RoadVitals

1985 Chevrolet Cavalier Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Data refreshed

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
3
Newest May 19, 2006
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
5 investigations on file

Recall campaigns

3 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

06E043000

FUEL SYSTEM, GASOLINE

May 19, 2006
88,303 units potentially affected
The defect: CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
The risk: THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
The remedy: HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
HONEYWELL INTERNATIONAL, INC.View on NHTSA.gov
86V073000

ENGINE AND ENGINE COOLING:ENGINE

May 28, 1986
87,174 units potentially affected
The defect: THE ENGINE AIR CLEANER PLASTIC TRIM COVER COULD FALL OFF THE AIR CLEANER ASSEMBLY AND LAND ON THE EXHAUST MANIFOLD CREATING A FIRE HAZARD. CONSEQUENCE OF DEFECT: IF THE CAR IS BEING OPERATED AT THE TIME THAT THE PLASTIC TRIM COVER FALLS OFF, AN ENGINE COMPARTMENT FIRE COULD OCCUR WITHOUT WARNING.
The remedy: REMOVE THE TRIM COVER AND DISCARD.
GENERAL MOTORS CORP.View on NHTSA.gov
85V042000

ENGINE AND ENGINE COOLING:ENGINE

Apr 12, 1985
34,331 units potentially affected
The defect: THE ENGINE AIR CLEANER PLASTIC TRIM COVER COULD DETACH FROM THE AIR CLEANER ASSEMBLY AND FALL FORWARD ON THE EXHAUST MANIFOLD. CONSEQUENCE OF DEFECT: IF THE CAR IS BEING OPERATED AT THE TIME OF DETACHMENT, AN ENGINE COMPARTMENT FIRE COULD OCCUR WITHOUT WARNING.
The remedy: REMOVE THE TRIM COVER AND DISCARD.
GENERAL MOTORS CORP.View on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect, and it is not a recall.

PE88027ClosedPreliminary Evaluation

HEADLAMP SWITCH FAILURE

Opened Feb 9, 1988
Closed May 11, 1988

===

EXTERIOR LIGHTING
EA87006ClosedEngineering Analysis

POWER ST. ASSIST

Opened Dec 16, 1986
Closed Sep 19, 1988

SUMMARY OF INFORMATION FROM THE MANUFACTURER:GM HAS DEVELOPED A SPLITRING FIELD REPAIR KIT AND IS EXTENDING THE WARRANRY ON ALL 1982-84 A,J, AND X, BODY CARS AND 1985 C,BODY CARS.THE WARRANTY APPLIES TO CARSTHAT ARE FOR 50,000 MILES OR 5 YRS.IT INCLUDES REIMBURSEMENT FOR PREVIOUSREPAIRS.ANALYSIS:WEARING OF THE RACK AND PINION HOUSING AND LOW AMBIENT TEMPCAN CAUSE TEMPORARY LOSS OF POWER ASSIST.TEFLON O RINGS FAIL TO SEALOFF INTERNAL PRESSURE.STATUS:EVALUATING THE EXTENDED WARRANTY OFFER BY GM.======

STEERING
EA87007ClosedEngineering Analysis

SUDDEN ACCEL

Opened Dec 16, 1986
Closed Aug 7, 1987

SUMMARY OF INFORMATION FROM MANUFACTURER:ANALYSIS:STATUS: GM RESPONDED BY LETTER DATED 12 FEBRUARY 1987.EA CLOSED ON8/7/87.===

VEHICLE SPEED CONTROL:LINKAGES
DP86019ClosedDefect Petition

SUDDEN ACCELERATION

Opened Sep 12, 1986
Closed Dec 22, 1986

There is no summary currently available

VEHICLE SPEED CONTROL:LINKAGES
PE86031ClosedPreliminary Evaluation

UNDERHOOD FIRES

Opened Feb 18, 1986
Closed Jun 10, 1986

There is no summary currently available

ENGINE AND ENGINE COOLINGLed to recall 86V073000

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .