2005 Chevrolet Corvette Engine Problems

My car has been broken for over a year now. It has been to the dealership for the main engine wiring harness part number 19115750 which is unique to the 2005 and 2006 corvette. The failure causes several different problem. It keeps the TCM from which is the traction control module which adjust speed and traction to the wheels which is design to help drivers keep their cars under control. Without this system the car will loose traction and can cause it to go off the road. The second issue with the harness is it can put the car limp mode which restricts the speed to under 40mph which if you are driving and trying to excel into traffic this system will come in without notice and put you into a situation where if you are trying to merge or just go when the light changes it will only go like 5 mph causes the cars behind you to run into the rear of your vehicle and when if fail and you are pulling into traffic it causes your car to be in a direct line of impact with oncoming vehicle. The engine harness also provides power to the transmission via the ECM which keeps it from providing enough power to run the transmission control computer. This will make your car not go into gear or make it go completely out so without a transmission your car won’t move at all. This happens without notice. Now GM doesn’t make a replacement harness anymore making your vehicle unusable. GM also wants between 7k and 10k to make a harness for the vehicle. This doesn’t include installation. This makes the owners like myself have to seek other means to repair the vehicle. Like having a custom harness made for vehicle. Since GM only made this harness for 2 years it has been impossible for me to get my vehicle repaired at any cost. Making owner to make decisions that are unfair to owners. Like sell the car for scrap Paid the expensive repair which is like half the value of the car. Trade the car and lose thousands of dollars if you can find a dealership willing to take it

NHTSA ID

11484749

Incident

May 1, 2021

I left my driveway and got two miles up the road and with no warning lights or anything dashboard went dark and suddenly car put itself into assesory mode and car just stopped while driving. I was probably going 15 mph and luckily no one was behind me. The dash said to "shift into park" so I did then I started by pushing start button and it started right up with no problem. I can't get anyone to service vehicle because they said it is not reading any code from check engine light ect. So all I can do is hope it doesn't do this again. Scary.

NHTSA ID

11432007

Incident

Sep 6, 2021

TL* THE CONTACT OWNS A 2005 CHEVROLET CORVETTE. WHILE DRIVING AT ANY SPEED AND DEPRESSING THE ACCELERATOR PEDAL, THE VEHICLE FAILED TO ACCELERATE OVER 5 MPH. IN ADDITION, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED AND THE MESSAGES "LOSS OF POWER" AND "TRACTION CONTROL SYSTEM" WERE DISPLAYED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DETERMINED THAT THE THROTTLE BODY NEEDED TO BE REPLACED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 6,000.

NHTSA ID

11281798

Incident

Jan 1, 2016

Mileage

6,000 mi

TL* THE CONTACT OWNS A 2005 CHEVROLET CORVETTE. THE CONTACT STATED THAT AFTER PARKING THE VEHICLE, THE STEERING WHEEL SEIZED AND COULD NOT BE TURNED IN EITHER DIRECTION AND THE ENGINE COULD NOT BE IMMEDIATELY RESTARTED. AFTER THE VEHICLE WAS FINALLY RESTARTED, THE MESSAGE 'STEERING LOCKED' HAD DISPLAYED. THE VEHICLE WAS TOWED THE LOCAL DEALER GRABIAK CHEVROLET (8282 RT. 22 NEW ALEXANDRIA, PA.) THE CAUSE OF THE FAILURE WAS NOT YET DETERMINED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 52,000.

NHTSA ID

11207427

Incident

May 11, 2019

Mileage

52,000 mi

WHILE DRIVING 70+MPH ON AN INTERSTATE, "REDUCED POWER MODE" AND "SERVICE ACTIVE HANDLING" WARNINGS ILLUMINATED ON THE DIC AONG WITH THE CHECK ENGINE LIGHT. THE VEHICLE THEN COMPLETELY SHUT OFF MAKING IT EXTREMELY DANGEROUS TO GET SAFELY OUT OF THE PATHS OF OTHER VEHICLES. THIS HAS HAPPENED TO THE VEHICLE ABOUT 8 TIMES NOW IN VARYING CIRCUMSTANCES, MOSTLY WHILE IN MOTION. ERROR CODES TAKEN FROM HANDHELD PROGRAMMER INCLUDE: P1516, P2101, P2135

NHTSA ID

11103827

Incident

Jun 25, 2018

Mileage

36,000 mi

TOOK THE CAR IN FOR A CHATTER NOISE AT IDLE AND WHEN STATIONARY. I'M TOLD THAT THE TORQUE TUBE NEEDS TO BE REPLACED, THE CAR ONLY HAS 27,000 MILES AND IT SEEMS THAT THIS IS A VERY DANGEROUS THING TO HAVE HAPPEN IF IT FAILS WHY YOU ARE DRIVING IT AND IT CAUSES MAJOR DAMAGE TO THE REST OF THE DRIVE TRAIN. IT IS A MAJOR PART OF THE DRIVE TRAIN AND AN OBVIOUS DEFECT WITH THE CORVETTES AS NOTED IN THE FORUMS. A RECALL IS IN ORDER AND CHEVORLET NEEDS TO STEP UP TO THE PLATE AND REPAIR THESE TO MAKE THIS CAR SAFER BEFORE SOME ONE IS SERIOUSLY INJURED. THE REPAIR IS VERY EXPENSIVE AT AROUND 3,000. A REPAIR THAT SHOULD NEVER NEED TO BE DONE ON A LOW MILEAGE CAR.

NHTSA ID

11096397

Incident

May 14, 2018

Mileage

27,000 mi

TL* THE CONTACT OWNS A 2005 CHEVROLET CORVETTE. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000.

NHTSA ID

10968195

Incident

Mar 13, 2017

Mileage

100,000 mi

THIS INCIDENT HAPPENED 4 OR MORE TIMES. HOWEVER, THIS LAST TIME, I WAS TRAVELING AT 75 MILES PER HOUR ON THE I95. THE TRACTION CONTROL SYSTEM LIGHT CAME ON AND THEN THE CAR ENGINE DIED ON ME AS HAS HAPPENED ON A NUMBER OF OTHER OCCASIONS. I WAS IN THE LEFT LANE ON THE HIGHWAY. LUCKY FOR ME THERE WERE NO VEHICLES BEHIND OR TO THE RIGHT OF ME SO I WAS ABLE TO COAST TO A DEAD STOP ON THE SAFE SIDE OF THE ROAD SHOULDER (RIGHT). THE CAR NORMALLY WOULD START AGAIN AFTER THIS SYSTEM FAILURE. THIS TIME IT DID NOT AND I HAD TO HAVE IT TOWED TO THE NEAREST GARAGE WHICH WAS A FORD DEALERSHIP. THIS COULD HAVE BEEN VERY SERIOUS HAD IT NOT BEEN FOR LIGHT TRAFFIC. I HAVE HAD THE VEHICLE SERVICE A NUMBER OF TIMES AT GM DEALERSHIPS FOR THE ENGINE LIGHT BEING ON. THE ISSUE IS STILL UNRESOLVED. I NO LONGER HAVE CONFIDENCE IN THE VEHICLE AS TO ITS DRIVABILITY AND SAFETY.

NHTSA ID

10724037

Incident

Jun 5, 2015

Mileage

14,000 mi

ACCELERATED QUICKLY TO 35 MPH AND WHEN I REACHED THE END OF THE BLOCK I ATTEMPTED TO SLOW AND MAKE A RIGHT HAND TURN. AT THAT TIME I GOT A WARNING TO CHECK THE CHARGING SYSTEM AND NOTICED I HAD NO POWER STEERING. MANAGED TO MUSCLE THE WHEEL TO COMPLETE THE TURN (HAD IT BEEN MY WIFE THERE IS NO WAY SHE WOULD HAVE BEEN ABLE TO TURN THE WHEEL) AND CONTINUE SLOWLY DOWN THE STREET TO MY DRIVEWAY WHERE I AGAIN MUSCLED THE CAR INTO THE DRIVEWAY. DISCOVERED THAT THE MOTOR WAS RUNNING BUT THE SERPENTINE BELT WAS NOT MOVING. THUS NO ALTERNATOR, POWER STEERING ETC. I HAD MY INDEPENDENT MECHANIC CHECK IT OUT, DISCOVERED THAT THE BOLT THAT HOLDS THE HARMONIC BALANCER PULLEY ON THE CRANK SHAFT STRIPPED AND THE CRANK SHAFT WAS TURNING AND NOT MOVING THE PULLEY. HE CALLED THE DEALERSHIP TO INQUIRE ABOUT THE PARTS AND THEY SAID THEY HAVE PLENTY IN STOCK. HE THOUGHT THIS WAS SURPRISING AND THAT IT WAS NOT A SPECIAL ORDER PART. THE SERVICE MANAGER TOLD HIM THAT THEY HAVE HAD A NUMBER OF SIMILAR INCIDENTS. BOTH MY MECHANIC AND I THINK THIS SHOULD QUALIFY FOR SOME TYPE OF RECALL IF IT IS HAPPENING WITH FREQUENCY. OBVIOUSLY SOME KIND OF DESIGN FLAW AND/OR MATERIAL FLAW, PLUS THEY DIDN'T KEY THE PULLEY SO IF THE BOLT STRIPS YOU WOULD NOT LOOSE THE POWER STEERING, ETC. IF THIS HAD HAPPENED AT HIGH SPEED OR DURING THE ACTION OF TURNING I BELIEVE A SERIOUS ACCIDENT AND/OR INJURY COULD HAVE OCCURRED. COST OF THE PARTS AND REPAIR WERE $2300.00. *TR

NHTSA ID

10659609

Incident

Nov 10, 2014

Mileage

71,580 mi

MY 2005 C6 WAS STUCK IN PARK, FAULTY SOLENOID IT WILL NOT ENGAGE DOG EAR TO ALLOW YOU SHIFT OUT OF PARK, LEAVES YOU STRANDED, DEALER WANTS $800 TO REPLACE ENTIRE SHIFTER SINCE THE SOLENOID IS RIVETED TO. THERE ARE MANY C6 OWNERS DEALING WITH SAME ISSUE. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID

10604256

Incident

Jun 11, 2014

Mileage

50,561 mi

DRIVING AT 1-35 MPH ENGINE AND ELECTRICAL WILL SHUT OFF, ALL LIGHTS AND ENGINE SHUTS OFF. PUT CAR IN PARK, ENGINE STARTS RIGHT AWAY. IN 2014 GM RECALL OF 2005 COBALT AND PONTIAC FOR SAME PROBLEM, IT WAS SAID THAT SIX PEOPLE DIED. I HAVE THE SAME PROBLEM. THIS ALMOST HAPPENED TO ME. I AM AFRAID TO DRIVE THE CAR. CALLED GM AND TALKED TO A SPECIALIST NAMED SCOTT AT 1-866-790-5600 EXT. 31087 . I WAS ASKED TO TAKE THE CAR BACK TO THE DEALERSHIP, SO THEY WILL LOOK AT IT FOR THE 3RD TIME. THIS HAS BEEN GOING ON SINCE MAY 08, 2013 -- ALMOST 1 YEAR. PLEASE HELP ME BEFORE SOMETHING HAPPENS TO ME OR MY FAMILY. THE CAR IS AT JACK SCHMITT CHEVROLET, 127 REGENCY PARK DRIVE; O'FALLON IL 62269 (618) 628-2500 WWW.JACKSCHMITT.COM. *TR

NHTSA ID

10573075

Incident

May 14, 2013

Mileage

71,000 mi

ON FOUR SEPARATE OCCASIONS OVER THE LAST TWO WEEKS THE VEHICLE HAS FAILED TO START AFTER BEING TURNED OFF FOR A BRIEF PERIOD OF TIME (WHILE REFUELING THE VEHICLE, ETC.). ON 2 OF THOSE 4 OCCASIONS THE VEHICLE HAS REQUIRED TOWING TO A DEALERSHIP'S REPAIR FACILITY. ON THE FIRST OCCASION, THE VEHICLE WOULD TURN OVER BUT FAILED TO START. IT THEN MYSTERIOUSLY STARTED AGAIN AFTER SITTING AT THE GAS PUMPS OF THE GAS STATION FOR APPROXIMATELY 45 MINUTES WHILE WAITING FOR A TOW TRUCK. ON THE SECOND OCCASION, THE VEHICLE FAILED TO START BUT WAS ABLE TO BE RESTARTED AFTER PULLING AND REINSERTING THE FUEL PUMP RELAY LOCATED IN THE UNDER HOOD UBEC. ON THE THIRD OCCASION, PULLING AND REINSERTING THE FUEL PUMP RELAY HAD NO AFFECT, THE VEHICLE WOULD NOT START AND THE VEHICLE REQUIRED TOWING TO THE DEALERSHIP. THE DEALERSHIP NOTED LOOSE CONNECTIONS ON THE UBEC AND ALSO REPLACED THE FUEL PUMP RELAY. ONE DAY LATER, THE VEHICLE AGAIN FAILED TO START AND REQUIRED TOWING TO THE DEALERSHIP, WHERE THE VEHICLE IS CURRENTLY. UPON WRITING-UP THE SERVICE TICKET, THE DEALER STATED THAT THE CIRCUITS WITHIN THE UBEC ON THIS VINTAGE CORVETTE HAVE BEEN PROBLEMATIC AND THAT THE UBEC WOULD MOST LIKELY REQUIRE REPLACEMENT. ON VISUAL INSPECTION, THE UBEC APPEARS TO BE LOCATED VERY CLOSE TO THE EXHAUST MANIFOLD ON THE VEHICLE WHICH WOULD MAKE IT VERY SUSCEPTIBLE TO INTERMITTENT FAILURES OF VARIOUS UBEC COMPONENTS CAUSED BY HEAT (HEADLIGHTS, FUEL PUMP, ETC.). GM SHOULD ISSUE A VOLUNTARY RECALL TO INCLUDE A HEAT SHIELD OR SOME IMPROVEMENT IN COMPONENT DESIGN OF THE UBEC ON THIS VEHICLE. *TR

NHTSA ID

10549788

Incident

Oct 17, 2013

Mileage

47,150 mi

TL* THE CONTACT OWNS A 2005 CHEVROLET CORVETTE. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS RESTARTED, BUT AFTER DRIVING TWO MILES THE SERVICE TRACTION SYSTEM AND REDUCE POWER WARNING MESSAGES ILLUMINATED. THE VEHICLE LOST ALL POWER AND STALLED. THE CONTACT STATED THAT THE VEHICLE WOULD RESTART AFTER TEN MINUTES. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS NOT INSPECTED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE AND CURRENT MILEAGE WAS 10,500. *TR

NHTSA ID

10515473

Incident

Jun 4, 2013

Mileage

10,500 mi

UPON TAKING MY CAR IN FOR AN OIL CHANGE IT WAS DISCOVERED BY THE TECHNICIAN THAT THE BOLT HOLDING THE HARMONIC BALANCER IN PLACE HAD BACKED ITSELF OUT. THIS ALLOWED THE HARMONIC BALANCER TO DO EXCESSIVE DAMAGE TO SEVERAL ENGINE COMPONENTS INCLUDING THE OIL PAN. ACCORDING TO TECHNICIAN FIRE COULD HAVE ENSUED OR CAR COULD'VE SUFFERED A SEVERE LOSS OF TRACTION FROM THE SUBSTANTIAL OIL LEAK. GENERAL MOTORS HAS ISSUED A "TECHNICAL SERVICE BULLETIN" OUTLINING REPAIR PROCEDURES TO BE PERFORMED AT A LOCAL DEALERSHIP AT NO COST TO CUSTOMERS WITH CARS IN A SPECIFIC VIN SERIES. AFTER LOOKING UP THE TSB MY CAR IS NOT IN SAID VIN SERIES EVEN THOUGH PROBLEM IS EXACTLY AS DESCRIBED IN TSB. *TR

NHTSA ID

10475258

Incident

Sep 1, 2012

Mileage

36,000 mi

SQUEAKING NOISE FROM ENGINE ACCESSORY DRIVE BELTS, CLUNKING/ KNOCKING NOISE AT LOWER FRONT OF ENGINE. THE CRANK SHIFT BLANCER SPLIT APART MOVING BACK TO THE ENGINE. DAMAGE TO THE TIMING CHAIN COVER AND OIL PAN CAUSING OIL TO LEAK.

NHTSA ID

10472142

Incident

Oct 21, 2009

Mileage

28,000 mi

WHILE TURNING IN A CORNER ON THE HIGHWAY, I LOST POWER STEERING AND I HAD SMOKE AND DEBRIS FLYING OUT OF THE BACK OF THE CAR. LUCKILY THERE WAS NOBODY NEAR ME, AND I MANAGED TO STEER OFF THE ROAD SAFELY. LOOKED IN THE ENGINE AND THE ACCESSORY BELT WAS SHREDDED, WHICH ALSO DESTROYED THE HEAT SHIELD MATERIAL ON THE INSIDE OF THE HOOD. GOT A FRIEND TO PICK ME UP AND WE INSTALLED A NEW BELT. DROVE 0.5 MILES AND THE BELT FLEW COMPLETELY OFF THIS TIME. POWER STEERING COMPLETELY DIED, AND I COULD BARELY TURN THE WHEEL WHILE BEING TAILGATED BY CARS. COOLING SYSTEM FAILED, COOLANT FLYING ALL OVER THE ENGINE BAY, UNDER THE CAR, AND ON THE HIGHWAY. I'M GLAD I WASN'T KILLED. CHECKED ALL THE PULLEYS AND FOUND THAT THE CRANKSHAFT PULLEY BOLT HAD BACKED OUT, WHICH I LATER FOUND OUT CAUSED WOBBLE ON THE BELT AND LED THE ENGINE/CAR TO FAIL. GOT A TOW TO THE NEAREST GM DEALER. THERE ARE MANY COMPLAINTS ABOUT THIS ON INTERNET CORVETTE FORUMS, AND GM IS AWARE OF THE ISSUE (TSB #05-06-01-001A). IT SEEMS LIKE CRASHING AND CAUSING ACCIDENTS WOULD WARRANT A RECALL. *TR

NHTSA ID

10460450

Incident

Jun 2, 2012

Mileage

61,000 mi

2005 CORVETTE, 45,224 MILES. SQUEAKING NOISE FROM ENGINE ACCESSORY DRIVE BELTS, CLUNKING/ KNOCKING NOISE AT LOWER FRONT OF ENGINE. FOUND CRANKSHAFT BALANCER RETAINING BOLT BACKED OUT, CRANKSHAFT BALANCER MOVING FORWARD. HAD THIS BOLT COME OUT FURTHER, IT WOULD HAVE DAMAGED THE STEERING RACK, ACCESSORY BELTS COMING OFF, LOSS OF POWER STEERING, ELECTRICAL, BRAKING. THIS ISSUE IS KNOWN BY GM/CHEVROLET, TSB 05-06-01-001D. VEHICLE WAS FLAT BED TOWED TO DEALER, THEY DENIED THAT THERE WAS A PROBLEM WITH THE BOLT, IT JUST NEEDED NEW BELTS. AFTER THREATENING THE DEALER & GM WITH A LAWSUIT IF THE PULLEY CAME OFF AND RESULTED IN PROPERTY DAMAGE OR BODILY INJURY, THEY WOULD REPLACE THE PULLEY WITH THE UPGRADED ONE & A NEW BOLT PER THE TSB, BUT AT CUSTOMER EXPENSE. REPAIRS COMPLETED 2/10/2010. THIS VEHICLE WAS WITHIN THE VIN NUMBER RANGE FOR THE TSB, BUT THE DEALER WAS MORE CONCERNED WHERE THE PAPER COPY OF GM TSB 05-06-01-001D CAME FROM- THIS IS PUBLIC INFORMATION. PLEASE- MAKE THIS ISSUE A FORMAL RECALL BEFORE SOMEONE GETS HURT. NHTSA DATABASE SHOWS AT LEAST 6 SIMILAR INCIDENTS, MANY OTHERS HAVE NOT BEEN REPORTED TO NHTSA. *TR

NHTSA ID

10310251

Incident

Jan 20, 2010

Mileage

45,224 mi

TL* THE CONTACT OWNS A 2005 CHEVROLET CORVETTE. THE MAIN PULLEY UNDER THE VEHICLE WAS UNSTABLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION. THE TECHNICIAN STATED THAT BECAUSE THERE WERE NO ASSOCIATED RECALLS, HE WAS RESPONSIBLE FOR THE COST OF THE REPAIR. THE FAILURE MILEAGE WAS 37,000.

NHTSA ID

10294032

Incident

Nov 29, 2009

Mileage

37,000 mi

PURCHASE A 2005 CORVETTE IN 2008. SHORTLY AFTER AC DIDN'T WORK AFTER WORKING FINE JUST MOMENTS. DROVE CAR FOR A HALF A MILE OR SO AND HEARD A CLUNKING SOUND. PULLED OVER AND RAISED HOOD BUT DIDN'T NOTICE ANYTHING. AC STILL NOT WORKING BUT CAR IS NOT A DAILY DRIVER AND WINTER WAS APPROACHING SO NOT TOO CONCERN. 2009 THIS YEAR DECIDED TO GET AC CHECKED FOR THE SUMMER.....THE AC CLUTCH WAS MISSING. HINDSITE THE CLUNKING SOUND I HEARD A YEAR AGO WAS THE AC CLUTCH FALLING OFF! UNACCEPTABLE FOR ANY CAR. *TR

NHTSA ID

10278746

Incident

Aug 1, 2008

Mileage

57,000 mi

AFTER ABOUT 2.5 YEARS THE CONVERTIBLE TOP MECHANISM STARTED GETTING NOISY AND THEN REFUSED TO CLOSE ALL THE WAY. THE DEALER REPAIRED IT UNDER WARRANTY WITH A NEW ELECTRIC MOTOR AND A PUMP REPAIR KIT. ABOUT A YEAR LATER THE EXACT SAME THING HAPPENED BUT THE DEALER REFUSED TO REPAIR IT UNDER THE ORIGINAL WARRANTY SAYING THAT IT WAS A DIFFERENT PROBLEM. THIS TIME HE REPLACED ALL THE HYDRAULIC HOSES ON THE LEFT SIDE AND CHARGED ME ABOUT $900.00. I FEEL THAT THE PROBLEM WASN'T PROPERLY REPAIRED THE FIRST TIME. *TR

NHTSA ID

10265464

Incident

Feb 1, 2008

Mileage

29,137 mi

POTENTIAL LOSS OF COOLANT, ENGINE OVERHEAT, LOSS OF VISIBILITY- INSPECTING UNDER THE HOOD DURING OIL CHANGE, I FOUND THE COOLANT AIR BLEED HOSE RUBBING THROUGH ON THE BOTTOM CORNER OF THE MASS AIR FLOW SENSOR. I TWISTED HOSE AWAY AND PLACED A PLASTIC CONDUIT OVER THE HOSE IN THIS AREA. THIS IS THE SMALL HOSE (8MM ID)LEFT OF THE THROTTLE BODY LEADING FORWARD TO THE COOLANT LINES LEADING TO THE SURGE TANK. HOSE WILL BE REPLACED SOON. *JB

NHTSA ID

10168455

Incident

Sep 16, 2006

Mileage

20,419 mi

MY BROTHER SUGGESTED I REPORT THAT THE ENGINE IN MY CAR'S FRONT PULLEY COMES LOOSE AND FALLS OFF CAUSING LOSS OF ELECTRICAL PRODUCTION, A/C, AND WORST OF ALL POWER STEERING--ITS A CORVETTE-DONT KNOW IF IT HAPPENS A LOT TO OTHERS ALSO BUT MAYBE YOU WANT TO LOOK INTO IT-SEEMS TO BE A DANGEROUS SITUATION. *NM

NHTSA ID

10165357

Incident

Jul 26, 2006

Mileage

13,900 mi

DT: THE CONTACT OWNS A 2005 CHEVY CORVETTE. ON NOVEMBER 27 2004 THE VEHICLE WOULD NOT LET THEM GET INTO THE CAR AND THE ALARM WOULD NOT GO OFF. ALSO, THE COMPUTER IN THE CAR WOULD TELL THEM THAT THERE WAS NO TIRE PRESSURE AND THE TIRES WERE ON THE VEHICLE AND THE COMPUTER STATED THERE WAS NO PSI. THEY HAD TO CLIMB INTO THE HATCH TO OPEN THE DOOR BECAUSE THE DOOR WOULD NOT OPEN WITH THE KEY. ON APRIL 5, 2005 THE DEALERSHIP REPLACED THE BATTERY AND IT DID CORRECT THE PROBLEM UNTIL APRIL 12,2005 AT THAT TIME THE VEHICLE WAS TOWED BACK TO THE DEALERSHIP AND THEY STATED BASICALLY IT WAS THE BATTERY AND THE ELECTRICAL SYSTEM SAME TYPE OF PROBLEM AGAIN THIS TIME. APRIL 16, 2005 THE VEHICLE HAD TO BE JUMPED STARTED. ON APRIL 20, 2005 THE VEHICLE WAS TOWED TO THE DEALERSHIP BECAUSE THEY COULD NOT GET INTO THE VEHICLE, THE BATTERY VOLTAGE WAS SHOWING ZERO, AND THE PSI ON THREE TIRES WERE SHOWING THAT THEY DID NOT HAVE TIRES ON THE VEHICLE. ON MAY 23, 2005 WITH ONLY 2700 MILES ON THE VEHICLE WHILE DRIVING DOWN THE HIGHWAY THE SERPENTINE BELT BROKE, IT OVER HEATED, THE ENGINE HAD BLEW AND THE VEHICLE HAD TO BE TOWED. AROUND JULY 3RD OR 4TH WITH LESS THAN 3000 MILES, THE VEHICLE WOULD NOT SHIFT CORRECTLY AND IT WOULD AUTOMATICALLY STOP BECAUSE IT WOULD COME OUT OF CRUISE CONTROL, THE COMPUTER WOULD GIVE THEM STRANGE ERROR MESSAGES. WHEN THEY ARRIVED TO THE DEALERSHIP THAT IS WHEN THE HATCH ON THE BACK HAD CAME OPEN BY IT SELF AND IT HAD HAPPENED TWICE BEFORE THIS BUT THEY THOUGHT THEY HAD MAYBE ACCIDENTALLY OPENED IT. ON JULY 12, 2005 THE VEHICLE WAS PICKED UP FROM THE DEALERSHIP THE PASSENGER DRIVER SIDE WINDOW MOLDING WAS MESSED UP. THE CONTACT TOLD THEM TO KEEP THE VEHICLE UNTIL IT WAS FIXED. THEY HAVE NOTICED NUMEROUS COMPLAINTS ON THE NHTSA WEBSITE WITH THE SAME TYPE OF PROBLEMS. ALSO, ON THE VEHICLE THEY HAVE BEEN UNABLE TO PUT A FULL FUEL TANK OF GASOLINE IN THE VEHICLE SINCE DATE OF PURCHASE. SERVICE INVOICES ARE AVAILABLE IF NEEDED. *NM

NHTSA ID

10128516

Incident

Nov 27, 2004

ON JUNE 22, 2005 WHILE DRIVING AT HIGHWAY SPEED MY '05 COVETTE LOST ITS SERPENTINE BELT CAUSING THE CAR TO LOSE PWER STEERING, ENGINE OIL AND COOLENT. WITH THE LOSS OR STEERING THE CAR BECAME HARD TO STEER AND MANUVER. THIS PROBLEM HAS BEEN KNOW BY CHEVROLET THAT A SPECIFIC BOLT WAS NOT PLACED CORRECTLY DURING MANUFACTURING AND CAUSES THE LOSS OF THE SERPENTINE BELT. THIS WAS A SCARY EVENT TO LOSE STEERING AT 60MPH WITH A PASSENGER DURING THE ENDING OF RUSH HOUR TRAFFIC ON HWY114 AT 6PM. THE REPAIR IS TAKING PLACE NOW INVOLVING A NEW DIAMOND WASHER AND PROPER TORQUING OF THE BOLT. POSSIBLE ENGINE DAMAGE MAY HAVE OCCURED AND THE RELIABILITY OF THE VEHICLE IS NOW IN QUESTION. IN SOME OCCURANCES THE PROBLEM HAS HAPPENED AGAIN. I DON'T WANT IT TO BE ME AND HAVE AN ACCIDENT.

NHTSA ID

10126332

Incident

Jun 22, 2005

Mileage

9,495 mi

DRIVING NEW 2005 CORVETTE (1486 TOTAL MILES ON CAR) IN SHOPPING DISTRICT AT 35MPH. HEARD "SLAPPING" SOUND FROM UNDER THE HOOD. PULLED OVER AND FOUND THAT ONE OF THE UNDERHOOD ENGINE BELTS WAS SHREDDING. WAS AWARE OF A MANUFACTURERS TECHNICAL SERVICE BULLETIN (05-06-01-001A - FEB 8, 2005), THEREFORE THOUGHT IMMEDIATELY THAT THE PROBLEM THIS TSB ADDRESSES WAS THE PROBLEM. THE OCCURRANCE WAS UNEVENTFULL, AS I WAS DRIVING VERY SLOWLY, HOWEVER IF IT HAD BEEN AT HIGHWAY SPEEDS THIS COULD HAVE RESULTED IN LOSS OF CONTROL AND BROKEN FLUID LINES UNDER THE HOOD. ENGINE WAS DISABLED. CAR WAS FLAT-BEDDED TO LOCAL CHEVROLET DEALER WHERE IT WILL BE REPAIRED.*AK

NHTSA ID

10114543

Incident

Mar 23, 2005

Mileage

1,486 mi