2005 Chevrolet Equinox Suspension Problems

The front sub frame where it bolts to the frame was completely rusted loose on the right side. The left side was barely holding on. This is what holds the motor up and control arms. My mechanics are telling me this is a common problem with Chevy Equinoxes. If it's common why aren't there recalls. My car only has 80,000 miles on it and my mechanic told me to scrap it. I'm a fabricator and welder. I welded a new frame under it but others can't do that and mechanics say it's a no fix.

NHTSA ID

11462993

Incident

Apr 29, 2022

BRAKE WON'T RELEASES AFTER PUTING ON BRAKE PEDAL KEY FALLS OUT OF IGNITION WHILE DRIVE ING STEERING SEEMS LIKE GOING TO FALL APART WHEN TURNINGS CAT HARDLY PUT GAS IN IT CODE 0445 LARGE EVAP LEAK DETECTOR

NHTSA ID

11414716

Incident

Mar 24, 2021

Mileage

45 mi

TL-THE CONTACT OWNS A 2004 CHEVROLET EQUINOX. THE CONTACT STATED THAT SHE BOUGHT THE VEHICLE USED BACK ON 02/2019. THE DRIVE SHAFT FELL OUT OF THE VEHICLE ON 07/2019 AND AN INDEPENDENT MECHANIC DEEMED THE VEHICLE UNDRIVABLE ON 12/23/19. THE CONTACT CALLED THE STATE POLICE FOR VEHICLE FRAUD AN DWAS STILL WAITING FOR A CALLBACK. THE CONTACT ALSO CONTACTED COUNTY ATTORNEY GENERAL AN RECEIVED NO ASSISTANCE. THE CONTACT WAS REFERRED TO THE STATE'S ATTORNEY GENERAL'S OFFICE. THE MANUFACTURER HAD NOT BEEN CONTACTED YET. THE DEALER M C'S AUTO SALES 1343 CONNELLSVILLE ST, LEMONT FURNACE, PA 15456 (724) 438-0191 STATED THERE WAS NOTHING THEY COULD DO ABOUT ITAND REFUSED TO REFUND THE PURCHASE. THE DEALER TRIED TO REPOCESS THE VEHICLE THE NEXT DAY BUT WAS UNSUCESSFUL. THE FAILURE MILEAGE WAS 114,000.TF

NHTSA ID

11298077

Incident

Feb 1, 2019

Mileage

114,000 mi

100000K MILES AND THE TRANSMISSION LOCKS UP HUGE PROBLEMS WITH WHEEL BEARINGS AND PROBLEMS WITH ABS SYSTEM

NHTSA ID

11090847

Incident

Apr 1, 2018

I BOUGHT THIS CAR USED IN 2026 I HAVE NOT HAD IT A YEAR YET AND AFTER THE FIRST MONTH IT HAS BEEN IN FOR REPAIRS, THE WHEELS SOUNDS LIKE THEY ARE COMING OFF AT TIMES, IT SOUNDS LIKE SOMETHING IS DRAGGING UNDERNEATH, BRAKES SCRUBS EVEN WITH MY PLACING NEW ONE ON, SOMETIME IT FEEL LIKE TRANSMISSION IS GOING OUT, IT PULLS HARD AT TIME. EVEN THO THIS CAR IS OLD CAN I STILL TAKE IT IN FOR RECALL PROBLEMS. I WAS NOT TOLD ABOUT ANY RECALLS WHEN I BOUGHT THIS CAR, I PAID $3500 AND I FEEL I HAVE ALMOST PAID THIS MUCH IN REPAIRS,ALL OF THIS HAPPENS WHEN CAR IS IN MOTION. ON HIGHWAY​, STREETS AND IT POPS SOMETIME WHEN MAKING TURNS

NHTSA ID

10983411

Incident

Jul 3, 2016

WHEN I 1ST BOUGHT THE CAR HAD TO CHANGE THE SUSPENSION, HEAD GASKET, ANTIFREEZE IS DISAPPEARING CAN'T SEE WHERE IT'S GOING KEY COMES OUT THE IGNITION VIN#[XXX] PURCHASED ON 8/19/15. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID

10916037

Incident

May 20, 2016

TL* THE CONTACT OWNS A 2005 CHEVROLET EQUINOX. THE CONTACT STATED THAT THERE WAS WATER ENTERING THE MAP LIGHT. THE CONTACT ALSO HEARD AN ABNORMAL NOISE IN THE REAR OF THE VEHICLE, THE SUSPENSION WAS UNSTABLE PERTAINING TO THE CONTROL ARM, AND THE AXLE WAS LEAKING FLUID WITHOUT WARNING. THE STEERING WHEEL ALSO MADE A GRINDING NOISE WHEN TURNED, THE AUTOMATIC TRANSMISION HESITATED, THE THROTTLE WAS LIGHT, AND IT WAS DIFFICULT TO REVERSE UPON THE CHANGE IN WEATHER. THE VEHICLE WAS NOT REPAIRED AND THE DEALER WAS NOTIFIED OF THE VARIOUS FAILURES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES AND PROVIDED NO REMEDY. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 201,765.

NHTSA ID

10788774

Incident

Jun 8, 2015

Mileage

201,765 mi

RECEIVED VEHICLE UPON MY MOTHERS PASSING. HAD 45K ON IT, GARAGED AND ONLY IN TOWN DRIVING. IN JUST OVER YEAR I HAVE HAD TO REPLACE REAR ROCKER JOINT, AC UNIT, FRONT RIGHT SPEAKER, FRONT BRAKES AND STARTER. NOW, THERE IS A WATER NOISE UNDER HOOD AND TRUCK IS STARTING TO ROCK WHEN AT STOP LIGHT. IT IS ALSO TRYING TO RUN HOT BUT NO LIGHTS, LEAKS OR ISSUE CAN BE FOUND. THE BACK SPOILER WAS LOOSE HTTP BEFORE THEN AND LEAKS IN THE BACK. LIFT GATE HARD TO OPEN AND MOLDING AROUND FRONT WINDSHIELD IS COMING LOOSE. I HAVE 65K ON THIS TRUCK. THERE IS NO WAY THIS TRUCK SHOULD HAVE THIS MANY PROBLEMS. I FEEL UNSAFE IN THIS LIGHTLY USED AUTO. *TR

NHTSA ID

10679460

Incident

Dec 2, 2013

Mileage

46,000 mi

PLEASE NOTE IN ORDER TO TRY TO AVID AN ACCIDENT IN WHICH NARDONE ELECTRIC TRUCK,BROADSIDED MY DRIVER SIDE ON A COMPLETE SCREPEDOWN ON MY VEHICLE, AND AFTERWARD AFTER I LEFT THE EXPRESSWAY 93 N IN BOSTON ,15 MINUTES LATER AFTER I STOPPED AT A CONVENIENCE STORE,MY VEHICLE WOULD NOT TURN LEFT OR RIGHT ONLY STRAIGHT... *TR

NHTSA ID

10633273

Incident

Feb 17, 2014

Mileage

88,000 mi

DRIVING DOWN STREET CUT OFF BY SEMI RAN INTO FLASHING SIGN WITH NOWHERE ELSE TO GO. OVER HALF PASSENGER FRONT BUMPER WAS CRUSHED RADIATOR SMASHED, WHOLE FRONT PASSENGER QUARTER SMASHED. CAR WAS UNDRIVEABLE BUT AIR BAGS DID NOT GO OFF. *TR

NHTSA ID

10597688

Incident

Oct 31, 2005

Mileage

30 mi

PLEASE NOTE I HAVE BEEN COMPLAINING ABOUT THIS VEHICLE WITH OTHER PROBLEMS HAS BAD FRONT END PARTS .THIS TIME IT WAS DIAGNOSED WITH FRONT END PARTS THAT COULD FALL OFF FRONT GEARS ETC,I HAD JUST SPENT OVER $1000 ON THE FRONT END .THIS VEHICLE IS A PIECE A JUNK I WANT CHEVY TO FIX AT THEIR DEALER FOR FREE HERE IN MASS AT [XXX] MY PHONE NUMBER. ANOTHER ONE OF CHEVY BONEHEAD DEFECTS. MY ADDRESS IS [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR UPDATED 12/9/2014 *JS *TR

NHTSA ID

10592513

Incident

Feb 17, 2014

Mileage

89,584 mi

WHILE DRIVING I HEAR A WHIRRING SOUND THAT VARIES WITH SPEED I AM DRIVING, THEN TURNS TO GRINDING. TAKE TO INDEPENDENT GARAGE (HARLOW TIRE) THEY REPLACE R FRONT WHEEL BEARING. AT COST OF APROX $379.00. ON MAY 3, 2013 I HEAR A SIMILAR SOUND, THINKING THE LEFT WHEEL BEARING MAYBE GOING I TAKE BACK TO SAME SHOP. IT TURNS OUT IT IS THE SAME ONE THEY REPAIRED R FRONT. THEY REPAIRED AT NO CHARGE. MILEAGE AT 2ND REPAIR 121778. *TR

NHTSA ID

10557210

Incident

Mar 4, 2013

Mileage

120,129 mi

MY CENTER BEARINGS WERE REPLACED ABOUT 3YRS AGO THOUGHT IT WAS A FLUKE THOUGH I HAD HEARD FROM MANY PEOPLE THAT THIS WAS AN ONGOING PROBLEM. CLUNKING BEGAN UNDER MY CAR AGAIN SO I KNEW WHAT IT WAS. TOOK IT TO THE MECHANIC AND THE CENTER BEARINGS WERE BROKE AGAIN AND THE BEARINGS AND THE BACK OF THE DRIVESHAFT ALSO. THE REAR U JOINT WAS ALSO BROKEN. THIS IS RIDICULOUS AS WELL AS DANGEROUS. I TAKE GOOD CARE OF MY CAR NO RUNNING OVER LOGS IN THE WOODS OR THINGS OF THAT NATURE HOW CAN THIS KEEP HAPPENING UNLESS IT IS A DEFECT OR FLAW IN DESIGN.THIS TIME WITH THE CLUNKING MY ANTI LOCK BRAKES WERE GOING OFF EVERY TIME I STOPPED TOO.MECHANIC HAD A HARD TIME GETTING THE PARTS TO REPLACE APPARENTLY EVERYONE NEEDS THEM BUT CHEVY SEES NO PROBLEM WITH THIS. *TR

NHTSA ID

10548845

Incident

Oct 14, 2013

Mileage

120,000 mi

NOT SURE OF EXACT FIRST DATE CLUNKING SOUNDS UNDER CAR TOOK IT IN AND THE BEARINGS THAT HOLD THE DRIVE SHAFT WERE BROKEN. MECHANIC SAID NEVER SAW SOMETHING LIKE THAT ON A CAR WITHOUT ANY OTHER DAMAGE AND THAT WHEN HE CHECKED WITH LOCAL DEALER WAS TOLD THAT IT WAS HAPPENING A LOT. I REPORTED TO CHEVY ALSO AND YET THEY SAID THERE WERE NO PROBLEMS. *TR

NHTSA ID

10548844

Incident

Jun 15, 2010

Mileage

85,000 mi

THIS VEHICLE IS A JOKE, I ALREADY PUT MONEY DOWN ON IT AND HAVE ONLY HAD IT A LITTLE OVER 2 WEEKS. 5 DAYS IT WAS ACTUALLY IN MY POSSESSION BUT NOT ABLE TO DRIVE IT MUCH. THE REST OF THE TIME IT WAS AT THE CAR LOTS MECHANIC, IT DIES DRIVING DOWN THE ROAD, IT IS HARD TO START AND SOMETIMES WON'T START AFTER 10 TRIES, IT IS SHIFTING HARD AND NOT WHEN IT IS NECESSARY( DOWN SHIFTING WHEN SPEEDING UP) AND IT HAS A HORRIBLE NOISE COMING FROM THE FRONT DRIVER SIDE WHICH THE MECHANIC CAN'T FIGURE OUT. NOT TO MENTION THAT THE FUEL PUMP WILL NEED TO BE REPLACED THANKS TO THE FUEL GAUGE NOT WORKING PROPERLY... I FEEL LIKE I JUST MADE A VERY COSTLY MISTAKE( I STILL OWE 6900 ON THIS VEHICLE... ) CHEVY SHOULD BE ASHAMED OF THIS VEHICLE AND SHOULD BE FIXING THESE PROBLEMS. *TR

NHTSA ID

10546955

Incident

Sep 29, 2013

Mileage

132,645 mi

PROBLEM WITH SWAY BAR LINKS, REPLACED TWICE. STILL PROBLEM WITH FRONT END AS CHEWED UP TIRES...REPLACED STRUTS,STEERING SHAFT,BRAKES FRONT& BACK. FRONT END AND BRAKE PROBLEMS... COST ME OVER $3500 TO THIS POINT,PLUS HEAD& REAR SEAL GASKETS... *TR

NHTSA ID

10525294

Incident

Oct 24, 2006

Mileage

34,000 mi

MY REMOTE WOULD NOT LOCK THE DOORS. REPLACED BATTERIES. IT WOULD LOCK AND UNLOCK ONCE. THEN NOTHING. FUSE BLOWN. REPLACE FUSE. WORK ONCE, BLOW FUSE. TOOK TO DEALER AFTER 3 MONTHS OF NOT BEING ABLE TO ACCESS MY TRUNK SPACE, YOU CAN'T OPEN FROM INSIDE OR OUTSIDE WITHOUT REMOTE. A WIRE INSIDE THE PASSENGER DOOR HAD SOMEHOW BEEN SEVERED??? HOW DOES THAT HAPPEN. $685 TO FIX.... NEXT HUGE ISSUE: DRIVING DOWN ROAD.. FRONT END GONE???? STRUTS, LINKS...$1100 CAR WON'T START ...HAVE TO GIVE IT GAS, SEEN A LOT OF THESE WITH NO IDEA WHAT'S WRONG. WELL DEALERSHIP SAYS ITS FUEL PRESSURE SENDING UNIT, BAD INJECTORS... GRAND TOTAL TO FIX $2000.. IN WHAT WORLD SHOULD A VEHICLE THAT DOES NOT EVEN 100K MILES ON IT HAVE SO MANY COSTLY FIXES......I LOOKED ON HERE TO SEE IF ANYONE ELSE IS HAVING THE STARTING ISSUE.. SEEMS TO BE A LOT OF PEOPLE. *TR

NHTSA ID

10497834

Incident

Sep 3, 2012

Mileage

78,000 mi

CARRIER BEARING FAILED ON CHEVROLET EQUINOX. THIS APPEARS TO BE A WIDESPREAD PROBLEM WITH 2005 EQUINOX. THIS IS A POTENTIAL SAFETY ISSUE THAT SHOULD BE RECALLED AND REPAIRED BY GM. *TT

NHTSA ID

10462734

Incident

Jun 21, 2012

Mileage

65,000 mi

REAREND WENT OUT DRIVING WITH MY BABY DAUGHTER IN CAR, NO WARNING WHATSOEVER! JUST BOUGHT 6 MONTHS AGO NOW I HAVE A LARGE LOAN AND NO CAR, WILL NOT BUY ANOTHER CHEVY. *TR

NHTSA ID

10460860

Incident

Jun 5, 2012

CAR DOESN'T START ON FIRST ATTEMPT. IT TRIES, THEN EVEN AFTER I RELEASE THE KEY IT CONTINUES TO START, LIKE ITS STUCK, I HAVE TO PUMP THE GAS TO GET IT TO START, AND IT ACTS FLOODED. I HAVE SPENT CLOSE TO $5000.00 DOLLARS, BRAKES, WHEEL BEARINGS, EMERGENCY BRAKE. THE FRONT END BEGAN TO FEEL VERY LOOSE. THE PROBLEM WAS THAT THE STRUTS PREMATURELY FAILED AND CREATED A VERY DANGEROUS DRIVING CONDITION. REPLACED MOUNTS STRUTS ETC ETC THIS CAR HAS BEEN A NIGHTMARE I BOUGHT THIS CAR NEW OUT OF THE DEALER. 2005 NEW PROBLEM STEERING WHEEL IS MAKING A GRINDING NOISE DEALER IS SAYING $1300.00 TO REPAIR IT WHEN DOES IT STOP GM / CHEVY NEEDS TO FIX THIS CARS AT NO COST. *TR

NHTSA ID

10454856

Incident

Jan 31, 2012

TL* THE CONTACT OWNS A 2005 CHEVROLET EQUINOX. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, THE ABS AND TRACTION LIGHTS ILLUMINATED AND WHEN DEPRESSING THE BRAKES, THE VEHICLE WOULD EXHIBIT A LOUD GRINDING NOISE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY ADVISED HER THAT THEY WOULD REPLACE THE BRAKES AND A HUB BEARING FAILURE. THE VEHICLE WAS LATER TAKEN TO THE DEALER AND THEY ADVISED THE CONTACT THAT THEY WOULD REPLACE THE HUB BEARINGS. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED SEVERAL MONTHS LATER. THE VEHICLE WAS TAKEN BACK TO THE DEALER AND THEY OFFERED NO ASSISTANCE. THE MANUFACTURER WAS LATER CONTACTED AND THEY ALSO OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 126,000. THE VIN WAS UNAVAILABLE.

NHTSA ID

10450602

Incident

Oct 15, 2011

Mileage

126,000 mi

THE CARRIER BEARING IS FAULTY ON 2005 EQUINOXES. OUR MECHANIC TOLD US THIS IS A HUGE PROBLEM BECAUSE IT COULD CAUSE THE CAR TO FLIP OVER. THE MAJOR ISSUE IS THAT TO REPAIR THE CARRIER BEARING, THEY HAVE TO REMOVE AND REPLACE THE DRIVE SHAFT. THIS HAS TO BE SENT TO CHEVROLET, AND SINCE IT CAN ONLY BE DONE BY THEM, THEY HAVE A STRONG ARM ON THE PRICE. ($1200) IT IS EVIDENT THAT THIS IS A MANUFACTURING DEFECT BECAUSE WHEN I BEGAN TO GOOGLE 'DRIVE SHAFT CHEVY', IT GAVE ME 2005 EQUINOX AS A SUGGESTION. THE YEAR WAS SPECIFIC IN THE PROBLEM. *TR

NHTSA ID

10436380

Incident

Jan 1, 2009

Mileage

50,000 mi

CAR DOESN'T START ON FIRST ATTEMPT. IT TRIES, THEN EVEN AFTER I RELEASE THE KEY IT CONTINUES TO START, LIKE ITS STUCK, I HAVE TO PUMP THE GAS TO GET IT TO START, AND IT ACTS FLOODED. ABS AND TRACTION CONTROL LIGHTS ON. WHEN I PRESS ON THE BRAKES IT FEELS STUCK AT THE TOP AND GRINDS AND PULSATES EVEN THOUGH MY BRAKES ARE GOOD. I'VE HAD MY SPEED SENSORS REPLACED TWICE , PROBLEM STILL ONGOING. I HAVE TO PUSH WITH ALL MY WEIGHT FOR THE BRAKES TO "BREAK THROUGH" WHAT EVER ITS STUCK ON AND WORK, THEN THEY LOCK UP. THAT'S WHEN THE ABS/TRACTION CONTROL LIGHTS COME ON, THEN I KNOW THE ABS IS NOT TRYING TO WORK AND MY BRAKES WILL STOP ME. I'VE ALMOST CRASHED INTO THINGS TOO MANY TIMES. *TR

NHTSA ID

10435594

Incident

Feb 12, 2010

Mileage

30,000 mi

THIS COMPLAINT IS IN REGARDS TO THE 2005 CHEVROLET EQUINOX. THIS VEHICLE WAS PURCHASED USED IN AUGUST 2009 WITH ROUGHLY 42000 MILES FROM CARMAX IN DULLES, VA. SINCE THE PURCHASE OF THIS VEHICLE, I HAVE SPENT NEARLY 3000 DOLLARS IN REPAIRS AS IT SEEMS THAT PARTS ARE WEARING OUT OR MALFUNCTIONING FAR EARLIER THAN TYPICAL. AT ABOUT THE 60000 MILE MARK, ALL FOUR ROTORS AND BRAKES NEEDED TO BE REPLACED DUE TO THE ROTORS BEING WARPED. I WAS TOLD BY THE MECHANIC THAT THIS IS NOT COMMON AND SHOULD NOT HAVE HAPPENED AT THIS TYPE OF MILEAGE. COST FOR THIS REPAIR WAS ABOUT $500. TIRES HAVE NEEDED TO BE REPLACED TWICE SINCE THE PURCHASE OF THIS VEHICLE; ONCE AROUND 60000 MILES DUE TO "UNEVEN WEAR" WHICH WAS LIKELY A RESULT OF THE BAD ROTORS, AND AGAIN AROUND THE 100000 MARK ALSO FOR "UNEVEN WEAR". THIS COST $400 ON EACH OCCASION. AT THE 80000 MILE MARK A LOUD KNOCKING NOISE WAS HEARD COMING FROM THE FRONT END, AND PROCEEDED TO GET WORSE UP TO THE 100000 MILE MARK. BETWEEN THOSE MILEAGE MARKS, THE FRONT END BEGAN TO FEEL VERY LOOSE. THE PROBLEM WAS THAT THE STRUTS PREMATURELY FAILED AND CREATED A VERY DANGEROUS DRIVING CONDITION. THE COST FOR THIS REPAIR WAS OVER $1300 AND WAS REPAIRED ON JUNE 27, 2011. AFTER DOING A BIT OF RESEARCH, I DISCOVERED THAT THIS IS A VERY PROMINENT AND COMMON PROBLEM FOR THIS YEAR, MAKE, AND MODEL. ON TOP OF THESE ISSUES, THERE IS ALSO APPARENTLY A PROBLEM WITH THE REAR END AS WELL THAT IS ALSO CREATING A KNOCKING. ALSO, THE DAYTIME RUNNING LIGHTS HAVE BEGUN TO FLASH REPEATEDLY AND VERY QUICKLY AT RANDOM TIMES AS WELL AS TURNING THEMSELVES ON AND OFF. THE CD PLAYER ALSO BROKE. I FEEL THAT THIS IS A VERY UNSAFE AND UNRELIABLE VEHICLE THAT SHOULD BE INVESTIGATED TO DETERMINE WHETHER THIS IS TRULY DUE TO "WEAR AND TEAR", OR IF THIS IS A FACTORY FAULT. *TR

NHTSA ID

10410137

Incident

Jun 24, 2011

Mileage

80,000 mi

MY 2005 CHEVY EQUINOX'S BRAKES STARTED VIBRATING WHEN I WOULD TRY TO STOP AND THEN THE ABS AND TC LIGHTS WOULD COME ON. REPLACED FRONT BRAKES, WAS TOLD BACK BRAKES WERE OKAY. STILL HAD THE SAME PROBLEM AND AFTER AWHILE THE BRAKES WOULD VIBRATE EVEN WHEN NOT BREAKING AND SOMETIMES HAVE TROUBLE STOPPING UNTIL THE ABS AND TC LIGHT COMES ON. 1ST DIAGNOSTIC DETERMINED I NEEDED A RIGHT FRONT WHEEL SPEED SENSOR. REPLACED IT AND 2 DAYS LATER HAD THE SAME PROBLEM. NEXT I WAS TOLD IT NEEDED THE LEFT WHEEL SPEED SENSOR. REPLACED IT. 2 DAYS LATER STARTING HAVING THE SAME PROBLEM. THEN I WAS TOLD IT NEEDED THE RIGHT FRONT WHEEL BEARING. REPLACED BOTH FRONT WHEEL BEARINGS. STILL HAVE A PROBLEM ONLY NOW THE BRAKES ONLY VIBRATE AND LIGHTS COME ON HILLS, WHEN TURNING OR GOING AT HIGHER SPEEDS. *TR

NHTSA ID

10406208

Incident

Apr 1, 2011

Mileage

82,000 mi