2007 Chevrolet Corvette Owner Complaints

The contact owns a 2007 Chevrolet Corvette. The contact stated that while the vehicle was parked at the residence, after exiting the vehicle, the contact became aware of an abnormal fuel odor inside the vehicle. A dealer was contacted. The vehicle was not taken to the dealer or an independent mechanic to be diagnosed. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that a special coverage had expired. The failure mileage was 11,500.

NHTSA ID

11728106

Incident

Mar 26, 2026

Mileage

11,500 mi

Fuel smell - possible fuel leak - the issue had been previously addressed with replacement of fuel subassembly in both saddle tanks. I believe that it is happening again ...

NHTSA ID

11662113

Incident

May 20, 2025

There was a strong fuel smell after the last 2 times I drove it. I took it to the shop and they tell me the evap canister was saturated and the fuel pump had small cracks in it likely seeping when the car heats up. I am having the fuel pump replaced, the evap canister and several seals/hoses in hopes it won't leak again.

NHTSA ID

11661881

Incident

Apr 6, 2025

After filling the tank with fuel, I was immediately aware of a strong smell of gas. I am always extremely careful not to overfill causing any fuel to escape. The heavy smell/escape of fumes is such that the car simply can’t be put in my garage. The risk of igniting and fire is a risk that is unacceptable. General Motors knows about this issue as they did notify me in 2017 that my car could have this condition and that if it did, they would fix it at no charge. I didn’t have the issue at that time so didn’t take the car in. So, now that I the problem, I have taken the car to Bradley Chevrolet in my town, Lake Havasu City, AZ and am told that in order to inspect the car for this issue, I will have to pay for 10 hours of labor ($2200) and only then will they see if they can find a new tank at another dealer. You see, GM no longer makes or has the tanks (according to their parts department). I have contacted their Customer Service Department and have a Case (#[XXX]). I am told that they will not participate going forward unless I spend the $2200 and then if they can’t find a new tank, they will put the car back together and send me home with it! It’s my belief that since this is a documented safety defect resulting in an apparent fire hazard that they would/should take care of it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11658490

Incident

Apr 1, 2025

Fuel smell but no leaks detected, can't store car in garage because of fumes. Worried when driving a fire will occur Had a service bulletin 150682 special vehicle adjustment, need help.

NHTSA ID

11624613

Incident

Oct 3, 2024

Fuel smell inside and outside when car is parked.

NHTSA ID

11617368

Incident

Aug 30, 2024

The contact owns a 2007 Chevrolet Corvette. The contact stated while starting the vehicle, there was a loud creaking and popping noise coming from the sunroof. The dealer was contacted; however, the vehicle was not repaired. The contact was concerned about the safety of the vehicle. The manufacturer was made of the failure and advised the contact to reach out to NHSTA Hotline for assistance. The failure mileage approximately was 22,000.

NHTSA ID

11596901

Incident

Jun 26, 2024

Mileage

22,000 mi

The fuel tank leaks after filling with fuel, resulting in gas vapors filling the garage. This is a known issue with many C6 corvettes. May result in a fire or explosion

NHTSA ID

11588921

Incident

May 4, 2024

Fuel pump had hairline cacks on top. Gas leak under pressure. Strong fumes while in garage. Gas leaks down on exhaust pipes

NHTSA ID

11585706

Incident

Apr 2, 2024

There is a strong smell of gasoline coming from the outside of the car. It is strongest once the car has been sitting in my garage overnight. Some evidence of fuel under the car.

NHTSA ID

11584858

Incident

Apr 23, 2024

There is a fuel leak most likely coming from the fuel pump or gasket from within the 2 gas tanks. Gas fumes are building up in my garage causing a horrible smell. Very dangerous please do something about this. Chevrolet has no recalls for this common problems.

NHTSA ID

11580511

Incident

Mar 31, 2024

Strong fuel smell inside car as well as in garage. Drivers side tank does appear to have a leak when filled. Doing a search online it appears this is a common issue with this vehicle and that a recall/repair was created for owners however my 2007 (not the original owner) I suspect has since expired. In my opinion any defects that puts the owner and personal property at risk should be covered regardless of age.

NHTSA ID

11560888

Incident

Dec 19, 2023

Strong smell in car of gasoline and around car

NHTSA ID

11539074

Incident

Jan 1, 2022

We are having an issue with our vehicle leaking fuel on left side fuel tank. The vehicle is constant smell of gas on that left side. It has been a safety concern for us and the dealer wants us to pay at least $1200 just for diagnostic alone. There was a Special Coverage Adjustment for this issue but we were never notified. The notice is Special Coverage Adjustment 15682. I spoke with GM/Chevrolet Customer Assistance and spoke with [XXX] he said I would have to get diagnostic and that the fee could be applied to repair. I understand there is a time limit on most things but it seems that something that relates to safety issue should not have and end date. This is a type of car that most people just have as a collector car and you can see by the low miles that this is the case. I am not trying to get a repair on a vehicle that has 100,000 or more miles. It may seem trivial but this is important to me. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11534419

Incident

Jul 25, 2023

Very strong fuel smell from driver side wheel well and inside of car. When car is parked inside garage it is unbearable.

NHTSA ID

11525254

Incident

Jun 3, 2023

For last 3 years whenever I fill my vehicle with gas the garage smells of gas until the tank is less than half a tank... The other major issue is the vehicle will not come out of park multiple time. This has put me in embarrassing situations many times. I stay away from driving the vehicle so many times when I could be in physical danger .

NHTSA ID

11513993

Incident

Mar 27, 2023

The Body Control Module has failed and there are no replacement parts available except used parts. The BCM is hard coded with the VIN. If you use a BCM from another car, certain safety systems are deactivated such as the air bags. The BCM is central to the electronic architecture so all other systems are at risk. The unit can be responsible for the car not starting, the headlights not working, the power windows and door locks failing, or in my case the active suspension not functioning. Since BCM's are widely used, this is a looming major safety issue for the nation because GM quit making new ones, no one else makes these parts, no one can repair the units. I know a number of C6 Corvette owners are using used parts which deactivates the air bags and the security system.

NHTSA ID

11508512

Incident

Jan 11, 2023

I started smelling gas from my car two weeks ago. I discovered on Corvette Forum.com that this is a common problem. If the car is filled up over 1/2 tank gas will come out of the top and drip on the exhaust, which is very concerning. Chevrolet claims that the cars with this issue were recalled, but mine was not. This is one of two reoccurring issues with the C6 Corvette, and unfortunately, I am a victim of both. The other is the shifter locks in place, and the car will not come out of park. Chevrolet does not own up to the responsibility for this defective engineering as well. Please add me to the complaints for these two recallable issues as Chevrollet refuses to address the issue. Fuel dripping on the exhaust preplexes me why NHTSA has not got involved already.

NHTSA ID

11498298

Incident

Dec 15, 2022

There is a very strong fuel odor coming from the car when I shut it down, especially when I park in the garage. The smell is overwhelming. Seems like it's coming from the rear part of the car, drivers side. I don't see fuel leaking nor on the garage floor, but it is very evident there is a problem. This is a safety issue that needs to be addressed. thank you

NHTSA ID

11493555

Incident

Oct 1, 2022

Headlights suddenly stopped working.

NHTSA ID

11493055

Incident

Oct 12, 2022

The contact owns a 2007 Chevrolet Corvette. The contact stated the engine of the vehicle was replaced because he wanted to update the engine. The contact stated that once the engine was replaced the vehicle would not start. The dealer diagnosed the vehicle and stated that 5 cylinder fractured causing the engine to lock up. The manufacturer was contacted and provided no further assistance. The failure mileage was 0.

NHTSA ID

11484694

Incident

Jul 15, 2022

Every time the fuel tank is filled to full (not past the click), there is a very bad fuel smell but no fuel leaking on the ground. I bought the car with 69000 and have noticed it every time I have filled the tank to full but never past the "click". I have read of many others having the same problem. I am afraid to park my car inside my garage. I have had fuel system parts replaced but it still continues. No leak has ever been noted.

NHTSA ID

11480858

Incident

Aug 23, 2022

Smell gas around and in car. Cannot see where it is coming from no sign on ground continuing issue for at least a year. I do not use the car . Afraid of fire. My primary car has been in for repair last 30 days and I am forced to use this car

NHTSA ID

11480095

Incident

Jun 2, 2022

This particular Corvette C6 model (2005 through 2013 model years) has a well known and documented problem with the automatic transmissions. Upon engine startup, it oftentimes will not shift out of the Park gear. When the Chevrolet Customer Service people were called about this, their response was that they are well aware of this problem with the C6 model years. The Customer Service people said that a Recall was not issued because the way to address this problem is to: Shut off the engine, put the ignition in the Accessory mode, then try and shift the transmission into Neutral. If it is able to shift into Neutral, then start the engine. Once the engine starts, then try and shift the transmission into the Drive or Reverse gear. If this sequence doesn't work, we were told just to keep repeating this sequence over and over. There have been occasions when we had to repeat this sequence at least half a dozen times and there have also been occasions where we were stranded in parking lots and had to leave the car and come back to it later to try again. This is a safety concern due to the real possibility of being stranded at night in parking lots. There aren't any warning lights or messages. There also aren't any advanced warnings, in terms of symptoms. The only way the problem manifests itself, is when the car cannot be shifted out of the Park gear. Whenever the car is brought into service, including at Chevrolet dealers for such items as oil changes, the mechanics try shifting it out of the Park gear and when they can't, they will call and ask us what to do. The added concern here is that if the mechanic physically forces the shifter out of the Park gear, the entire shifter and possibly the transmission will be damaged. We are the original owners of the car and it only has 18,000 miles on it. This problem first appeared about two years ago but it is happening much more often now.

NHTSA ID

11477266

Incident

Mar 1, 2020

The airbag indicator light on the dash of the vehicle periodically lights up indicating a fault with the system. The car was checked by a dealer who could find no issue. The light resets if you cycle the vehicle on/off, but the problem returns randomly when driving the vehicle. The airbag system disabling itself without warning puts the driver at risk of not having the system deploy under conditions it should. The system resetting the warning to every on/off cycle is also misleading because unless you experience the behavior there is no reliable way to know that there is an issue with the SRS system on the vehicle.

NHTSA ID

11476661

Incident

Jul 30, 2022