2015 Chevrolet Colorado Problems

The electric power steering assembly has failed. I will be driving and my power steering will cut out with no warning, the sensor light is on constantly. Turning it off will sometimes fix it but not for long. It will affect my cruise control at times as well

Was traveling down the interstate at 75mph. The steering wheel jolted left and would not allow driver to turn the wheel back to the right causing a single vehicle accident. The vehicle left the roadway and hit the cable barrier in the median and traveled approximately 50 yards before stopping.

The electric power steering assembly has failed. I will be driving and my power steering will cut out with no warning, the sensor light is on constantly. Turning it off will sometimes fix it but not for long. It will affect my cruise control at times as well

The contact owns a 2015 Chevrolet Colorado. The contact stated that while driving at various speeds, the Service Power Steering light would illuminate and the power steering would fail. The contact would have to pull to the side of the road, turn off the vehicle, and wait a while in order to reset the vehicle's computer system and re-activate the power steering. The traction control, stability, track, and service 4-Wheel Drive warning lights were illuminated as well. The vehicle was taken to 3 different certified mechanics, who were not able to diagnose and repair the vehicle. The steering wheel was recalibrated by a mechanic; however, the failure remained persistent. The manufacturer was informed, and it was confirmed that the VIN was not included in any recall. The failure mileage was 115,225.

The electric power steering assembly has failed. I will be driving and my power steering will cut out with no warning, the sensor light is on constantly. Turning it off will sometimes fix it but not for long. It will affect my cruise control at times as well

Odometer Fraud. The contact purchased a 2015 Chevrolet Colorado. The contact stated that they discovered a mileage discrepancy after the purchase. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 193,073. The contact began having unknown issues with the vehicle and obtained a Carfax report. The report indicated the vehicle was due for an oil change. The report indicated the mileage was 292,500. The Birmingham police department was contacted and referred him to the NHTSA hotline.

The contact owns a 2015 Chevrolet Colorado. The contact stated that while driving approximately 45 MPH and depressing the accelerator pedal, the vehicle hesitated and failed to respond as needed. The vehicle gradually responded but failed to exceed 50 MPH. There was no warning light illuminated. The failure was intermittent and only occurred while depressing the accelerator pedal. The vehicle was taken to the local dealer several times due to the failure. The contact stated that the failure reoccurred several times after the vehicle was repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 150,000.

Steering: Sudden loss of power steering. DIS display says check Stable trak Transmission: Has a problem with request for downshift

Since i've had my truck the passenger seat vibrates excessively while driving; the oil alert comes on even when there is oil, current oil change; seems to not have power, shifts hard. What's interesting is that these items come up when I searched on recalls. this truck is not driven hard... mehanic cant figure out what is causing the oil alert, the passenger seat shaking excessively.. and there is a recall on You Tube Truck was purchased in [XXX], 07/15 have lived in [XXX] since 11/15. This is unacceptable INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owned a 2015 Chevrolet Colorado. The contact stated that the vehicle was driven and parked in the garage. Upon exiting the vehicle, the contact noticed an abnormal burning smell and smoke coming from under the hood. It was unknown whether a warning had illuminated. The contact opened the hood and noticed that the engine compartment had caught on fire. The contact closed the hood and attempted to restart the vehicle to drive out of the garage; however, the vehicle failed to restart. The contact shifted to neutral(N) and was able to push the vehicle out of the garage. The contact stated that the vehicle burned significantly from the front end to the windshield. The fire was extinguished by the fire department. No fire department report was filed. No police report was filed. There was no injury sustained. There was no property damage. The contact stated that the vehicle was a total loss and was in the process of being towed to a salvage yard. The vehicle did not have full insurance coverage but had liability coverage. The dealer and the manufacturer were not contacted. The failure mileage was approximately 124,000.

The contact owns a 2015 Chevrolet Colorado. The contact stated that while driving on a service road at 35 MPH and attempting to bring the vehicle to a stop, the brake pedal was depressed; however, the brake pedal was extremely firm, requiring excessive force to depress for the vehicle to come to a stop. The contact stated that there was an abnormal amount of white smoke coming from the front end of the vehicle. There was no warning light illuminated. The contact pulled over and had the vehicle towed to the local dealer to be diagnosed. The contact was informed that the vacuum pump was faulty and needed to be replaced. The vehicle was repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 141,540.

The contact owns a 2015 Chevrolet Colorado. The contact stated while driving at an undisclosed speed, the brake pedal was depressed; however, the vehicle failed to stop as intended. The contact stated that the brake pedal was pushing his foot upwards. The contact had to step on the brake pedal very hard to stop the vehicle to prevent a crash. The vehicle was taken to an independent mechanic where it was diagnosed with a failed vacuum pump, vacuum sensor, and a fractured cam shaft. The contact was informed that the vacuum sensor and the vacuum pump needed to be replaced, and the cam shaft needed to be repaired. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 156,000.

I just bought this truck. While driving it on the first day we were in stop and go traffic and I pressed the throttle and nothing happened, when I pressed it further it all of a sudden squealed tires and jumped forward causing me to almost rear end the car in front.

The contact owns a 2015 Chevrolet Colorado. The contact stated that while driving at 70 MPH, the vehicle to her right lane was struck by a vehicle behind it causing the vehicle on the right lane to spin out and hit her vehicle. The contact stated her vehicle was struck on the right center of the passenger side. No air bags deployed. No warning lights were illuminated. A police report was filed. No injuries were sustained. The vehicle was not towed. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and advised the contact to call the NHTSA Hotline. The failure mileage was approximately 157,000.

2005 CHEVY COLORADO RUSTED FRAME NEXT TO REAR CAB MOUNTS ON BOTH SIDES. FRAME IS CRACKING IN THIS LOCATION. THIS APPEARS TO BE THE RESULT OF RUSTING FROM THE INSIDE OUT BECAUSE THE REST OF FRAME LOOKS TO BE IN GOOD CONDITION. STILL HAS PAINT ON IT. I THINK THIS IS A WEAK SPOT IN THE FRAME DUE TO A STRUCTURAL ENGINEERING ISSUE. I HAVE FOUND MANY OTHER PEOPLE COMPLAINING OF THE SAME PROBLEM WITH THERE CHEVY COLORADO'S

TL* THE CONTACT OWNS A 2015 CHEVROLET COLORADO. THE CONTACT STATED THAT THE REAR PASSENGER SIDE FENDER WAS SEVERELY CORRODED. SHOTTENKIRK (5031 AVE O, FORT MADISON, IA) WAS CONTACTED AND CONFIRMED THE VEHICLE HAD CORROSION, BUT REFUSED TO REPAIR THE VEHICLE FOR FREE. THE CONTACT WAS REFERRED TO THE MANUFACTURER AND NHTSA. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED ON THREE OCCASIONS FOR THE SAME ISSUE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 23,700. *BF UPDATED 7/24/18*JB

Engine Control module-PO442 leak detected and PO496 Evaporated Emission System Flow during non-purge. Also, Inflatable Restraint Sensing and Diagnostic Module -1.B1425-03 Control module power circuit. When we fill the gas tank it takes multiple times to start And Stalls While Driving, almost causing accidents. We have diagnostic report by Firestone, Advanced Auto. First believed gas cap problem when started 2020-2021?Problem has become more constant to point of us not being comfortable driving far for fear of accident or getting stuck somewhere.

Beginning in 2018, perhaps earlier, I noticed that often when I would press the accelerator all the way, the engine would (and still does) make a sound (I’ve since learned, through many dealership interactions and internet searches, that the sound is referred as pinging or knocking from pre-detonation), and it SEEMED that the car’s computer would (and still does) electronically back off the throttle, and the rpm’s reduced in terms of speed of acceleration (sometimes the rpm’s even DECREASED as opposed to merely increasing less rapidly). This has placed myself and passengers of the car in danger by causing the car to go through intersections significantly slower than I (as well as my mother who also occasionally drives the car) would naturally anticipate, as this slow crossing through the intersection has led to many close-calls when intersecting traffic (when they have the right-of-way) almost crash into the broad side of the truck. It USED to occur I would put in any fuel with an octane rating lower than 91, but now it even happens with 91 octane fuel. The problem has been reproduced by two Chevrolet dealerships. I have taken it in many times to have them repair/replace/service parts that I thought might be causing the problem. The shop foreman at one location replicated it and said he had no idea what the cause could be. The service dept. was then in back-and-forth contact with engineers at GM over the next couple of days, and the engineers eventually suggested an oil system flush thing (which ended up not helping). It’s had oil filter changes, fuel induction service, and basically everything short of replacing the injectors or pistons. Neither the vehicle nor its components have been inspected by the manufacturer, police, insurance representatives or others. No warning lamps or messages have ever displayed in relation to the problem. My co-worker’s husband has a 2018 GMC Canyon with a V6, and says the exact same thing happens with his car.

Steering: Sudden loss of power steering. DIS display says check Stable trak Transmission: Has a problem with request for downshift

Power steering and stabilitrak will suddenly go out while I’m driving with no warning. Recall repair was already performed 6/2023 yet I’m still experiencing the problem. I contacted the dealer within a few days of the repair and explained the problem was still occurring. The lady I spoke to said I didn’t tell them I was already having problems with the power steering when I dropped off the vehicle for repair. I was informed I would have to pay for the additional repair out of pocket.

The contact owns a 2015 Chevrolet Colorado. The contact previously received notification of the NHTSA Campaign Number: 16V054000 (Steering), and the vehicle was taken to the dealer where the recall repair was completed; however, while driving at an undisclosed speed, the steering wheel became stiff and difficult to maneuver. The power steering assist warning light illuminated. The contact turned off the vehicle, then opened and closed the driver’s side door and the steering wheel started to perform as designed. The contact stated that the front driver’s and passenger’s side low beam and the rear passenger’s side taillight failed. The vehicle was taken to the dealer where it was diagnosed that the steering rack had failed and needed to be replaced. The manufacturer was notified of the failure and the contact was informed that a percentage of the repair cost would be covered. The failure mileage was approximately 110,372.

THE AUTO HEADLIGHT FUNCTION CHANGES THE INSTRUMENT PANEL LIGHTS TO DIM WHEN DRIVING. EXAMPLE: AT 4 O'CLOCK PM YOUR DRIVING EAST. THE SUN IS SETTING TOWARDS THE WEST SO THE LIGHT SENSOR ON THE DASH THAT CONTROLS THE AUTO HEADLIGHT FUNCTION DOESN'T SEE THE SUN DIRECTLY THINKS IT'S DARK OUTSIDE AND TURNS THE HEADLIGHTS ON. WHEN THIS HAPPENS THE INSTRUMENT PANEL LIGHTS GO DIM BECAUSE YOU HAVE SET THE DIM CONTROL THE PREVIOUS NIGHT TO A LOWER LEVEL THAT IS NOT BRIGHT AND DISTRACTING TO YOUR NIGHT TIME DRIVING. WHEN THIS HAPPENS YOU HAVE TO PHYSICALLY TAKE YOUR EYES OFF THE ROAD TO ADJUST THE DIM CONTROL SWITCH SO THE INSTRUMENT PANEL LIGHT IS BRIGHT ENOUGH DURING THE DAYLIGHT HOUR TO SEE AND READ THE INSTRUMENT PANEL. ALSO IT CAN BE 12 NOON WITH OVERCAST SKY'S OUTSIDE AND THE SENSOR CAN NOT TELL THAT IT IS NOT DARK OUTSIDE. THIS IS A HAZARDOUS AND SAFETY CONCERN DUE TO A DISTRACTION ON A DAILY BASIS OF HAVING TO TAKE YOUR EYES OFF THE ROAD WHEN DRIVING DURING THESE HOURS OR CONDITIONS. VEHICLE CAN BE MOVING OR STOPPED. SENSOR IS TOO SENSITIVE. THIS HAPPENS ALL THE TIME.

The contact owns a 2015 Chevrolet Colorado. The contact stated while driving 35 MPH, the vehicle lost power steering functionality. The contact lost control of the vehicle, with the traction control warning light illuminated. The contact restarted the vehicle, but the failure persisted. The dealer was not notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 102,000.

TL* THE CONTACT OWNS A 2015 CHEVROLET COLORADO. THE CONTACT STATED THAT THE POWER STEERING LOOSES POWER WHILE DRIVING. THE POWER STEERING, TRACTION CONTROL WARNING LIGHT ILLUMINATED. IN ADDITION, POWER STEERING INACTIVE DRIVE WITH CAUTION, AND A SHAM NOISE ACCORDED MESSAGES DISPLAYED. THE CONTACT WAS ABLE TO COASTED TO THE SIDE OF THE ROAD AND POWERED OFF THE ENGINE. THE VEHICLE WAS RESTARTED AND WAS ABLE TO DRIVE AS NORMAL. THE CONTACT STATED THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AUTONATION CHEVROLET AUSTIN DEALER (11400 RESEARCH BLVD, AUSTIN, TX 78759, (512) 592-3197) AND WAS DIAGNOSED THAT THE CO545 CODE VERIFIED TOUCH SENSOR FAULT FAILED INTERNALLY IN THE STEERING GEAR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND PROVIDED A CASE NUMBER: THE FAILURE MILEAGE WAS APPROXIMATELY 95,000. [XXX] PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *PM

Since i've had my truck the passenger seat vibrates excessively while driving; the oil alert comes on even when there is oil, current oil change; seems to not have power, shifts hard. What's interesting is that these items come up when I searched on recalls. this truck is not driven hard... mehanic cant figure out what is causing the oil alert, the passenger seat shaking excessively.. and there is a recall on You Tube Truck was purchased in [XXX], 07/15 have lived in [XXX] since 11/15. This is unacceptable INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

TL* THE CONTACT OWNS A 2015 CHEVROLET COLORADO. WHILE DRIVING 40 MPH, THE HOOD BEGAN TO SHAKE AND PARTIALLY LIFTED UP, BUT NEVER FULLY OPENED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER WHO WAS UNABLE TO DIAGNOSE OR REPAIR THE VEHICLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 1,000. UPDATED 02/05/16*LJ UPDATED 03/02/16.*JB

Driver's side front seat belt cable braking . No incident, just noticed, contacted GM and even though there is a recall for similar problems with other models they are not interested in doing anything.

LEFT REAR TIRE BLOWOUT WHILE TRAVELING SOUTHBOUND ON US HWY 550 AT MILE POST 84 OVER RED MOUNTAIN PASS. THIS IS A PARTICULARLY DANGEROUS PASS WITH STEEP DROP OFFS AND NARROW, IF ANY, SHOULDERS. DRIVER WAS ABLE TO FIND ROOM ON THE RIGHT SIDE OF ROAD TO REMOVE THE BLOWN OUT TIRE AND MOUNT THE SPARE. HAD THIS BLOWOUT OCCURRED ON ANOTHER STRETCH OF THE ROAD, DRIVER AND TRUCK WOULD HAVE GONE OVER THE EDGE. ASPHAULT PAVEMENT WAS DRY AND ICE-FREE AT THE TIME. DRIVER JUDGES THE BLOWOUT DUE TO MANUFACTURING DEFECT: PLY AND TREAD SEPARATION. TIRE WAS OEM PROVIDED WITH THE NEW TRUCK, NOT QUITE 2 YEARS OLD, AND OTHERWISE AMPLE TREAD LIFE. DRIVER HAS PHOTOGRAPHS OF THE TIRE, AND KEEPS THE TIRE IN HIS BARN FOR INSPECTION IF REQUIRED.

The contact owns a 2015 Chevrolet Colorado. The contact stated that while driving at various speeds, the transmission would intermittently hesitate upon the depression of the accelerator pedal without warning. The contact had taken the vehicle to a dealer and was informed that there were no defects with the vehicle and that the hesitation was normal vehicle operation. The manufacturer had also been notified of the failure but offered no assistance. The vehicle had yet to be repaired. The failure mileage was 15.