2009 Chevrolet Cobalt Electrical Problems

The air bag never deployed I bought car in 2018 from original owner with car only having 33,000 miles on it and still under warranty til car had 100,000 miles and I hit a deer head on 2 months after getting car which bought in may of 2018 hit the deer in July 2018 . The deer was hit with the front passenger side it broke my headlight n messed my hood up and smashed in the grill little and my air bags never deployed I hit deer at 50 mph , after that had happened I took it in to Chevy dealership and had them look at car cause I told them I hit that deer and air bag never deployed and that my air bag light came on once in awhile and said service air bag . The dealership said they do that sometimes and did something to make light go off that was it my air vag light still comes on and says service air bag . Also ignition switch and fuel smell foul coming from car a lot and is as I speak . My reduce engine power light comes on a lot and have no power to gas pedal n car won’t stay running . I have try to get two recalls fixed back in 2-21 I was having problems with my car back then too special reach called me in Jan of 2021 and told me that there were two recalls on my car ignition switch and fuel module so I informed dealership when I took my car in That next month in feb 21 told them I was informed on 2 active recalls on my car . When they were done with my car later that day I asked them if they fixed the recalls they said no cause it was map sensor so I then made an appt to get recalls fixed when I got there for the recalls to be fixed one of the technicians told me it shows that they were done . I called Chevy and complained about the issue I just had and never had recalls fixed but they must of put it in computer they fixed them So I’ve been really upset that I been trying to get past recalls fixed that are on my car and I get run around and told there isn’t any I know about a past recall on shift selnoid low circuit too that was a past recal

NHTSA ID

11631947

Incident

Feb 20, 2021

The contact owns a 2009 Chevrolet Cobalt. The contact stated while attempting to start the vehicle, the vehicle failed to start and was jumpstarted; however, the auto theft warning light illuminated, and the key could not be removed from the ignition. The contact was able to drive the vehicle however, the locks failed to lock the doors, and there was a clicking sound when the windows failed to roll up or down. The contact stated that after refueling the vehicle, the vehicle was consuming an excessive amount of fuel. The contact stated that the tank was full however, the next day the fuel tank was empty. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 161,595.

NHTSA ID

11585314

Incident

Apr 1, 2024

Mileage

161,595 mi

Wiring harness is located too close to the human under the driver's seat. Exposes the driver to electrical frequencies that could be avoided if the wire harness was a further distance away from the human. Also, the the fuel line rusted through after 9 years about 9 inches away from the rear axle where the metal tape ends around the fuel line. The metal tape seems to allow more moisture to become trapped around the fuel line; which promotes rust and a leak where the metal tap ends. After the metal tape, the fuel line is in good condition on this specific vehicle. The fuel leak is about 0.5 inches wide and a lot of gasoline drips / leaks after the car is started. The rust particles are located after the fuel filter; which may promote the rust particles to reach the engine via the rusted fuel line. The car has trouble starting (a delay) and needs to have the key turned twice due to the leak. The leak is very close to the muffler, so it seems like it would be at risk of catching on fire if the muffler was hot enough or if it were traveling on a long trip or going up or down a steep hill. The vehicle has been inspected by police. There were no warning lamps or lights.

NHTSA ID

11464722

Incident

May 13, 2022

The contact owns a 2009 Chevrolet Cobalt. The contact stated while driving at various speeds, the vehicle would shake, and the vehicle would power off inadvertently. The vehicle would restart however, the steering wheel was difficult to turn. The contact stated that the check engine warning light was illuminated. The vehicle was not diagnosed nor repaired. The manufacturer was informed of the failure. The failure mileage was approximately 134,000.

NHTSA ID

11422791

Incident

Jun 16, 2020

Mileage

134,000 mi

WITH NO RECENT CHANGES TO THE CAR, IT WON'T START, THEFT LOCK SYMBOL IS ON. TRIED THE SPARE KEY. TRIED THEFT LOCK RELEARN 10 MINUTE AND 30 MINUTE PROCEDURE. DISCONNECTED AND RE-CONNECTED NEGATIVE BATTERY TERMINAL. NONE OF THE STEPS WORKED. THIS ISSUE HAS THE POTENTIAL TO KEEP FAMILIES STRANDED.

NHTSA ID

11400264

Incident

Mar 10, 2021

Mileage

119,273 mi

NO START ISSUE. BATTERY AND ALTERNATOR GOOD. WONT START AFTER IT'S BEEN DRIVEN FOR ABOUT 1 HOUR. WHEN YOU TURN CAR OFF IT WON'T START UNTIL IT COOLS DOWN. I HAVE NOT BEEN ABLE TO GO ANYWHERE BECAUSE IT WON'T START WHEN I COME OUT OF STORE ST SHOP AGAIN. NEW STARTER PUT IN AND WON'T START. THEY ARE GOING TO KEEP LOOKING

NHTSA ID

11385500

Incident

Dec 11, 2020

Mileage

88,600 mi

IGNITION SWITCH WAS SAID TO BE THE ISSUE WITH MY CAR AND THERE WAS A RECALL FOR YEARS 2005-2010 .IGNITION SWITCH SAFETY ISSUE. STARTER MOTOR IS GOOD. BATTERY IS GOOD. ALTERNATOR IS GOOD. WILL NOT CRANK OR START.

NHTSA ID

11339754

Incident

Jun 10, 2020

I BOUGHT A USED 2009 CHEVY COBALT 2 YEARS AGO IN 2017 WITH 119K MILES. IT HAS BEEN NOTHING BUT A HEADACHE WITH THINGS GOING WRONG! THE BIGGEST ISSUE IS THE CODE P2135 THAT SENDS THE CAR INTO REDUCED ENGINE POWER AND THE ENGINE SHAKES VIOLENTLY. THIS IS VERY SCARY ESPECIALLYWITH 3 YOUNG BOYS IN THE CAR WITH ME. I HAVE REPLACED THE ENTIRE THROTTLE BODY, ECM, ACCELERATOR PEDAL ASSEMBLY WITH NEW SENSOR, CRANKSHAFT POSITIONING SENSOR, CAMSHAFT SENSORS, SPARK PLUGS AND SPARK PLUG WIRES. AFTER ALL THESE THINGS I AM OUT OF IDEAS ONWHY THIS KEEPS HAPPENING IN BUT ALL THOSE NEW PARTS HAVE NOT FIXED THE PROBLEM THAT KEEPS OCCURRING. PLEASE TELL ME THERE IS A RECALL OR YOU CAN AT LEAST TELL ME WHAT THE PROBLEM IS. I HAVE READ MANY FORUMS ABOUT PEOPLE WITH THIS SAME ISSUE.

NHTSA ID

11316325

Incident

Jun 1, 2017

Mileage

120,000 mi

THE VEHICLE ANTI THEFT LIGHT KEEPS COMING ON. WHEN THIS OCCURS THE VEHICLE JERKS IN DRIVE, HARD TO STOP, WHEEL WILL LOSE POWER STEERING IN DRIVE, AND ALL NEEDLES WILL MOVE. THE RPM, MPH, AND GAS NEEDLE CONTINUES TO FLUCTUATE. THE GAS NEEDLE WILL INDICATE LOW FUEL WHEN FUEL IS PRESENT. I CAN NEVER KNOW WHAT SPEED I'M DOING. THE VEHICLE FLASHES POWER STEERING DIGITALLY. THE CAR WILL SHUT OFF IN MID DRIVE! TAKEN TO MANY MECHANICS INCLUDING DAVE GILL CHEVROLET AND NO ONE FULLY DIAGNOSED THE ISSUE!

NHTSA ID

11267137

Incident

Aug 27, 2018

Mileage

128,000 mi

HELLO, I HAVE A 2009 CHEVY COBALT. IT WAS RUNNING OKAY. I WENT TO THE STORE FOR SOME DOG FOOD. PARKED THE CAR, CAME BACK TO GO BACK HOME AND THE KEY 🔑 IN THE IGNITION WOULD NOT TURN. IT WAS LOCKED OR JAMMED, DON'T KNOW. KEY WOULD NOT TURN IN THE IGNITION SWITCH TO TURN THE CAR ON!!! I WENT TO THE INTERNET AND FOUND THAT THERE WAS A RECALL FROM GENERAL MOTORS ON MY 2009 CHEVY COBALT. I FOUND A NHTSA CAMPAIGN ID# 14V171000 THAT SHOWS THE RECALL FOR MY CAR. IT DESCRIBES AN IGNITION SWITCH RECALL. I CALLED THE CHUCK NASH CHEVROLET WHERE I BOUGHT THE CAR AND THEY TOLD ME THAT THEY HAD REPAIRED THE RECALL. APPARENTLY THEY REPAIRED IT WITH A DEFECTIVE IGNITION-SWITCH OR NOT AT ALL. THE RECALL STATES THAT SOME VEHICLES WERE REPAIRED WITH DEFECTIVE OR USED PARTS. MARY BARRA, GENERAL MOTORS CEO STATED THAT ALL AFFECTED RECALL VEHICLES WOULD BE REPAIRED UP TO CUSTOMER SAFETY STANDARDS. I REALLY NEED YOUR HELP IN THIS MATTER. THIS CAR IS MY ONLY MEANS OF TRANSPORTATION. THANKS. GOD BLESS.

NHTSA ID

11257415

Incident

Sep 11, 2019

Mileage

83,500 mi

TL* THE CONTACT OWNS A 2009 CHEVROLET COBALT. WHILE DRIVING VARIOUS SPEEDS, THE STEERING WHEEL SPONTANEOUSLY FAILED TO TURN AND SEIZED. IN ADDITION, THE TIRE PRESSURE MONITORING INDICATOR ILLUMINATED AND THE REMAINING INSTRUMENT CLUSTER WARNING INDICATORS WERE INOPERABLE. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 152,000.

NHTSA ID

11219498

Incident

Apr 1, 2019

Mileage

152,000 mi

TL* THE CONTACT OWNS A 2009 CHEVROLET COBALT. THE CONTACT STATED THAT THE VEHICLE DID NOT START AND SPILLED FUEL WITHOUT WARNING. THE VEHICLE WAS TOWED TO SCENIC CHEVROLET (864-622-2555, LOCATED AT 3449 BLUE RIDGE BLVD, WEST UNION, SC 29696) WHERE IT WAS STATED THAT THE REPAIRS FOR NHTSA CAMPAIGN NUMBER: 14V047000 (AIR BAGS, ELECTRICAL SYSTEM) AND NHTSA CAMPAIGN NUMBER: 14V171000 (ELECTRICAL SYSTEM) COULD NOT BE PERFORMED DUE TO CORRODED FUEL LINES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT ASSIST. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 48,000.

NHTSA ID

11204375

Incident

Jan 29, 2019

Mileage

48,000 mi

AFTER DRIVING CAR APPROXIMATELY 4 MILES ON COUNTY ROADS, AT 25-35MPH. I ARRIVE AT MY DESTINATION, STOP, SHIFT INTO PARK, AND REACH TO TURN KEY OFF. I AM UNABLE TO MOVE KEY FROM THE RUN POSITION, AND/OR REMOVE THE KEY. SO MY CAR IS SITTING THERE RUNNING AND I AM UNABLE TO TURN OFF THE ENGINE. AFTER NEARLY 10 MINUTES TRYING TO TURN THE KEY BACK TO OFF WHILE JIGGLING THE KEY AND THE STEERING WHEEL, AND SHIFTING THE GEAR SHIFT DOWN AND BACK TO PARK SEVERAL TIMES, I AM UNABLE TO REGAIN CONTROL OF THE IGNITION SWITCH AND KEY. I RESORT TO PULLING A FUSE UNDERHOOD TO KILL THE ENGINE.

NHTSA ID

11191150

Incident

Mar 23, 2019

Mileage

170,000 mi

WIRING HARNESS IN DRIVER'S SIDE FRONT DOOR CREATES AN ELECTRICAL SHORT THAT DISABLES SIDE IMPACT SENSORS/AIRBAGS. SYMPTOMS MATCH EXACTLY THE AN EXISTING RECALL (15V500000) THAT LISTS ONLY THE 2010 MODEL YEAR AS BEING AFFECTED. THE DISABLING OF THE AIRBAG HAPPENS EVERY TIME THE DRIVER'S SIDE WINDOW IS ROLLED DOWN. THIS OCCURS WHEN DRIVING AND STATIONARY.

NHTSA ID

11191045

Incident

Mar 4, 2019

TL* THE CONTACT OWNS A 2009 CHEVROLET COBALT. THE CONTACT STATED THAT THERE WAS NO SAFETY PRE-INSPECTION STICKER WHEN THE VEHICLE WAS PURCHASED FROM DEL CHEVROLET (1644 LANCASTER AVE, PAOLI, PA 19301, (484) 324-4265). AS A RESULT, THE VEHICLE FAILED INSPECTION. THE INSPECTION SHOP INFORMED THE CONTACT THAT THE BATTERY NEEDED REPLACEMENT, THE VEHICLE NEEDED AN ALIGNMENT, FOUR NEW TIRES, AND A NEW LOWER CONTROL ARM AND BALL JOINT. IN ADDITION, THE VEHICLE STALLED ON MORE THAN ONCE OCCASION. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBERS: 14V171000 (ELECTRICAL SYSTEM, 14E021000 (ELECTRICAL SYSTEM), AND 14V047000 (AIR BAGS, ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 115,000.

NHTSA ID

11176204

Incident

Mar 15, 2018

Mileage

115,000 mi

THE IGNITION SWITCH WON'T TURN ON AND SOMETIMES WON'T TURN OFF ITS VERY LOOSE ONCE YOU DO GET IT ON AND NOW WON'T TURN OVER AT ALL

NHTSA ID

11129902

Incident

Sep 17, 2018

THIS HAS HAPPENED TWICE, MY CAR WONT START AND THE ANTI THEFT ON THE DASH COMES ON BUT THERE'S NOTHING ON TO KILL THE BATTERY. ALSO SOMETIMES WHILE DRIVING MY SERVICE AIR BAG LIGHT COMES ON BUT GOES OFF RIGHT AFTER. LAST THING IS MY POWER LOCKS WOULD GO CRAZY JUST LOCKING AND UNLOCKING EITHER WHEN THE CAR WAS OFF OR IN MOTION.

NHTSA ID

11114367

Incident

Jul 15, 2018

Mileage

143,000 mi

ELECTROMAGNETIC METER (EMF METER FOR BOTH WIRELESS & NON-WIRELESS FORMS OF ELECTRICAL RADIATION) USED TO MEASURE ELECTRICAL RADIATION LEVELS READ HIGH LEVELS OF RADIATION THAT THE METER FELT WAS OVER-THE-LIMIT ONLY WHEN POWERING THE VEHICLE ON BUY TURNING THE KEY (WITH A BATTERY & GAS IN THE VEHICLE). THE INCREASE OF ELECTRICAL POWER SEEMS TO BE THE CAUSE OF THE METER INCREASING. THERE ARE MANY WIRES THAT WERE UNDER THE SEAT THAT ARE SETTING OFF THE METER WHEN HELD WITHIN 12 INCHES OF IT (IN THE AREA THE DRIVER & PASSENGER WOULD SIT - ON THE SEAT). PERHAPS, A RECALL AND ELECTROMAGNETIC SHIELDING NEEDS TO BE ADDED IN THE AREA WHERE THE PASSENGERS AND DRIVERS SIT.

NHTSA ID

11098870

Incident

May 1, 2018

TL* THE CONTACT OWNS A 2009 CHEVROLET COBALT. THE CONSUMER STATED UPON ENTERING THE VEHICLE THE ANTI-THEFT INDICATOR WAS ILLUMINATED. THE CONTACT PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD AND RESTARTED THE VEHICLE; HOWEVER, IT FAILED TO START. THE DEALER (JIM TAYLOR CHEVROLET LOCATED AT 139 GRIMSHAW ST, RAYVILLE, LA 71269; (318) 728-6550) WAS CONTACTED AND CONFIRMED THAT THE CONTACT HAD TO PAY FOR THE REPAIR SINCE THE VIN WAS NOT INCLUDED IN A RECALL. THE VEHICLE WAS DIAGNOSED THAT THE IGNITION SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AT 800-222-1020 AND STATED THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 160,000. UPDATED 08/16/17*LJ *CN THE CONSUMER STATED INITIALLY ASKED WAS THERE A RECALL ON THE IGNITION SWITCH. THE CONSUMER ALSO STATED THE DIAGNOSIS WAS THE SHIFT SOLENOID, WHICH WAS REPLACED ON 8/8/17 AND 8/10/17 BUT THIS IS STILL A RECURRING PROBLEM. THE CONSUMER STATED THE VEHICLE IS BACK IN THE SHOP AND THE MECHANIC IS SAYING ITS AN ELECTRICAL ISSUE. *TR

NHTSA ID

11011690

Incident

Jul 30, 2017

Mileage

160,000 mi

TL* THE CONTACT OWNS A 2009 CHEVROLET COBALT. WHILE DRIVING 60 MPH, THE VEHICLE STALLED AND THE LOW FUEL SENSOR INDICATOR ILLUMINATED. THE CONTACT STATED THAT SHE HAD 50 MILES TO GO UNTIL THE FUEL TANK WAS EMPTY. THE CONTACT HAD SOMEONE COME TO HER LOCATION TO REPLACE THE ECM/TRANS FUSE, WHICH ALLOWED THE VEHICLE TO RESTART; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TOWED TO THE DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN ANY OPEN RECALLS PER CASE NUMBER: 8-2926645326. THE FAILURE MILEAGE WAS APPROXIMATELY 119,000.

NHTSA ID

10983455

Incident

Apr 29, 2017

Mileage

119,000 mi

EPS MOTOR HAS FAILED, I SEE SOME RECALLS ON THIS WHY NOT MINE. THIS SEEMS TO BE A BIG PROBLEM WITH THE COBALT SO I DON'T UNDERSTAND WHY MINE IS NOT IN THE RECALL. I WAS DRIVING WHEN THIS HAPPENED. *TR

NHTSA ID

10933651

Incident

Nov 25, 2016

TL* THE CONTACT OWNS A 2009 CHEVROLET COBALT. THE CONTACT STATED THAT THE POWER STEERING FAILED AND THE POWER STEERING INDICATOR ILLUMINATED. IN ADDITION, THE SPEEDOMETER, RPM, AND FUEL GAUGES RANDOMLY MOVED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS APPROXIMATELY 71,250.

NHTSA ID

10927194

Incident

Nov 21, 2016

Mileage

71,250 mi

TL* THE CONTACT OWNS A 2009 CHEVROLET COBALT. WHILE DRIVING VARIOUS SPEEDS, THE INSTRUMENT PANEL GAUGES FLUCTUATED AND THE POWER STEERING FAILED. THE LOW FUEL, SERVICE TRACTION, POWER STEERING, AND CHECK ENGINE WARNING INDICATORS ILLUMINATED. THE CONTACT WAS ABLE TO PULL THE VEHICLE OVER, SHUT IT OFF, AND RESTART IT ON THE FIRST ATTEMPT. HOWEVER, THE FAILED RECURRED. THE VEHICLE WAS OPERABLE AGAIN AFTER BEING PARKED FOR HOURS. THE VEHICLE WAS TAKEN TO A DEALER, BUT THE FAILURE COULD NOT BE DUPLICATED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 61,000.

NHTSA ID

10914240

Incident

Oct 5, 2016

Mileage

61,000 mi

HAD THE IGNITION SWITCH RECALL "FIXED" ABOUT 6 MONTHS AGO, AND TODAY I GO TO START IT AND EXACT SAME THING, KEY STUCK IN IGNITION, NOW WHEN I SEARCH RECALL FOR MY CAR IT SHOWS NOTHING UNDER MY VIN, NOW I'M STUCK WITHOUT MY CAR BECAUSE PREVIOUS DEALERSHIP DIDN'T FIX IT CORRECTLY AND THE RECALL IS THE OBVIOUS REASON!

NHTSA ID

10907514

Incident

Sep 18, 2016

TL* THE CONTACT OWNS A 2009 CHEVROLET COBALT. THE CONTACT'S VEHICLE WAS INCLUDED IN A RECALL REGARDING THE ELECTRICAL SYSTEM AND IGNITION. THE VEHICLE WAS REPAIRED PER THE RECALL, WHICH INCLUDED NEW IGNITION KEYS. SHORTLY AFTER THE REPAIR, THE KEY PAD FOR THE DOORS NO LONGER WERE ABLE TO CONTROL THE DOOR LOCKS. THE VEHICLE ALSO BEGAN TO EMIT A BURNING RUBBER ODOR FROM THE STEERING WHEEL. ADDITIONALLY, THE STARTER KEY WAS DIFFICULT TO REMOVE FROM THE IGNITION OCCASIONALLY WITHOUT HAVING THE STEERING WHEEL IN A SPECIFIC POSITION. THE CONTACT ALSO STATED THAT SOMETIMES THE ENGINE AND ALL THE ELECTRICAL SYSTEMS WOULD FAIL TO START; HOWEVER, ONLY THE TAIL LIGHTS REMAINED ILLUMINATED. IT WAS DIAGNOSED THAT THE VEHICLE'S MICRO SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 28,000.

NHTSA ID

10905765

Incident

Sep 1, 2014

Mileage

28,000 mi