RoadVitals

1997 BMW Z3

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
47
Latest Mar 24, 2023
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
2
Latest Mar 23, 2006
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
6
6 injuries, 0 deaths reported

Overview

Our database contains 47 NHTSA owner-reported complaints for the 1997 BMW Z3, most frequently naming the airbags, interior & seats and seat belts categories. 2 safety recalls have been issued covering this model year; and 13 manufacturer communications are on file.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

2 campaigns cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
06E026000

EXTERIOR LIGHTING

Mar 23, 2006
61,944 units potentially affected
The defect: CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
The risk: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
The remedy: PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
PRO-A MOTORS, INC.View on NHTSA.gov
97V131000

VEHICLE SPEED CONTROL

Aug 19, 1997
410,000 units potentially affected
The defect: THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL WITHOUT CRUISE CONTROL BEING ENGAGED, THE OUTER TUBE COULD CATCH ON THE EDGE OF THE BROKEN BUSHING.
The risk: THIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.
The remedy: DEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.
BAYERISCHE MOTOREN WERKEView on NHTSA.gov

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

View all 47
Airbags
Filed Mar 24, 2023
Crash reported1 injury reported

The contact owned a 1997 BMW Z3 Roadster. The contact stated that while driving at approximately 40 MPH, there was a multi-car rear-end accident involving two other vehicles after she fell asleep at the wheel and rear-ended the vehicle in front of her. The contact stated that no other passengers were in her vehicle; however, only the driver's side air bag had failed to deploy. The contact required hospitalization and was in a coma. A police report was filed. The vehicle was towed to a tow yard and later auctioned. The manufacturer was made aware of the failure and confirmed the VIN was not included in an air bag recall. The approximate failure mileage was 199,000. The VIN was not available.

NHTSA ID
11513678
Incident
Feb 14, 2017
Mileage
199,000 mi
Suspension
Filed Jan 23, 2017

VEHICLE JERKS, SHUTTERS AND PULLS TO THE RIGHT. REAR SUB FRAME AND DIFFERENTIAL BUSHING FAILURE.

NHTSA ID
10946920
Incident
Jan 19, 2017
Mileage
199,000 mi
Interior & seats
Filed Feb 4, 2014

THE SEAT TRACKS OF BOTH THE DRIVER AND PASSENGER SIDE OF THE VEHICLE ALLOWED THE SEATS TO MOVE AT LEAST 10MM FORWARD AND REARWARD UNDER BRAKING AND ACCELERATION. THIS MOVEMENT CAUSES A PARTIAL LOSS OF CONTROL OF THE VEHICLE. *TR

NHTSA ID
10562829
Incident
Oct 3, 2012
Mileage
130,000 mi
Airbags
Filed May 30, 2011

UPON STARTING THE CAR THE AIR BAG LIGHT CAME ON AND STAYED ON. THIS IS THE THIRD TIME THIS HAS HAPPENED. THE FIRST TWO TIME IT COST APPROXIMATELY $350 TO REPAIR. FOR THIS TO HAPPEN A THIRD TIME IS INDICATIVE OF A DESIGN FAULT.

NHTSA ID
10404652
Incident
May 26, 2011
Mileage
56,423 mi
Filed Dec 18, 2010
Fire reported

I TURNED THE KEY TO START THE VEHICLE. IT STARTED NORMALLY. I PUT THE CAR IN NEUTRAL (5 SPEED TRANS.) TO ALLOW IT TO WARM-UP FOR ABOUT 2 MINUTES WHILE I CHECKED MY VOICE MAIL ON MY PHONE. AS I PUT THE CAR IN GEAR AND LOOKED OUT THE WINDSHIELD TO PULL OUT OF MY PARKING SPACE, I SAW DENSE WHITE SMOKE ROLLING OUT FROM UNDER THE HOOD ON THE DRIVER'S SIDE. I LOOKED AT THE DASH FOR ANY WARNING OR INDICATOR LIGHTS; THERE WERE NONE. I IMMEDIATELY TURNED THE CAR OFF, POPPED THE HOOD, AND GOT OUT OF THE CAR. I WANTED TO WAIT UNTIL THE SMOKE WAS NO LONGER ROLLING OUT BEFORE ACTUALLY OPENING THE HOOD, AS I WAS AFRAID OF INTRODUCING A RUSH OF AIR IF SOMETHING WAS ON FIRE. AS THE SMOKE RAPIDLY INCREASED AND PROGRESSED TO BLACK SMOKE, I CALLED MY FACILITY SECURITY FROM AN EMERGENCY CALL BOX WHILE ALSO CALLING 911 FROM MY CELL PHONE. DURING THE 911 CALL, FLAMES BECAME VISIBLE FROM UNDER THE HOOD. FOUR FIRE ENGINES ARRIVED TO PUT OUT THE FIRE. ALL FOUR LEVELS OF MY FACILITIES PARKING DECK WERE FILLED WITH TOXIC SMOKE WHICH WAS EVACUATED BY THE FIRE DEPARTMENT. THE CAR WAS A TOTAL LOSS. THE FIRE DEPT. TOLD ME THAT NIGHT THAT THE CAR WAS TOO BADLY BURNED TO DETERMINE THE CAUSE. THEY SUPPOSED IT WAS ELECTRICAL. AFTER INSPECTING THE CAR, THE INSURANCE INVESTIGATOR DID NOT BELIEVE THE FIRE TO BE FROM ELECTRICAL ORIGIN, BUT INSTEAD FUEL / ENGINE RELATED. THE CAR HAD BEEN MAINTAINED ON A REGULAR BASIS. NO SERVICE HAD BEEN RECENTLY PERFORMED. I HAD NOT BEEN EXPERIENCING ANY ISSUES WITH THE CAR'S PERFORMANCE.

NHTSA ID
10371628
Incident
Nov 12, 2010
Mileage
110,000 mi
Seat belts
Filed Dec 3, 2010

MY 1997 BMW Z3 HAD THE AIRBAG LIGHT COME ON 2 YEARS AGO. THE TECHNICIAN SAID IT WAS CAUSED BY THE SEATBELT TENSIONER. HE REPLACED IT AND ALL WAS FINE. IT'S BACK ON AGAIN. IF THIS IS AS COMMON TO THESE MODELS AS I'VE HEARD WHY HASN'T BMW HAD A RECALL TO FIX THE PROBLEM. THIS IS GETTING EXPENSIVE. *TR

NHTSA ID
10369086
Incident
Dec 2, 2010
Mileage
131,000 mi
Airbags
Filed Aug 13, 2008

PASSENGER GOT INTO FRONT SEAT AND ADJUSTED IT DOWN AND BACK WITH THE POWER SEAT CONTROLS. AIRBAG LIGHT ILLUMINATED AND HAS BEEN ON EVER SINCE. I CHECKED FOR BROKEN OR DAMAGED WIRING BUT FOUND NOTHING OBVIOUS. BMW IS RECALLING MANY OF THEIR NEW CARS, BUT IT SEEMS THEIR OLD ONES EXHIBIT THE SAME FAILURES. *TR

NHTSA ID
10238068
Incident
Apr 1, 2008
Mileage
69,500 mi
Interior & seats
Filed Mar 24, 2008

SEAT RAILS DO NOT LOCK PROPERLY THEREBY ALLOWING SEAT(S) TO SLIDE FORWARD DURING BRAKING. CAN POTENTIALLY LEAD TO LOSS OF CONTROL OF VEHICLE. *TR

NHTSA ID
10222149
Incident
Feb 10, 2008
Mileage
88,000 mi

Manufacturer communications

A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.

SI B12 12 10

ENGINE AND ENGINE COOLING

BMW: WHEN AT LOWER SPEEDS OR STOPPING THE ENGINE IDLE DIPS TOO LOW BECAUSE OF A SOFTWARE PROBLEM. *RM

121099

ENGINE AND ENGINE COOLING:ENGINE

INFORMATION REGARDING VOLUNTARY EMISSION RECALL CAMPAIGN NO. 99E-A01. *TT

121299

ENGINE AND ENGINE COOLING:ENGINE

INFORMATION PERTAINING TO QUALITY MONITORING OF M44 / M62 CAMSHAFT SENSOR. *TT

16 01 98

FUEL SYSTEM, GASOLINE

INFORMATION ON EVAPORATIVE EMISSION CONTROL AND FUEL FILLER CAP / FILLER DOOR LABELS. *YC

51 09 97

LATCHES/LOCKS/LINKAGES:HOOD:LATCH

INSTALLATION OF HOOD LATCH GUIDE PLATE. *AK

12 15 96

VEHICLE SPEED CONTROL:CRUISE CONTROL

ROUGH IDLE

Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Compare model years

Complaint and recall counts across every year of this model

BMW Z3 by model year
YearComplaintsRecallsInvestigationsIssue Index
2004010—
2003210—
2002610—
2001191040.5
2000341055.6
1999393045.2
1998301043.5
1997Viewing472050.7
1996302051.0

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.