2019 Chevrolet 6500 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2019 Chevrolet 6500, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Brakes150.0%
- Electrical150.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
The brake switch nearly burned the truck to the ground could smell the electrical burning, and the brake pressure failed due to a brake line failure Chevrolet says, the switch was covered in recall. But the say the brake lines arent covered. These same brake lines were recalled on Chevrolet commercial van chassis. This could have resulted in serious injury or death if it hadn't have failed at very low speeds. This is urgent an needs to be addressed. This vehicle has been in arkansas, not up north with salt on the roads. The brake lines shouldn't fail on a truck that's less than 4 years old.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
The brake switch nearly burned the truck to the ground could smell the electrical burning, and the brake pressure failed due to a brake line failure Chevrolet says, the switch was covered in recall. But the say the brake lines arent covered. These same brake lines were recalled on Chevrolet commercial van chassis. This could have resulted in serious injury or death if it hadn't have failed at very low speeds. This is urgent an needs to be addressed. This vehicle has been in arkansas, not up north with salt on the roads. The brake lines shouldn't fail on a truck that's less than 4 years old.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .