1996 Buick Riviera Fuel system Problems

I SMELLED GAS. I OPENED THE HOOD, REMOVED THE ENGINE COVER & FUEL WAS SPRAYING FROM THE PLASTIC FUEL LINE, THE SIZE OF A PINHOLE. I CONTACTED THE DEALER TO ORDER A NEW FUEL LINE AND WAS TOLD THE FUEL LINE PART #25648136 IS DISCONTINUED, AS SOON AS I FIND ONE LEFT SOMEWHERE, I WILL BE TAKING TO AN INDEPENDENT REPAIR SHOP FOR REPAIR. THERE ARE NO RECALLS LISTED ON THIS? A DANGEROUS SITUATION. I WENT INTO VARIOUS AUTO FORUMS ON THE INTERNET & NOTICED THAT SEVERAL OTHER PEOPLE WERE HAVING THE SAME PROBLEM. A PINHOLE LEAK IN THE PLASTIC FUEL LINE. THIS IS THE SECOND TIME I HAVE REPLACED THIS LINE IN THE 4 YEARS I HAVE OWNED THIS CAR WITH 60000 MILES BETWEEN THE LAST TIME THIS HAPPENED AND NOW. GM NEEDS TO OFFER A REDESIGNED REPLACEMENT PART THAT DOESN'T LEAK. *TR

NHTSA ID

10680980

Incident

Dec 22, 2010

Mileage

80,000 mi

TL* THE CONTACT OWNS A 1996 BUICK RIVIERA. THE CONTACT STATED THAT AFTER REFUELING THE VEHICLE, THERE WAS A STRONG GASOLINE ODOR. THE CONTACT NOTICED THAT THE FUEL TANK WAS FRACTURED FROM EXCESSIVE CORROSION CAUSING FUEL TO LEAK. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 68,000. UPDATED 8//1/14*CN THE CONSUMER STATED THE TANK WAS PLASTIC WITH A METAL RING BONDED TO THE TANK, WITH A METAL LOCK RING THAT HELD THE FUEL PUMP IN PLACE. BOTH METAL RINGS WERE COMPLETELY RUSTED, TO THE POINT THEY WERE CRUMBLING AND FLAKING. UPDATED 08/26/14

NHTSA ID

10594863

Incident

Nov 20, 2013

Mileage

68,000 mi

TL* THE CONTACT OWNS A 1996 BUICK RIVIERA. WHILE DRIVING APPROXIMATELY 45 MPH THE ENGINE STARTED HESITATING. HE PULLED OVER TO THE SIDE OF THE ROAD, AND NOTICED AN ENGINE COMPARTMENT FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FLAMES. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A SALVAGE CENTER. THE VEHICLE WAS COMPLETELY DESTROYED . THE CAUSE OF FAILURE HAS NOT BEEN DETERMINED AT THIS TIME. ALTHOUGH HE EXPERIENCED AN IDENTICAL FAILURE, HE VEHICLE IDENTIFICATION NUMBER WAS EXCLUDED FROM RECALL CAMPAIGN ID NUMBER 96V116000 (FUEL SYSTEM, GASOLINE:FUEL) . THE FAILURE AND CURRENT MILEAGES WERE 140,000.

NHTSA ID

10291539

Incident

Nov 9, 2009

Mileage

140,000 mi

WHILE DRIVING I NOTICED A SMELL OF GAS. I STOPPED & WAS AT A TRUCK STOP. I CHECKED UNDER THE GAS TANK VEHICLE & SPOTTED NO GAS DRIPPING FROM THE TANK. THEN I WENT AROUND TO FRONT OF THE VEHICLE & SAW NO GAS LEAKING. THEN SEVERAL DAYS LATER, I DROVE TO FRESNO, PARKED THE CAR & TOLD MY DAUGHTER THAT I SMELLED GAS. I OPENED THE HOOD, REMOVED THE ENGINE COVER & FUEL WAS SPRAYING FROM THE PLASTIC FUEL LINE, THE SIZE OF A PINHOLE. I PLACED SOME TAPE ON IT & DROVE IT HOME. I CONTACTED THE DEALER & ORDERED A NEW FUEL LINE. I WILL BE TAKING INTO THE BUICK DEALERSHIP FOR REPAIR. THERE ARE NO RECALLS LISTED ON THIS???? A DANGEROUS SITUATION. I WENT INTO VARIOUS AUTO FORUMS ON THE INTERNET & NOTICED THAT SEVERAL OTHER PEOPLE WERE HAVING THE SAME PROBLEM. A PINHOLE LEAK IN THE PLASTIC FUEL LINE. THIS BEING ON THE 1995 - 1999 BUICK RIVIERA'S ( 3.8 L ) V6. *TR

NHTSA ID

10232104

Incident

Jun 19, 2008

Mileage

132,550 mi

FUEL SMELL WHEN TANK IS FULL. REMOVED ACCESS COVER FOR FUEL PUMP MODULE FOUND WELL FOR MODULE FILLED WITH DIRT OVER TOP OF MODULE. CLEAN OUT DIRT FOUND METAL RING TO HOLD MODULE IN ROTTED OFF TANK THERE WAS NOTHING HOLDING FUEL PUMP MODULE IN TANK IF CAR ROLLED OVER. FUEL CAN RUN OUT LOOKS LIKE A BAD HAZARD. *TR

NHTSA ID

10230002

Incident

Jun 5, 2008

Mileage

120,000 mi

TL*THE CONTACT OWNS A 1996 BUICK RIVIERA. THE CONTACT IS EXPERIENCING A FUEL AND A WATER LEAK. THE DEALER STATED THAT THE FUEL INJECTOR NEEDED TO BE REPLACED. THE CURRENT AND FAILURE MILEAGES WERE 150,000. UPDATED 04-08-08 *BF

NHTSA ID

10220677

Incident

Mar 1, 2008

Mileage

131,451 mi

DT*: THE CONTACT STATED THERE WAS AN ODOR OF FUEL IN THE VEHICLE. THE CONTACT TOOK THE SHROUD OFF OF THE ENGINE AND DETERMINED THE PLASTIC FUEL LINE HAD A HOLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP, WHERE THE FUEL LINE WAS REPLACED WITH A HIGH PRESSURE HOSE. UPDATED 3/22/2006 - THE VEHICLE STALLED WHILE DRIVING AND THAT WHEN THE CONSUMER OPEN THE HOOD AND SAY THE MIST OF FUEL BEING SPRAYED ONTO THE HOT ENGINE. THE RUBBER FUEL LINE WAS REPLACED WITH A HIGH PRESSURE RUBBER LINE AT AND INDEPENDENT SHOP. *NM

NHTSA ID

10152100

Incident

Mar 3, 2006

Mileage

123,800 mi

TOP OF THE GAS TANK SPLIT, RESULTING IN A LARGE GAS SPILL, ALMOST CAUSING A FIRE. *AK

NHTSA ID

984515

Incident

May 10, 1996