RoadVitals

1996 Chevrolet Chevy Van Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
2
Latest Jun 5, 2006
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
2
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 1996 Chevrolet Chevy Van, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Driver assistance150.0%
  • Fuel system150.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Driver assistance

Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.

1
report

From owner reports, verbatim

CONSUMER STATES WHEN HE LETS GO OF THE ACCELERATOR PEDAL THE VEHICLE SPEED DOES NOT DECREASE.*JB

NHTSA ID 8010436 · filed May 23, 2002

Too few reports in this category for a page of its own — they appear in the full complaint list.

Fuel system

Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.

1
report

From owner reports, verbatim

DT*: THE CONTACT STATED THE FUEL PUMP FAILED MULTIPLE TIMES. DURING THE FIRST FAILURE THERE WAS NO WARNING WHEN THE VEHICLE STALLED. THE FUEL PUMP WAS REPLACED BY AN INDEPENDENT REPAIR SHOP ON SEPTEMBER 29, 2004 AT 113,500 MILES. WHILE DRIVING 45 MPH THE VEHICLE STALLED AND THEN RESTARTED. THERE WAS NO WARNING PRIOR TO THE VEHICLE STALLING. THE MECHANIC REPLACED THE FUEL PUMP A SECOND TIME AT 146,000 MILES. DURING THE INSPECTION IT WAS DISCOVERED THE FUEL PUMP CONNECTOR WAS CAUSING THE FUEL PUMPS TO FAIL. THERE IS A NHTSA RECALL, # 05V155000, REGARDING THE FUEL PUMP. THE FUEL PUMP PART NUMBER ON THE VEHICLE IS WH-3001. THE VIN WAS NOT INCLUDED IN THE RECALL. UPDATED 6-27-2006 - *NM

NHTSA ID 10159019 · filed Jun 5, 2006

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .