2007 Chevrolet Aveo Owner Complaints

The airbag warning light has remained illuminated since I acquired the vehicle in January 2025. The warning light stays on continuously and does not reset. This indicates a fault in the airbag system, and I have been advised that when this light is on, the airbags may be disabled and may not deploy in a crash. The vehicle has also experienced ongoing electrical problems, including lighting failures, blown fuses, and shift-interlock malfunctions, which suggests an electrical system fault affecting multiple safety-related systems. These issues create concern that the airbag control system may be impacted by the same electrical malfunction. The vehicle has not been repaired or diagnosed by a dealer for the airbag issue. The condition is still present and the warning light remains illuminated. This failure creates a serious safety risk because the airbags may not function in the event of a collision.

NHTSA ID

11713137

Incident

Jan 1, 2025

While driving, the vehicle began experiencing repeated electrical failures including blown fuses, inoperative headlights and brake lights, and the transmission becoming locked in PARK. When the fuse blows, the gear shift cannot be moved out of PARK and the ignition key cannot be removed, leaving the vehicle stuck and unable to be driven or safely turned off. The brake lights and daytime running lights also stop working, making the vehicle unsafe to operate in traffic. This condition has been occurring repeatedly and requires frequent fuse replacement just to move or shut off the vehicle. An emergency override hole on the shifter had already been exposed, indicating the problem existed before and the vehicle was previously being forced out of PARK manually. A tow truck driver had to use this override to move the vehicle. The airbag warning light is also illuminated, indicating the safety restraint system may not function properly in a crash. These failures create a serious safety risk due to loss of exterior lighting, inability to shift, inability to turn the ignition off, and possible airbag malfunction. This failure is consistent with a known defect involving the Daytime Running Light (DRL) module overheating and causing electrical shorts, as documented in manufacturer recall and technical service bulletins for this vehicle. The problem has been reproduced multiple times and remains unresolved.

NHTSA ID

11713135

Incident

Oct 1, 2025

The contact owns a 2007 Chevrolet Aveo. The contact was made aware of NHTSA Campaign Number: 06V398000 (Fuel System, Gasoline) however, the VIN was not included in the recall. The contact stated that after the vehicle was involved in an accident, the vehicle lost motive power and failed to restart on various occasions. No warning lights were illuminated, and the vehicle was towed to the contact's residence. The vehicle was then towed to an independent mechanic, where it was diagnosed that the fuel pump needed to be replaced. The vehicle was repaired; however, the contact stated that the failure had reoccurred, and the vehicle failed to restart. The manufacturer was made aware of the failure. The failure mileage was unknown.

NHTSA ID

11504723

Incident

Dec 31, 2022

The contact owns a 2007 Chevrolet Aveo. The contact stated while starting the vehicle, the driver’s side front air bag sensor warning light illuminated. The contact took the vehicle to an independent mechanic who inspected the vehicle and completed a diagnostic test which displayed a failure with the front driver’s side air bag. The vehicle was not repaired due to the cost. The manufacturer was not made aware of the failure. The failure mileage was approximately of 52,000.

NHTSA ID

11427530

Incident

Jul 20, 2020

Mileage

52,000 mi

Out of no where it cought on fire

NHTSA ID

11425220

Incident

Jul 10, 2021

TL* THE CONTACT OWNS A 2007 CHEVROLET AVEO. THE CONTACT STATED THAT WHILE DRIVING AT AN UNDISCLOSED SPEED, THE VEHICLE SHUDDERED WITH THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE FAILURE WAS DUE TO AN UNKNOWN ENGINE CYLINDER FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 96,000.

NHTSA ID

11340648

Incident

Jul 15, 2020

Mileage

96,000 mi

I HAVE PROBLEMS WITH WHENEVER I GO TO PUT GAS IN MY CAR, SOME OF IT GOES ON THE GROUND. NOT ALL OF THE GAS GOES ON THE GROUND, BUT A LITTLE LESS THAN HALF OF WHAT I PURCHASED. MY HEADLIGHTS ARE SO DIM THAT I CAN'T HARDLY SEE WHEN I'M DRIVING AT NIGHT. ALSO, MY PASSENGER SIDE AIR BAG LIGHT IS CONSTANTLY ON? THERE'S ONE THERE AND NOTHING BIGAMY WRONG WITH IT THAT I CAN SEE. THE STEREO.....ONLY THE DRIVER SIDE FRONT SPEAKER WORKS, THE OTHER THREE DOESN'T WORK AT ALL....PLEASE LOOK INTO THESE FEW THINGS OR GIVE ME SOME SORT OF IDEA OF WHAT I CAN DO

NHTSA ID

11306218

Incident

Jan 30, 2020

Mileage

177,900 mi

VEHICLE HEADLIGHTS FAILED. CAR WAS PARKED IN THE DRIVEWAY. AN HOUR LATER WHEN IT WAS STARTED AGAIN, THE HEADLIGHTS FAILED TO COME ON AND REMAIN INOPERABLE. BULBS, SWITCH, AND RELAY HAVE ALL BEEN CHECKED AND VERIFIED TO BE OPERABLE.

NHTSA ID

11156513

Incident

Dec 1, 2018

Mileage

82,000 mi

"TAKATA RECALL" I BOUGHT MY CAR IN 2009. ABOUT 6 MONTHS LATER THE AIRBAG LIGHT CAME ON AND THE DEALER WENT OUT OF BUSINESS. WHEN I CHECKED THE VIN NUMBER IT WAS NOT AMONG THE MANY, MANY AVEOS TAGGED FOR RECALL TO REPLACE FAULTY AIRBAG SYSTEMS. AND I'M NOT ALONE. COMPLAINTS KEEP PILING IN FROM AVEO OWNERS ABOUT THE AIRBAG SAFETY LIGHTS THAT NEVER TURN OFF, NEARLY CATCHING UP WITH 20 YEARS OF "COMPLAINTS INVOLVING TAKATA INFLATORS..." MY CAR WAS PARKED WHEN AN INDIVIDUAL BACKED INTO MY PASSENGER DOOR. THE COLLISION WAS SO SEVERE THE DOOR HAD TO BE REPLACED. YET IT TRIGGERED NO AIRBAGS. DID YOU KNOW WHILE THE AIRBAG LIGHT IS ENGAGED, THE CAR CANNOT BE SOLD? YOU THINK THIS MIGHT BE DUE TO THE FACT THAT IT INDICATES A SERIOUS PROBLEM WITH THE AIRBAG SYSTEM - THAT MOST PROMINENT FEATURE IN AVEO'S HIGHLY TOUTED "5-POINT" SAFETY RATING? SO WHAT'S ITS RATING WITHOUT AIRBAGS? OR DO WE NEED A HIGHER BODY COUNT BEFORE THE MAKERS AND SAFETY REGULATORS ARE WILLING TO TALK ABOUT THAT? NEED WE REALLY TOIL WITH THE QUESTION ABOUT WHY AMERICA LOST ITS PLACE IN THE AUTO INDUSTRY? WE NEED GO NO FURTHER THAN RIGHT HERE.

NHTSA ID

11155287

Incident

Mar 22, 2010

Mileage

65,000 mi

TAMARA RECALL MY CAR COMBUSTED INTO FRAMES AFTER BEING WRECKED INTO A CURVE OF LAST YEAR OF JUNE.

NHTSA ID

11149829

Incident

Jun 9, 2017

Mileage

160,000 mi

RECALL FOR DAYLIGHT RUNNING LIGHTS OVER HEATING DIDN'T APPLY TO MY PARTICULAR CAR, BUT SEEMS TO BE A PROBLEM IN MY CAR REGARDLESS. GROUND WIRES IN MY HEADLIGHT ASSEMBLY HAVE FRIED AND LEFT SCORCH MARKS ON HEADLIGHT CONNECTION. NO ACTUAL FIRE YET JUST A MELTED PLASTIC UNDER THE HOOD. NOT SURE IF MY CAR IS INVALID AS HAVE BEEN FIXED OR JUST NOT COVERED BUT IN EITHER CASE PART IS FAILING.

NHTSA ID

11142230

Incident

Oct 10, 2018

Mileage

90,000 mi

BLOWS A FUSE AND WILL NOT COME OUT OF PARK

NHTSA ID

11115030

Incident

Jul 27, 2018

1. AIRBAG READINESS LIGHT REMAINS ON FOR DURATION OF VEHICLE'S OPERATION. 2. DRIVER SIDE INSIDE DOOR LATCH IS CRACKED AND WILL NOT OPEN DOOR.

NHTSA ID

11102400

Incident

Feb 9, 2016

Mileage

38,334 mi

TL* THE CONTACT OWNS A 2007 CHEVROLET AVEO. WHEN THE CONTACT PULLED IN THE DRIVEWAY AND ATTEMPTED TO TURN OFF THE VEHICLE, THE ELECTRICAL POWER SHUT OFF. AS A RESULT, THE CONTACT WAS UNABLE TO ROLL THE WINDOWS UP OR DOWN, UNLOCK THE DOOR WITH THE SWITCH, AND THE KEY WOULD NOT TURN TO THE OFF POSITION IN THE IGNITION. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS CONTACTED AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING). THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

NHTSA ID

11094150

Incident

May 15, 2018

Mileage

120,000 mi

TL* THE CONTACT OWNS A 2007 CHEVROLET AVEO. WHILE ATTEMPTING TO PARK THE VEHICLE, IT INDEPENDENTLY ACCELERATED UPHILL. THE CONTACT STATED THAT THE FAILURE RECURRED TWICE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT THE FAILURE WAS NOT DETERMINED. THE LOCAL DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED CASE NUMBER: 8-3467846222. THE FAILURE MILEAGE WAS UNKNOWN.

NHTSA ID

11035624

Incident

Oct 18, 2016

TL* THE CONTACT OWNS A 2008 CHEVROLET AVEO. THE CONTACT STATED THE SEAT BELT WARNING LIGHT ILLUMINATED AND THE WIRES FOR THE PARKING LIGHTS WERE BURNT. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC WHO REPLACED THE VEHICLE'S FRONT LIGHT ASSEMBLY. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE CONTACT STATED THAT THE FAILURE WAS RELATED TO NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING) HOWEVER, THE VIN WAS NOT INCLUDED. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

NHTSA ID

11020046

Incident

Jan 1, 2016

Mileage

120,000 mi

TL* THE CONTACT OWNS A 2007 CHEVROLET AVEO. WHILE THE VEHICLE WAS PARKED OR WHILE DRIVING, A BURNING ELECTRICAL ODOR WAS DETECTED IN THE VEHICLE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT THE CAUSE OF THE ODOR COULD NOT BE DETERMINED. THE CONTACT WAS REFERRED TO AN ELECTRICAL SPECIALIST BY THE INDEPENDENT MECHANIC, BUT THE VEHICLE WAS NOT DIAGNOSED DUE TO THE DIAGNOSTIC FEES. THE CONTACT STATED THAT THE INDEPENDENT MECHANIC ADVISED HER TO DISCONNECT THE VEHICLE'S BATTERY. THE CONTACT RESEARCHED THE ISSUES ONLINE AND FOUND NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING), BUT THE VIN WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE, CONFIRMED THAT THE VIN WAS NOT INCLUDED IN THE RECALL, AND REFERRED THE CONTACT TO NHTSA. THE APPROXIMATE FAILURE MILEAGE WAS 120,000. UPDATED 10/25/17*LJ THE CONSUMER STATED THE VEHICLE WAS TRADED IN. *JS

NHTSA ID

11015140

Incident

Jul 30, 2017

Mileage

120,000 mi

AIRBAG LIGHT CAME ON AND HAS STAYED ON FOR 2 MONTHS. UNABLE TO DETECT WHAT IS WRONG WITH ELECTRONIC READER. AIRBAGS ARE DISENGAGED, AND I CAN'T FIND OUT WHY WITHOUT PAYING MORE MONEY THAN I HAVE TO SPEND BECAUSE EACH COMPONENT HAS TO BE CHECKED, AND THAT DOESN'T INCLUDE ACTUALLY FIXING THE PROBLEM, JUST FIGURING OUT WHAT THE PROBLEM IS. I'VE SEEN THAT MANY PEOPLE HAVE COMPLAINED ABOUT THIS. PASSENGER AIRBAG SENSOR STARTED ACTING WEIRD/ NOT WORKING FIRST. OCCURRED AROUND 100 K MILES. WHEN WILL A RECALL HAPPEN? THIS IS APPARENTLY A COMMON SAFETY ISSUE.

NHTSA ID

11006479

Incident

May 15, 2017

Mileage

100,000 mi

TL* THE CONTACT OWNS A 2007 CHEVROLET AVEO. WHILE DRIVING 55 MPH, THE ACCELERATOR PEDAL FAILED TO OPERATE AND THE GEAR FAILED TO SHIFT AND WENT STRAIGHT INTO NEUTRAL. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE COOLANT LEVEL SENSOR MODULE NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.

NHTSA ID

10946321

Incident

Jan 18, 2017

Mileage

130,000 mi

TL* THE CONTACT OWNS A 2007 CHEVROLET AVEO. WHILE DRIVING APPROXIMATELY 35 MPH, THE STEERING COLUMN SEIZED WITHOUT WARNING. THE VEHICLE WAS MANUALLY RESTARTED AND THE STEERING OPERATED NORMALLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 127,429.

NHTSA ID

10918998

Incident

Jun 30, 2016

Mileage

127,429 mi

THE AIR BAG WARNING LIGHT CAME ON WHILE DRIVING 20MPH WHILE TURNING AND HAS NEVER WENT OFF (STARTED AROUND 125,000MILES). I TOOK IT TO THE LOCAL MECHANIC, HE CHECKED WIRES AND HOOKED IT UP TO A DIAGNOSTIC MACHINE AND BELIEVES IT IS EITHER THE MODULE OR THE SENSOR IN THE SEAT, BUT CAN'T/WON'T GIVE AN EXACT CAUSE. WHEN I TRIED TO CONTACT GM THEY KEPT SAYING I WAS JUST GOING OFF WHAT THE INTERNET SAID AND NEEDED TO SEE A DEALER. JUST MADE IT FEEL LIKE THAT DIDN'T CARE ABOUT MY SAFETY OR THE SAFETY OF ANY ONE IN ONE OF THESE VEHICLES. *TR

NHTSA ID

10917451

Incident

May 28, 2016

Mileage

125,000 mi

TL* THE CONTACT OWNS A 2007 CHEVROLET AVEO. THE CONTACT STATED THAT THE AIR BAG WARNING INDICATOR ILLUMINATED THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 65,000. UPDATED 05/04/17*LJ *TR

NHTSA ID

10906200

Incident

Sep 13, 2014

Mileage

65,000 mi

TAKATA RECALL MY 2007 CHEVY AVEO ON 9/ 10 2016 WEN I STARTED IT UP THE PASSENGER SIDE AIR BAG LIGHT SAYING THAT THE AIRBAG IS OFF! HAS JUST COME ON AND WILL NOT GO OFF! IT IS ON EVERY TIME I START THE CAR AND WILE DRIVING IT WITH OR WITH OUT A PASSENGER IN IT. THIS FROM WHAT I HAVE READ ON LINE MEANS THE AIR BAG IS BAD AND WILL NOT DEPLOY OR WILL DEPLOY FOR NO REASON THERE NEEDS TO BE A RECALL I HAVE READ MANY POST FROM OTHERS WITH THIS SAME PROBLEM IN THE 2007 CHEVY AVEO PLEASE RECALL THIS CAR BEFORE SOMEONE IS KILLED!!!

NHTSA ID

10905547

Incident

Sep 10, 2016

Mileage

112,000 mi

DASHBOARD CAUGHT FIRE WHILST CAR WAS PARKED FOR HOURS IN SECURE PARKING LOT. CAR FIRE WAS PUT OFF BY FIREFIGHTERS WHO CUT BATTERY AND CABLES BROKE WINDOWS IN ORDER TO STOP FIRE. NOW CAR DOES NOT TURN ON AT ALL AND DASHBOARD CENTER IS COMPLETELY MELTED.

NHTSA ID

10904359

Incident

Aug 9, 2016

Mileage

50,000 mi

LIGHT STAY ON ALWAYS.

NHTSA ID

10895537

Incident

Nov 22, 2007

Mileage

50 mi