1999 Chevrolet Astro Brakes Problems

I HAVE 2- CHEVY ASTRO VANS. 1-1998, 1-1999. THE 1999 HAS CORRODED BRAKE LINES AND GAS LINES. THE MAIN BRAKE LINES ARE CORRODED INTO. I WAS COMING BACK FROM A LONG TRIP YESTERDAY AND I NOTICED THAT THE BRAKES WERE SOFT. WHEN I GOT HOME UPON INSPECTION I CHECKED THE BREAK FLUID AND IT WAS LOW. I FILLED IT. I NOTICED A PUDDLE OF FLUID BY THE BACK TIRE. AND LOOKED, I DISCOVERED ALL OF THE BRAKE AND GAS LINES WERE EAT UP WITH CORROSION. GM NEEDS TO TAKE THIS AS A VERY SERIOUS PROBLEM AND FIX IT IMMEDIATELY. I COULD HAVE BEEN KILLED , OR I COULD HAVE KILLED SOMEONE IF THE BRAKES FAILED TO HOLD. I INSPECTED THE 1998 ASTRO VAN TO SEE IF IT HAD A PROBLEM TO. AND UPON DOING SO DISCOVERED IT IS FINE, NO PROBLEMS. I HAVE PICS OF BOTH VANS THE PICS WILL SHOW THAT MY STATEMENT IS TRUE. I BOUGHT THE 1999 VAN (THE ONE WITH CORRODED LINES) IN THE STATE OF OHIO. AND I BOUGHT THE 1998 VAN IN ALABAMA.I DO NOT KNOW WHY THIS IS, BUT I KNOW I AM NOT THE ONLY ONE WITH A FAULTY GM PRODUCT WITH CORROSIVE BRAKE AND GAS LINES. I AM VERY THANKFUL I DISCOVERED THIS BEFORE TRAGEDY HAPPENED. THIS IS A POTENTIAL DEADLY PROBLEM, AND GM NEEDS TO RESOLVE THIS BEFORE SOMEONE LOOSES THEIR LIFE, NOT AFTER. ANY HELP WITH GETTING THIS RESOLVED IS GREATLY APPRECIATED! I JUST WANT TO LET UNSUSPECTING GM OWNERS KNOW ABOUT THIS DANGER! *TR

NHTSA ID

10609436

Incident

Jul 8, 2014

Mileage

200,000 mi

TL*THE CONTACT OWNS A 1999 CHEVROLET ASTRO. THE POWER STEERING PUMP FAILED WHILE DRIVING APPROXIMATELY 10 MPH. THE CONTACT APPLIED THE BRAKES, BUT NOTHING HAPPENED. HE THEN DEPRESSED THE BRAKE PEDAL ALL THE WAY TO THE FLOOR, BUT THE VEHICLE DID NOT STOP. THE VEHICLE CRASHED INTO HIS HOME. THE VEHICLE WAS TOWED TO A SHOP AND THE MECHANIC STATED THAT THERE WAS FAILURE WITHIN THE POWERTRAIN. HE FURTHER STATED THAT THE POWER STEERING AND POWER BRAKES WERE CONNECTED TO THE SAME UNIT, CAUSING BOTH TO FAIL SIMULTANEOUSLY. HE CALLED GM AND A REPRESENTATIVE FROM THE ENGINEERING DEPARTMENT STATED THAT THE BRAKES SHOULD HAVE WORKED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 75,000 AND CURRENT MILEAGE WAS 120,000.

NHTSA ID

10206772

Incident

May 1, 2006

Mileage

75,000 mi

COMMENTS: WHY DID EVERYONE MISS THE 1999 CHEVY ASTRO VAN WITH AWD? I ALREADY HAD THE FRONT WHEEL BEARINGS REPLACED (AT MY COST) EARLIER THIS YEAR FOR THE SAME PROBLEM!!! PARTS ARE NO LONGER AVAILABLE, BUT LOCAL FIRESTONE GARAGE PERFORMED THE MAINTENANCE, AND HAS THE RECORDS OF THE SERVICE. NEAR-MISS TOO MANY TIMES AT LOW SPEED STOPPING PROBLEMS. SOME ONE NEEDS TO INCLUDE THE CHEVY & GMC MINI-VANS!!! *JB

NHTSA ID

10134869

Incident

Dec 31, 2004

Mileage

89,000 mi

ABS BRAKING LIGHT APPEARED ON DASHBOARD AND REMAINED ON. WHILE APPLYING THE BRAKES PEDAL WENT TO THE FLOOR. CONSUMER LOST CONTROL OF VEHICLE AND STRUCK ANOTHER VEHICLE FROM BEHIND. UPON IMPACT, BOTH FRONTAL AIR BAGS DID NOT DEPLOY. NO INJURIES WERE REPORTED. VEHICLE WAS TOWED, AND TOTALED OUT BY THE INSURANCE COMPANY. *AK

NHTSA ID

10094329

Incident

Sep 24, 2004

AT 29,000 MILES THE FRONT BRAKE ROTORS, BEARINGS AND PADS HAD TO BE REPLACED. WHEN I COMPLAINED THAT THIS WAS LOW MILES FOR BRAKES TO FAIL, THE MANAGER SAID THE BRAKES GO OUT EARLY ON THIS MODEL BECAUSE THE BACK BRAKES WERE NOT SO GOOD SINCE THE SELF ADJUSTING WAS NOT RELIABLE. I WROTE TWICE TO GM ASKING FOR CLARIFICATION. I SPOKE TO THE MANAGER;S BOSS WHO SAID I WOULD REPLACE BRAKES EVERY 30,000 MILES BECAUSE THE BRAKES WERE LIGHT FOR THE VAN WEIGHT. NOW AT ABOUT 43,000 I AM AGAIN HAVING BRAKE PROBLEMS. SEEMS WRONG TO ME. ITEM 2 -AT 35,425 MILES I REPORTED WHEN THE VAN WAS IN FOR SERVICE THAT I PUSH THE GAS PEDAL DOWN AND THE VAN JUST DID NOT WANT TO GO. THEN IF YOU HELD THE PEDAL DOWN AFTER A BIT, THE VAN WOULD JUMP FORWARD BECAUSE IT SUDDENLY GOT GAS. THIS WAS BAD WHEN ANYTHING WAS AROUND CLOSE BECAUSE OF THE SUDDEN ACCELERATION. THE SHOP SAID THEY WOULD REPLACE A PART UNDER WARRANTY. I THINK IT WAS CALLED A THROTTLE BODY, BUT I AM NOT SURE. THEY REPALCED NOTHING. THEY CLEANED THE THROTTLEBODY PLATE. THE PROBLEM IS NOW MORE NOTICABLE. FROM DISCUSSION WITH OTHER PEOPLE, IT SEEMS THIS LACK OF GOING AS YOU PUT THE PEDAL DOWN, AND THEN THE SURGING AHEAD IS HAPPENING TO MANY PEOPLE. THIS COMES FROM AN INTERNET CAR PROBLEM CHAT SITE. *AK

NHTSA ID

765767

Incident

Mar 28, 2002

CONSUMER STATED ROTORS ON VEHICLE HAD WARPED. HAD REPAIRED. THE ROTORS WAS WARPED AGAIN. HAD TO HAVE REPAIRED THIS IS A CONTINOUS PROBLEM. NLM

NHTSA ID

8007868

WHILE DRIVING APPLIED ON BRAKES AND CONSUMER WAS NOT ABLE TO COME TO A STOP. MECHANIC HAS BEEN NOTIFIED.*AK

NHTSA ID

8005902

BRAKES HAVE BEEN SEVERLY WORN OUT*AK CONSUMER STATED THE SEATBELTS, ARM RESTS, CONSOLE THE TRIM ON THE SEAT CUSHION HAS TORN, THERE IS WIND NOISE FROM HIGH TOP ROOF, WINDOW IS LOOSE, RADIO IS INOPERATIVE, POWER STEERING FLUID LEAKING, STEERING COOLUMN IS MAKING A NOISE, WEATHERSTRIP COMING OFF OF BACK DOOR, TIRES SHAKE, THERE IS A HARD THUMP WHE GOING OVER BUMPS, CIGARETTE LIGHTER IS INOPERATIVE,TRANSMISSION SHIFTS HARD, PRESSURE GUAGE GETS STUCK, WINDOW GETS STUCK, THERE ARE NO LOW BEAM LIGHTS, WINDSHIELD WIPERS ARE INOPERATIVE, DOOR LOCK DO NOT COME ALL THE WAY UP, THE FRONT END OF VEHICLE DIPS, AND THE SHOCKS FEEL WEAK, THE LIFGATE DOES NOT STAY OPEN, INTERIOR LIGHTS STAY ON TO LONG, VEHICLE REMOTE IS INOPERATIVE, SLIDING DOOR IS HARD TO OPEN AT TIMES, OIL PRESSURE GUAGE READS HIGH, REFRIGERATOR NOT OPERATING FROM REAR SOCKET, HEATING SYSTEM IS INOPERATIVE, BATTERY GOES DEAD.*SLC

NHTSA ID

8002579

Incident

Oct 18, 1999

VEHICLE BEGAN TO LUNGE OR SURGE FOWARD, WHILE CONSUMERS FOOT WAS PRESSED DOWN ON THE BRAKE PEDAL, AT TIMES THE IDLE WOULD REACH A HIGH RPM THAT IT SEEMED AS IF VEHICLE WOULD GO OUT OF CONTROL.*JB

NHTSA ID

562392

IN EMERGENCY SITUATIONS WHEN CONSUMER HAS TO APPLY BRAKE HARD, PEDAL WILL GO TO FLOOR AND STAY THERE. BRAKING ACTION OKAY. *AK

NHTSA ID

886965

Incident

Jul 1, 2000

WHILE ATTEMPTING TO STOP THE CONSUMERS FOOT HIT BOTH THE BRAKE AND ACCELERATOR PEDAL CAUSING THE VEHICLE NOT TO STOP, CONSUMER BELIEVES THE BRAKE PEDAL AND ACCELERATOR ARE TOO CLOSE TOGETHER. NLM

NHTSA ID

558785

Incident

Dec 25, 2000

BRAKES PADS ARE WEARING EXCESSIVELY. FRONT BRAKES/ ROTORS & WHEEL BEARING WERE ALL REPLACED. CONSUMER RECEIVED A PHONE CALL FROM GMC. APPARENTLY, THEY KNOW OF PROBLEM, BUT NO RECALL WAS ISSUED. *AK SOMETHING IN THE BRAKE SYSTEM IS MALFUNCTIONING, ACCORDING TO THE CONSUMER. *YH

NHTSA ID

875912

Incident

Nov 1, 2000

DEFECTIVE DRIVER INBOARD PAD WORN METAL TO METAL WHICH CAUSED EXTENDED STOPPING DISTANCE, MAY RESULTING IN A CRASH. *AK THE OWNER INSPECTED THE VEHICLE AND DETERMINED THAT BRAKE SYSTEM FAILURE CAUSED EXTENDED STOPPING DISTANCE BUT THE DEALER DISAGREED. *YH

NHTSA ID

873835

Incident

Oct 24, 2000

INTERMITTENT FAILURE OF STEERING WHERE STEERING BINDS TURNING RIGHT OR LEFT. HAVE TO FORCE STEERING TO COMPLETE TURNS. BRAKES ALSO INTERMITTANTLY WILL GRAB HARD WHEN COMING TO A FAST, HARD STOP. HYDRAVAC UNIT HAS BEEN REPLACED. DEALER CHACKED POWER STEERING PUMP PRESSURE PER GM TECH SUPPORT. PLAN NOW IS TO REPLACE STEERING GEAR BOX. DON'T SEE HOW THIS COULD AFFECT BRAKES. POWER STEERING PUMP HAS HAD A HIGH PITCHED WHINE SINCE IT WAS NEW. DEALER AND GM DO NOT SEEM TO BE CONCERNED WITH THAT.

NHTSA ID

732768

Incident

Sep 25, 2000

IF PUTTING BRAKES ON QUICKLY THEY LOCK UP AND THEN THEY STOP. BRAKES WILL GRAB/DRIFT, THEN THEY STOP. WHEN CONSUMER STOPS SLOWLY THEY WORK FINE.*AK

NHTSA ID

868394

Incident

May 23, 1999

BOTH FRONT BRAKES ON THIS VEHICLE WORE EVENLY, PAPER THIN IN 8000 MILES - THIS IS ABNORMAL SINCE MY OLD ASTRO WENT MORE THAN20,000 MILES AND STILL HAD PLENTY LEFT WHEN I CHANGED THEM - BOTH WHEELS SPIN FREELY WITHOUT BINDING - MY BEST GUESS IS THAT THE BACK BRAKES MAY NOT BE GRABBING (OR THE FRONTS MAY BE GRABBING TOO HARD - CHEVROLET IS TRYING TO BLAME MY DRIVING - THIS IS VERY DANGEROUS SINCE IF THE LINING WEARS OFF IT WILL PULL TO THAT SIDE WHILE BRAKING AND POSSIBLY CAUSE A CRASH - I DO NOT RIDE MY BRAKES AND DO ALL HIGHWAY DRIVING - BRAKES ARE SUPPOSED TO LAST LONGER THAN 8000 MILES. *AK

NHTSA ID

724558

Incident

Nov 30, 1999

WHILE DRIVING 20-30 MPH AND UPON APPLYING THE BRAKES PEDAL WENT TO THE FLOORBOARD, RESULTING IN EXTENDED STOPPING DISTANCE. CONSUMER HAS CONTACTED DEALER. PLEASE PROVIDE ANY FURTHER DETAILS. *AK

NHTSA ID

863587

WHEN APPLYING THE ABS BRAKES ON WET PAVEMENT FRONT BRAKES LOCK UP, CAUSING EXTENDED STOPPING DISTANCE. CAUSE UNKNOWN. PLEASE GIVE ANY FURTHER DETAILS. *AK

NHTSA ID

856486

ABS FAILED. YH

NHTSA ID

549422

Incident

Oct 7, 1999

DEFECTS LISTED AS AWD AND TRANSFER CASE MAY BE SAME PROBLEM AND WERE EXPERIENCED FROM THE FIRST 300 MILES AND ON (UPON SLOWING DOWN OR ACCELERATING A "CLUNK" WAS HEARD AND FELT FROM THE FRONT END ALSO WHEN CORNERING THE VEHICLE "LURCHED/WHEELS GRABBED" LIKE IT WAS STUCK IN 4WD. IN JULY IMMEDIATLY AFTER IT HAD BEEN INTO THE DEALER TO BE SERVICED AGAIN THE BRAKES CAUSED THE VAN TO PULL LEFT AT 35-50 MPH AND WHEN SLOWED FOR CORNERS WOULD SOUND LIKE "LOOSE PARTS RUBBING TOGETHER". IN AUGUST OF 1999 (JUST BEFORE THE REPLACEMENT TRANSFER CASE CAME IN) VAN HIT LOOSE GRAVEL TRAVELING AT 45-50 MPH, PULLED ONTO SOFT SHOULDER, FORWARD ABOUT 12 FT, CAUGHT TRACTION AND CAME UP ON ROAD, FRONT LEFT WHEEL WAS OFF GROUND WHEN IT CAME DOWN THE TIRE POPPED OFF THE BEAD, WHEEL GROUND INTO PAVEMENT, FLIPPING VAN ON FRONT, LEFT SIDE/CORNER, THEN ONTO HOOD AND WINDSHIELD, THEN ONTO FULL RIGHT SIDE THEN UPRIGHT CROSSWAYS IN LANE IT HAD BEEN TRAVELING IN. THE VAN WAS TOTALED.

NHTSA ID

712607

Incident

Aug 20, 1999

DURING A MODERATE BRAKING THE VEHICLE WILL PULL TO THE LEFT SIDE. IT IS VERY DANGEROUS DUE TO YOU HAVE TO HOLD THE STEERING WHEEL WHILE BRAKING TO KEEP FROM PULLING INTO ONCOMING TRAFFIC.

NHTSA ID

710527

Incident

Jul 5, 1999

BRAKE PEDAL WAS SET TOO HIGH , AND WHEN APPLYING BRAKES VEHICLE WOULD PULL HARD TO THE RIGHT. VEHICLE BEEN IN / OUT OF DEALER'S SHOP AND NOTHING COULD BE FOUND. *AK

NHTSA ID

841636

Incident

Jan 15, 1999

VEHICLE HAS HAD CONTINUALLY FAILURES WITH THE POWER STEERING SYSTEM (8 POWER STEERING PUMPS, 2 GEAR BOXES, 2 POWER STEERING PRESSURE LINES REPLACED), DAMAGE TO SERPENTINE BELT FROM FLUID LEAKAGE ON ONE OCCASION. MJS

NHTSA ID

545475

Incident

Sep 5, 1997