousands of dollars. This problem should be a recall! BMW was sued in 2018 and settled the case. I am unable to file a claim for this now. I recently moved from Southern CA to New Orleans LA. There is a lot mor torrential rain here. Never had a problem in Southern CA.

PASSENGER DOOR GOT LOCKED - UNABLE TO OPEN. DELER HAD TO TAKE DOOR OUT TO FIX. THIS MAJOR SAFETY ISSUE WITH VERY EXPENSIVE REPAIR FROM BMW DEALER. GOT ENGINE LIGHT FOR DIESEL FUEL TANK SENSOR. BMW TOLD ME TO TAKE TWO MONTH TO GET PART FROM GERMANY. WAITING FOR PART AND HIGH REPAIR BILL. AGAIN GOT ENGINE LIGHT FOR OTHER REASON. I AM COM EARN ABOUT SAFEST OF MY 2010 BMW X5 DIESEL MODEL AND LIKE HELP FROM NHTSA. THANKS.

AS I WAS DRIVING ON A BRIDGE MY CAR COMPLETELY WENT INTO A STOP. BREAKS INSTANTLY LOCKED AND MY CAR WOULD NOT DRIVE, TURN ON, OR GO ON NEUTRAL THE BREAKS STAYED IN LOCK. POLICE OFFERUP EVEN TRIED TO SEE IF IT'S A SIMPLE BREAK BUTTON. NOTHING WORKED I WAS IN THE MIDDLE OF A BRIDGE LUCKY THE CAR BEHIND ME SWERVED RIGHT AWAY AND MYSELF AND MY DAUGHTER WERE SAFE. I CALLED MY SISTER WHO LIVED DOWN THE STREET, SHE CAME RIGHT AWAY AND PARKED BEHIND ME WITH HER EMERGENCY SAFETY LIGHTS ON. THE CAR WENT INTO SHOCK I COULDN'T EVEN PUT IT IN NEUTRAL SO I CAN MOVE IT FROM THE MIDDLE OF THE BRIDGE. TOWED IT TO BMW NOW THEY SAY IT'S THE COMPUTER SYSTEM AND THE WIRES OF THE CAR THAT CONNECTS TO THE COMPUTER. COST TO FIX IS OVER 3,500 I CAN NOT AFFORD TO FIX. I HAVE 4 TEENAGE KIDS AND NOW NO CAR BECAUSE I CANNOT AFFORD TO PAY FOR THE CAR SERVICES. IN THE PAST 3 YEARS I HAVE PAID OVER 8K IN REPAIRS BY BMW DEALERSHIP SERVICES. THIS IS NOT FAIR

MAY 10, 2017 WE PURCHASED A 2010 BMW X5 WITH APPROX 70KMILES FROM EAST PROVIDENCE AUTO FOR $16,000. TWO DAYS LATER WE BROUGHT THE VEHICLE BACK BECAUSE THE WINDSHIELD WIPER FLUID LEAKED ONTO THE DRIVER SIDE FLOOR, THE SUNROOF WOULDN'T CLOSE AND A BURNING OIL SMELL WAS COMING FROM THE INSIDE OF THE VEHICLE. AFTER INSPECTING, THE MECHANIC SAID THE HOSE FROM THE WINDSHIELD WIPER TANK WAS NEEDED REPLACEMENT, HE UNJAMMED THE SUNROOF AND ADDED 2 QUARTS OF OIL; HOWEVER, HE COULDN'T FIX ANYTHING. MAY 22 WE RETURNED B/C THE OIL LIGHT WAS ON AND THE BURNING OIL SMELL STILL EXISTED. BUT THE GARAGE WAS LOCKED. THE SALESMAN SAID WE WOULD HAVE TO COME BACK. MAY 24 WE RETURNED AFTER BLUE SMOKE WAS COMING FROM THE EXHAUST. THE MECHANIC SAID THE OWNER WAS IN PORTUGAL FOR TWO WEEKS AND HE COULDN'T WORK ON THE VEHICLE WITHOUT PERMISSION. AFTER RETURNING AND CALLING MANY TIMES OVER THE NEXT MONTH WE MET WITH THE OWNER WHO SAID HIS MECHANIC LEFT, WE WOULD HAVE TO WAIT. JULY 3 WE HAD THE VEHICLE INDEPENDENTLY INSPECTED (SEE ATTACHED REPORT). HE INSPECTED THE ENGINE AND DRAINED THE OIL. HE RECOMMENDED THE ENGINE BE REMOVED FOR FURTHER DIAGNOSIS AND IF NOT RESOLVED THE ENGINE WILL EVENTUALLY NEED TO BE REPLACED. AFTER RETURNING TO EP AUTO THE OWNER SAID THE 30 DAY WARRANTY WAS UP SO WE FILED A COMPLAINT WITH THE RHODE ISLAND DEALERS LICENSE AND REGULATIONS OFFICE (COMPLAINT NUMBER AM-1702213). WE ARE AWAITING A RESPONSE FROM THE HEARING BOARD. THE CASE MANAGER ADVISED THAT IT'S IMPOSSIBLE TO FORCE EP AUTO TO TAKE THE VEHICLE BACK BECAUSE WE HAVE TO PROVE THE ISSUES ARE PRE-EXISTING AND SHE IS ANTICIPATING THE HEARING BOARD WILL NOT RULE IN OUR FAVOR. AT THIS POINT WE ARE EXTREMELY RELUCTANT TO DRIVE THE VEHICLE DUE TO THE SAFETY CONCERNS. I RECENTLY RECEIVED A RECALL NOTICE FROM YOU ALLEGING DEFECTIVE AIRBAGS MADE BY TAKATA. PLEASE FEEL FREE TO CONTACT ME. THANK YOU FOR YOUR HELP.

Sunroof drains - front and back overflow and drone down the pillars into the front and rear electronic boxes. A KNOW PROBLEM for this BMW. I want BMW to repair and fix this problem. Water damaged control boxes are thousands of dollars. This problem should be a recall! BMW was sued in 2018 and settled the case. I am unable to file a claim for this now. I recently moved from Southern CA to New Orleans LA. There is a lot mor torrential rain here. Never had a problem in Southern CA.

AFTER CHANGING THE BATTERY, THE VEHICLE HAS NO OPERATING DASH LIGHTS, GAUGE INDICATIONS, TURN SIGNALS, OR BRIGHT LIGHTS. ADDITIONALLY, THE WINDSHIELD WIPER CONTINUOUSLY SWIPES, BUT HAS NO ABILITY TO SPRAY WASHER FLUID OR CHANGE THE SPEED OF THE SWIPE. THESE CONDITIONS RENDER IT DIFFICULT TO DRIVE AND SEE THROUGH THE WINDSHIELD, ESPECIALLY AT NIGHT, AND PREVENTS THE OPERATOR FROM MONITORING THE VEHICLE, IDENTIFYING ONES SPEED, OR SIGNALING A TURN. MOREOVER, THE CONTINUOUS WINDSHIELD WIPER ACTION IMPAIRS ONE'S ABILITY TO SEE AND IS ALSO DISTRACTING; MAKING IT DANGEROUS TO DRIVE THE VEHICLE. *TR

Headlight wiring loom insulation on both passenger and driver sides degrading heavily to the point of disintegration on touch. My driver side headlights have stopped working despite best attempts at isolating wires. I have received multiple headlight(low/DRL) warnings and errors because of this issue. It has been verified by countless independent mechanics and hobbyists on this generation of car with no aftermarket or OE solutions. I have since almost collided with objects in the road while driving at night due to this faulty manufacturing. I also fear for an electrical fire which is bound to happen due to exposed wiring. This has been happening for a few months with no improvement and further degradation. I have not had it inspected by BMW.

AFTER CHANGING THE BATTERY, THE VEHICLE HAS NO OPERATING DASH LIGHTS, GAUGE INDICATIONS, TURN SIGNALS, OR BRIGHT LIGHTS. ADDITIONALLY, THE WINDSHIELD WIPER CONTINUOUSLY SWIPES, BUT HAS NO ABILITY TO SPRAY WASHER FLUID OR CHANGE THE SPEED OF THE SWIPE. THESE CONDITIONS RENDER IT DIFFICULT TO DRIVE AND SEE THROUGH THE WINDSHIELD, ESPECIALLY AT NIGHT, AND PREVENTS THE OPERATOR FROM MONITORING THE VEHICLE, IDENTIFYING ONES SPEED, OR SIGNALING A TURN. MOREOVER, THE CONTINUOUS WINDSHIELD WIPER ACTION IMPAIRS ONE'S ABILITY TO SEE AND IS ALSO DISTRACTING; MAKING IT DANGEROUS TO DRIVE THE VEHICLE. *TR

Front passenger seat occupancy mat (OC3) problem safety code. Supplemental Restraint System (SRS/AIR BAG SYSTEM) I contacted BMW OF NORTH AMERICA and they stated my 2010 BMW X5 is to old, one way to look at it. I requested assistance and BMW will not help out. I am the original owner and MY VEHICLE is garage kept. This air bag will not deploy and the passenger could be killed and or injured in a accident.

FRONT PASSENGER SEAT MAT SENSOR FAULTY LEAVING THE FRONT PASSENGER WITHOUT AIRBAG PROTECTION. I'LL INSTALL A BYPASS DEVICE BECAUSE THEY ARE COMMON AND INEXPENSIVE AND AVAILABLE BECAUSE SO MANY BMWS HAVE THIS ISSUE. THE BYPASS DEVICE WILL ALLOW THE PASSENGER AIRBAGS TO DEPLOY WHETHER A PASSENGER IS IN THE SEAT OR NOT. THE YEARS 2006 AND 2007 SAW RECALL ON THE PASSENGER SEAT SENSOR. THIS NEEDS TO BE ADDRESSED.

Bridgestone Dueler 255/50R19 107H runflat, DOT EJVUDJE2013 Tire failure: local tread separation in a valley between road contact ridges. Tread separation from underlying belts suggest manufacturing defect. No human life was in danger due to early detection of the fault